NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
9 reportsClear category filter24,410 miles · Feb 27, 2014
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
FORD VEHICLE LOST POWER AND STOPPED RUNNING WITH FULL TANK OF FUEL. WOULD NOT RESTART, HAD TOWED TO REPAIR SHOP. REPLACED FUEL PUMP FOR $606.99. DROVE ABOUT A MILE AND SAME THING HAPPENED AGAIN. FOUND THAT THE FUEL INERTIA SHUT OFF SWITCH NEEDED RE-SETTING. BOUGHT A FUEL PUMP I DIDN'T NEED. THIS HAS HAPPENED MULTIPLE TIMES THIS …
Read full complaint
FORD VEHICLE LOST POWER AND STOPPED RUNNING WITH FULL TANK OF FUEL. WOULD NOT RESTART, HAD TOWED TO REPAIR SHOP. REPLACED FUEL PUMP FOR $606.99. DROVE ABOUT A MILE AND SAME THING HAPPENED AGAIN. FOUND THAT THE FUEL INERTIA SHUT OFF SWITCH NEEDED RE-SETTING. BOUGHT A FUEL PUMP I DIDN'T NEED. THIS HAS HAPPENED MULTIPLE TIMES THIS YEAR AGAIN. FORD DEALER SAID I NEEDED A FUEL PUMP. (35,000 MILES) AGAIN, NO WAY. THE REPLACEMENT PART (INERTIA SWITCH) MOVES THE SWITCH FROM PASSENGER FLOOR AREA TO SIDE KICK PANEL. THE DESIGN CHANGE SHOWS DESIGN FLAW. FORD SHOULD REPLACE FOR NO COST. VERY DANGEROUS WHEN ENGINE DIES.
NHTSA ODI #10568429
43,000 miles · Jul 6, 2011
Fuel System, Gasoline
DRIVING DOWN NJ GSP AND 2006 FORD RANGER ENGINE STOPPED COLD IN HEAVY TRAFFIC. FUEL CUT OFF SWITCH ACTIVATED. *TR
NHTSA ODI #10410633
45,000 miles · Aug 2, 2010
Fuel System, Gasoline
APPROXIMATELY EIGHT MONTHS AGO MY VEHICLE STALLED AND WOULD NOT RESTART. IT WAS TOWED TO A DEALER AND APPROXIMATELY $300 LATER I WAS TOLD THAT THE INERTIA SWITCH HAD FAILED AND HAD BEEN REPLACED. TWO DAYS AGO THE SAME SYMPTOMS APPEARED AND THE VEHICLE WAS TOWED TO THE DEALER AGAIN. I DID SOME INTERNET SEARCHING AND FOUND INFO AN…
Read full complaint
APPROXIMATELY EIGHT MONTHS AGO MY VEHICLE STALLED AND WOULD NOT RESTART. IT WAS TOWED TO A DEALER AND APPROXIMATELY $300 LATER I WAS TOLD THAT THE INERTIA SWITCH HAD FAILED AND HAD BEEN REPLACED. TWO DAYS AGO THE SAME SYMPTOMS APPEARED AND THE VEHICLE WAS TOWED TO THE DEALER AGAIN. I DID SOME INTERNET SEARCHING AND FOUND INFO AND A YOUTUBE VIDEO THAT EXPLAINED WHERE TO FIND THE SWITCH AND HOW TO RESET IT. WENT TO THE DEALER AND ATTEMPTED THE RESET IN THEIR PARKING LOT BEFORE THEY COMPLETED ANY COSTLY REPAIRS. VEHICLE STARTED AND HAS WORKED FINE SINCE. POSSIBILITY OF STALLING IN TRAFFIC IS A CONCERN BUT I'LL TAKE MY CHANCES!! NOTEWORTHY THAT A CLOSE FRIEND WHO OWNS AN OLDER MODEL MAZDA PICKUP RECENTLY HAD THE EXACT SAME PROBLEM WITH THE INERTIA SWITCH REPLACED. *TR
NHTSA ODI #10346718
50,600 miles · Mar 8, 2010
Fuel System, GasolineVehicle Speed ControlCrash
I WAS PULLING INTO SHERRY'S MINI MART IN DOE RUN, MO WHEN I REALIZED THAT MY TRUCK WAS NOT SLOWING DOWN AS EXPECTED, EVEN THOUGH I HAD MY FOOT ON THE BRAKE. I HAD LITTLE TIME TO REACT AS I WAS BEARING DOWN ON THE BUILDING. I PUT MY OTHER FOOT ON THE BRAKE BUT THE TRUCK CONTINUED TO MOVE FORWARD, EVEN SPINNING THE TIRES TRYING T…
Read full complaint
I WAS PULLING INTO SHERRY'S MINI MART IN DOE RUN, MO WHEN I REALIZED THAT MY TRUCK WAS NOT SLOWING DOWN AS EXPECTED, EVEN THOUGH I HAD MY FOOT ON THE BRAKE. I HAD LITTLE TIME TO REACT AS I WAS BEARING DOWN ON THE BUILDING. I PUT MY OTHER FOOT ON THE BRAKE BUT THE TRUCK CONTINUED TO MOVE FORWARD, EVEN SPINNING THE TIRES TRYING TO OVERCOME THE BRAKES. I JUMPED THE CURB AND HIT THE BUILDING AT A VERY LOW SPEED. AT THIS TIME I MANAGED TO POP IT OUT OF GEAR. I DID NOT GO THROUGH THE WALL, BUT PUSHED IT IN ABOUT A FOOT. MY AIRBAGS DID NOT DEPLOY. MOST OF THE DAMAGE WAS TO THE WALL AND THE INTERIOR OF THE BUILDING. THERE WAS LITTLE DAMAGE TO MY TRUCK OTHER THAN A FEW SCRATCHES ON THE BUMPER. LUCKILY NO ONE WAS WALKING IN FRONT OF ME OR NEAR THE INSIDE OF THE BUILDING. THIS WAS THE ONLY TIME THIS HAS OCCURRED IN THE 50,000 MILES THAT I HAVE OWNED THIS TRUCK AND IT HAS NOT HAPPENED IN THE DAYS FOLLOWING. I TOOK MY TRUCK TO MY FORD DEALER THE NEXT MORNING AND THEY CLAIM THEY COULD FIND NOTHING WRONG. THEY COULD FIND NO FAULT CODES IN THE COMPUTER AND CONFIRMED THAT THERE WAS NO DAMAGE OTHER THAN THE SCRATCHES ON THE BUMPER. THEY DID IMPLY THAT I WAS HITTING THE ACCELERATOR PEDAL WITH THE SIDE OF MY FOOT WHILE BRAKING. I STRONGLY DISAGREE WITH THEIR IMPLICATION AND HAVE WITNESSES WHO SAW MY EFFORTS TO STOP THE TRUCK. *TR
NHTSA ODI #10317699
55,800 miles · Feb 15, 2010
Electrical SystemFuel System, Gasoline
INERTIA SWITCH IN 2006 FORD RANGER CAUSES TRUCK TO STALL RANDOMLY. SWITCH IS LOCATED ON PASSENGER-SIDE IN COMPARTMENT BY THE FOOT. THIS RANDOM STALLING IS ESPECIALLY DANGEROUS WHILE IN THREE LANE TRAFFIC, RAILROAD CROSSINGS, INTERSECTIONS, BRIDGES, ETC.. THIS SWITCH IS DESIGNED TO CUT ELECTRIC TO FUEL PUMP IN CRASH BUT MOST O…
Read full complaint
INERTIA SWITCH IN 2006 FORD RANGER CAUSES TRUCK TO STALL RANDOMLY. SWITCH IS LOCATED ON PASSENGER-SIDE IN COMPARTMENT BY THE FOOT. THIS RANDOM STALLING IS ESPECIALLY DANGEROUS WHILE IN THREE LANE TRAFFIC, RAILROAD CROSSINGS, INTERSECTIONS, BRIDGES, ETC.. THIS SWITCH IS DESIGNED TO CUT ELECTRIC TO FUEL PUMP IN CRASH BUT MOST OFTEN FAILS DURING NORMAL DRIVING OPERATION. THIS IS NOT A UNIQUE COMPLAINT TO 2006, BUT BY OTHER YEARS REPORTED ON THE INTERNET. THIS PROBLEM HAS EXISTED FOR MANY YEARS AND IS PROBABLY RESPONSIBLE FOR MORE DEATHS DUE TO ERRANT OPERATION THAN IT SAVED LIVES IN A CRASH. ANOTHER EXAMPLE OF WHAT SEEMS LIKE A GOOD IDEA GONE BAD. *TR
NHTSA ODI #10310641
35,000 miles · Jan 4, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THE FUEL PUMP SHUT OFF SWITCH ACTIVATED WHICH CAUSED THE ENGINE TO SHUT OFF WHILE HE WAS DRIVING. THE CONTACT STATED THAT THE FAILURE OCCURS WHENEVER THE SPEED INCREASED TO 30 MPH WHILE DRIVING. THE DEALER WAS CONTACTED AND THEY WERE UNABLE TO ASSIST HIM SINCE ALL O…
Read full complaint
TL*THE CONTACT OWNS A 2006 FORD RANGER. THE CONTACT STATED THAT THE FUEL PUMP SHUT OFF SWITCH ACTIVATED WHICH CAUSED THE ENGINE TO SHUT OFF WHILE HE WAS DRIVING. THE CONTACT STATED THAT THE FAILURE OCCURS WHENEVER THE SPEED INCREASED TO 30 MPH WHILE DRIVING. THE DEALER WAS CONTACTED AND THEY WERE UNABLE TO ASSIST HIM SINCE ALL OF THE COMPUTERS WERE INOPERABLE. THE FAILURE MILEAGE WAS 35,000. UPDATED 02/02/10 *BF UPDATED 02/05/10. *JB
NHTSA ODI #10298017
32,172 miles · Nov 20, 2008
Fuel System, Gasoline
I OWN A 2006 RANGER 3.0 AUTO. THAT HAS 35,300 MI. THE FUEL DELIVERY INERTIA SWITCH HAS KICKED OUT UNDER NORMAL DRIVING CONDITIONS TWICE. FIRST TIME AT 32,172 MI. AND HAD TO BE TOWED TO A DEALER. THE TECHNICIAN RESET THE SWITCH AND I HAD NO PROBLEMS UNTIL 35,100 MI. THIS TIME I WAS LUCKY ENOUGH TO BE IN A PARKING LOT, INSTEAD OF …
Read full complaint
I OWN A 2006 RANGER 3.0 AUTO. THAT HAS 35,300 MI. THE FUEL DELIVERY INERTIA SWITCH HAS KICKED OUT UNDER NORMAL DRIVING CONDITIONS TWICE. FIRST TIME AT 32,172 MI. AND HAD TO BE TOWED TO A DEALER. THE TECHNICIAN RESET THE SWITCH AND I HAD NO PROBLEMS UNTIL 35,100 MI. THIS TIME I WAS LUCKY ENOUGH TO BE IN A PARKING LOT, INSTEAD OF OUT IN MOVING TRAFFIC. WHEN TIS HAPPENS, THE ENGINE, OF COURSE, DIES IMMEDIATELY. THE SWITCH CANNOT BE RESET WHILE SITTING IN THE DRIVER'S SEAT. THE DEALER WILL NOT REPLACE AS THEY CANNOT FAIL THE SWITCH DURING " THEIR" ROAD TEST. *TR
NHTSA ODI #10249368
21,219 miles · Feb 27, 2008
Engine And Engine CoolingFuel System, Gasoline
NO EVENT LEADING UP TO FAILURE. ENGINE JUST QUIT. NO WARNING OF ANY KIND. ENGINE WOULD QUIT AND OPERATOR WOULD HAVE TO WAIT BEFORE RESTARTING. AT ONE POINT THE VEHICLE DID NOT RESTART WITHOUT THE HELP OF A DEALERSHIP MECHANIC SEVERAL DEALERSHIPS REPLACED THE FUEL PUMP. FUEL PUMP REPLACED TWICE. *TR
NHTSA ODI #10219312
3,500 miles · Mar 1, 2007
Electrical SystemFuel System, Gasoline
I WAS IN STOP AND GO TRAFFIC IN MY 2006 FORD RANGER WITH APPROXIMATELY 3500 MILES ON IT WHEN ENGINE SPUTTERED AND STOPPED AS I TRIED TO ACCELERATE. THE GAS TANK WAS NEAR FULL AND THE TRUCK WOULD NOT RESTART AFTER I COASTED ACROSS A LANE OF MOVING TRAFFIC ONTO THE MEDIAN. HAVING EXPERIENCED A SIMILAR PROBLEM IN MY 1986 RANGER, …
Read full complaint
I WAS IN STOP AND GO TRAFFIC IN MY 2006 FORD RANGER WITH APPROXIMATELY 3500 MILES ON IT WHEN ENGINE SPUTTERED AND STOPPED AS I TRIED TO ACCELERATE. THE GAS TANK WAS NEAR FULL AND THE TRUCK WOULD NOT RESTART AFTER I COASTED ACROSS A LANE OF MOVING TRAFFIC ONTO THE MEDIAN. HAVING EXPERIENCED A SIMILAR PROBLEM IN MY 1986 RANGER, I CALLED THE DEALER SERVICE CENTER TO ASK WHERE THE FUEL SAFETY SHUT OFF SWITCH WAS LOCATED. AFTER BEING ASSURED THAT THE SWITCH COULD NOT BE THE PROBLEM UNLESS I HAD BEEN IN A COLLISION OR HIT A VERY LARGE POT-HOLE, I RESET THE SWITCH AND THE TRUCK STARTED. THE SWITCHES IN THESE TRUCKS APPARENTLY HAS A DEFECT THAT HAS NOT BEEN CORRECTED FOR 20 YEARS. THE SERVICE PEOPLE SEEM TO BE UNAWARE OF THE ISSUE AND I SUSPECT THAT MANY PEOPLE HAVE BEEN SOLD FUEL PUMPS AND OTHER RELATED ITEMS THAT WERE NOT THE PROBLEM. I AM JUST GLAD IT DIDN'T HAPPEN AT 65 MPH. *JB
NHTSA ODI #10183920
Official recalls
12Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement front passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall expands and replaces previous recall number 23V-125.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement frontal passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed April 5, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall has been fully superseded by recall 23V-306.
Feb 17, 2021
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with passenger-side air bag inflators. As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles built with passenger-side air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the passenger side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with driver-side air bag inflators . As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the front driver side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 16V-036 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 15V322 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42.
Jan 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger vehicles manufactured March 24, 2003, to May 4, 2006. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the air bag inflators, free of charge. The recall began February 26, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S03. Note: This recall supersedes 14V-343 and only applies to Rangers manufactured in North America.
May 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger trucks manufactured March 24, 2003, to May 4, 2006. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on December 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S22. Note: This recall partially supersedes recall 14V-787.
Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Nov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration