NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
576 reportsMileage unknown · Jun 13, 2011
Latches/locks/linkages
1998 FORD RANGER HAS SECURITY ISSUE WHICH ALLOWS ANY INDIVIDUAL TO USE A TO UNLOCK THE DOOR AND NO ONE WOULD EVEN KNOW IT UNTIL YOU FIND YOUR STUFF MISSING. ALL IT TAKES IS A SCREW DRIVE UNDER THE DOOR HANDLE TO UNLOCK THE DOOR AND GAIN ENTRY. THIS IS COMMON TO MOST ALL RANGERS AND IT IS HARD TO REPORT ANY LOSS WITHOUT PROOF THA…
Read full complaint
1998 FORD RANGER HAS SECURITY ISSUE WHICH ALLOWS ANY INDIVIDUAL TO USE A TO UNLOCK THE DOOR AND NO ONE WOULD EVEN KNOW IT UNTIL YOU FIND YOUR STUFF MISSING. ALL IT TAKES IS A SCREW DRIVE UNDER THE DOOR HANDLE TO UNLOCK THE DOOR AND GAIN ENTRY. THIS IS COMMON TO MOST ALL RANGERS AND IT IS HARD TO REPORT ANY LOSS WITHOUT PROOF THAT THERE WAS ILLEGAL ENTRY BECAUSE THERE IS NO DAMAGE TO THE DOOR OR THE DOOR HANDLE. THIS MUST NOT BE TAKEN LIGHTLY AND FORD NEEDS TO COME UP WITH SOMETHING TO PREVENT THIS. *TR
NHTSA ODI #10406099
188,000 miles · May 25, 2011
Structure
FRAME ON MY 1998 FORD RANGER RUSTED INTO AT THE REAR SPRING SHACKLES, AND BUMPER. I HAVE NEVER HAD A TRUCK TO DO THIS. THE STEEL CROSSMEMBER THAT RUNS BEHIND THE CAB OVER THE GAS TANK FROM SIDE TO SIDE IS ALSO COMPLETELY GONE FROM RUSTING AWAY. THEY MUST HAVE RECEIVED A BAD BATCH OF STEEL WHEN MAKING THIS YEAR. THE SPARE TIRE H…
Read full complaint
FRAME ON MY 1998 FORD RANGER RUSTED INTO AT THE REAR SPRING SHACKLES, AND BUMPER. I HAVE NEVER HAD A TRUCK TO DO THIS. THE STEEL CROSSMEMBER THAT RUNS BEHIND THE CAB OVER THE GAS TANK FROM SIDE TO SIDE IS ALSO COMPLETELY GONE FROM RUSTING AWAY. THEY MUST HAVE RECEIVED A BAD BATCH OF STEEL WHEN MAKING THIS YEAR. THE SPARE TIRE HOLDER IS ALSO RUSTED AWAY, PLACED THE SPARE TIRE IN THE BED SO THAT IT WOULD NOT FALL OFF WHEN TRAVELING DOWN THE HIGHWAY. I SUSPECT THAT THIS WAS VERY COMMON FOR THIS YEAR. *TR
NHTSA ODI #10402650
50,000 miles · May 18, 2011
Service Brakes, Hydraulic
REAR BRAKES LOCKUP EVERY TIME IT RAINS. THIS CAUSES SLIDING ON WET PAVEMENTS. AS OF NOW I HAVE NOT BEEN IN AN ACCIDENT BECAUSE OF THIS PROBLEM. *TR
NHTSA ODI #10401387
148,300 miles · Apr 29, 2011
Structure
1998 FORD RANGER WITH FRAME RUST. REAR SHACKLES HAVE RUSTED AND FALLEN OFF. *TR
NHTSA ODI #10398242
215,708 miles · Apr 6, 2011
Electrical SystemFire
TRUCK WAS PARKED AT THE VETERINARIAN AND I HAD GONE INSIDE WITH MY TWO DOGS. AFTER ABOUT 15 OR 20 MINUTES SOMEONE OUTSIDE WAS BLOWING THERE CAR HORN. THE RECEPTIONIST LOOKED OUT AND THEN TOLD ME MY TRUCK WAS ON FIRE. I RAN OUTSIDE AND SMOKE AND FLAMES WERE COMING OUT FROM UNDER THE HOOD. WE USED FIRE EXTINGUISHERS BUT THAT DID V…
Read full complaint
TRUCK WAS PARKED AT THE VETERINARIAN AND I HAD GONE INSIDE WITH MY TWO DOGS. AFTER ABOUT 15 OR 20 MINUTES SOMEONE OUTSIDE WAS BLOWING THERE CAR HORN. THE RECEPTIONIST LOOKED OUT AND THEN TOLD ME MY TRUCK WAS ON FIRE. I RAN OUTSIDE AND SMOKE AND FLAMES WERE COMING OUT FROM UNDER THE HOOD. WE USED FIRE EXTINGUISHERS BUT THAT DID VERY LITTLE. THE FIRE TRUCK GOT THERE AND GOT THE FIRE PUT OUT. THEY CUT THE HOOD OPEN TO MAKE SURE THE FIRE WAS OUT.
NHTSA ODI #10395094
160,000 miles · Feb 20, 2011
Exterior LightingSeat BeltsUnknown Or Other
98' FORD RANGER: HAS A CRACKED FRAME ON THE REAR RIGHT SIDE. TRUCK MAKES LOUD NOISES WHEN DRIVING AND I AM AFRAID IT MAY BECOME WORSE OVER TIME OR COMPLETELY BREAK DOWN IN UNSAFE SPEEDS. I CAN NOT SELL IT, AS I WAS TRYING TO USE THE MONEY FOR A NEW VEHICLE DUE TO A NEW BABY IN OUR FAMILY. NO ONE WILL BUY SUCH A DEFECTIVE VEHI…
Read full complaint
98' FORD RANGER: HAS A CRACKED FRAME ON THE REAR RIGHT SIDE. TRUCK MAKES LOUD NOISES WHEN DRIVING AND I AM AFRAID IT MAY BECOME WORSE OVER TIME OR COMPLETELY BREAK DOWN IN UNSAFE SPEEDS. I CAN NOT SELL IT, AS I WAS TRYING TO USE THE MONEY FOR A NEW VEHICLE DUE TO A NEW BABY IN OUR FAMILY. NO ONE WILL BUY SUCH A DEFECTIVE VEHICLE. ALSO SEAT BELTS WILL NOT STAY LATCHED? ALSO THE INSIDE DOME LIGHT MELTS RIGHT THROUGH THE COVERING, WHERE TEMPERATURES MAKE THE PLASTIC COVER BUBBLE AND MELT.
NHTSA ODI #10383860
198,000 miles · Jan 29, 2011
Fuel System, GasolineUnknown Or OtherWheels
DISPITE PROPER MAINTENCE, I OBSERVED BODY RUST AND DECAY ON THE UNDERSIDE OF MY TRUCK FRAME. ALSO THE BRAKE LINES HAVE BEEN REPLACED DUE TO CORRUSION AND RUST INTO THE FRAME. SPARE TIRE BRACKETS HAVE RUSTED INTO AND THE TIRE FELL OFF. ALSO EVAP CANASTER BRACKET RUSTED INTO AND THE EVAP CANASTER FELL OFF.
NHTSA ODI #10380366
151,663 miles · Jul 8, 2010
Engine And Engine Cooling
I STARTED THE TRUCK, ALL GAUGES READ OK, BACKED IT OUT ONTO THE ROAD AND PROCEEDED T DRIVE TO MY DESTINATION. I SHIFTED INTO 3RD AND IT FELT SLUGGISH, (LIKE BRAKE DRAG) I LOOKED DOWN AT THE INSTRUMENT PANEL FOR INFORMATION, AND FOUND NO RESPONSE FROM THE OIL PRESSURE GAUGE. I PROCEEDED TO PUSH IN THE CLUTCH AND SHUT OFF THE MOTO…
Read full complaint
I STARTED THE TRUCK, ALL GAUGES READ OK, BACKED IT OUT ONTO THE ROAD AND PROCEEDED T DRIVE TO MY DESTINATION. I SHIFTED INTO 3RD AND IT FELT SLUGGISH, (LIKE BRAKE DRAG) I LOOKED DOWN AT THE INSTRUMENT PANEL FOR INFORMATION, AND FOUND NO RESPONSE FROM THE OIL PRESSURE GAUGE. I PROCEEDED TO PUSH IN THE CLUTCH AND SHUT OFF THE MOTOR, BUT BY THE TIME I PUSHED IN THE CLUTCH THE ENGINE SHUT DOWN AND WOULDN'T PROCEED TO RUN. I CHECKED THE OIL DIP STICK TO FIND THE OIL LEVEL IS ACCEPTABLE, BUT THE MOTOR REFUSES TO TURN OVER. PROBLEM STILL OCCURS TO THIS DAY. *TR
NHTSA ODI #10341968
35,000 miles · Mar 22, 2010
Power TrainFire
1998 FORD RANGER, DRIVE SHAFT BROKE ON VEHICLE. *BF AFTER THE DRIVE SHAFT BROKE, IT WENT THROUGH THE GAS TANK CAN CAUSED THE VEHICLE TO CATCH ON FIRE. OHIO TRAFFIC CRASH REPORT #10-0294-89 UPDATED 05/03/10 *BF UPDATED 05/24/10 *BF THE REAR AXLE PINION FROZE, THE DRIVE SHAFT TWISTED AND BROKE IN TWO. UPDATED 05/28/10
NHTSA ODI #10321950
83,000 miles · Mar 16, 2010
Service Brakes, Hydraulic
MY 1998 FORD RANGER XLT SO FAR HAD 2 COMPLETE BRAKE FAILURES DUE TO CORRODED BRAKE LINES. THIS IS A SYSTEMIC PROBLEM CAUSED BY THE SPIRAL PROTECTION OF THE BRAKE LINES WHICH KEEPS THE HUMIDITY TRAPPED AND THUS CORRODES THE LINES. WHEN THIS HAPPENS, BRAKE FLUID IS LEAKING OUT WHEN THE PEDAL IS PUSHED DOWN YET NO BRAKE FUNCTION I…
Read full complaint
MY 1998 FORD RANGER XLT SO FAR HAD 2 COMPLETE BRAKE FAILURES DUE TO CORRODED BRAKE LINES. THIS IS A SYSTEMIC PROBLEM CAUSED BY THE SPIRAL PROTECTION OF THE BRAKE LINES WHICH KEEPS THE HUMIDITY TRAPPED AND THUS CORRODES THE LINES. WHEN THIS HAPPENS, BRAKE FLUID IS LEAKING OUT WHEN THE PEDAL IS PUSHED DOWN YET NO BRAKE FUNCTION IS EXPERIENCED. AS THIS PROBLEM HAS A CLEAR TECHNICAL REASON IN THE FORM OF THE BRAKE LINES, IT IS SYSTEMIC IN ALL SUCH VEHICLES. THIS HAS BEEN CONFIRMED BY MY CAR MECHANIC SHOP WHICH IS FREQUENTLY REPAIRING FORD VEHICLES WITH THIS PROBLEM. THE PROBLEM HAS NO EARLY WARNING INDICATION AND IS NOT DETECTED BY THE YEARLY INSPECTION. *TR
NHTSA ODI #10320329
Official recalls
5Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Jul 28, 1999
VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.
Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
Mar 30, 1999
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
Feb 2, 1998
VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.
Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
Oct 28, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration