IllustrationMY 1998 RANGER WILL NOT PASS STATE INSPECTION AGAIN DUE TO FRAME RUST. NOT JUST IN THE REAR BUT ALL OVER. THE REST OF THE TRUCK IS IN GOOD SHAPE. *JS
1998 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 1998 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 109 of 576 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports29 fire reports34 injury reports
What owners actually said
576 reportsTHE FRAME IS HAVING SERIOUS AND DANGEROUS HEAVY RUST AND ROT COMPROMISING THE STRUCTURAL INTEGRITY OF THE TRUCK. IN FACT A SHOCK MOUNT JUST BROKE WHILE DRIVING AND THE RESULTING LOUD BANG CAUSED ME GREAT STRESS WHILE DRIVING. AFTER PULLING OVER AND LOOKING I COULD SEE THE SHOCK MOUNT HAD ROTTED SO BAD AS TO BREAK OFF THE AXLE H…
Read full complaint
THE FRAME IS HAVING SERIOUS AND DANGEROUS HEAVY RUST AND ROT COMPROMISING THE STRUCTURAL INTEGRITY OF THE TRUCK. IN FACT A SHOCK MOUNT JUST BROKE WHILE DRIVING AND THE RESULTING LOUD BANG CAUSED ME GREAT STRESS WHILE DRIVING. AFTER PULLING OVER AND LOOKING I COULD SEE THE SHOCK MOUNT HAD ROTTED SO BAD AS TO BREAK OFF THE AXLE HOUSE.AM ALSO CONCERNED ABOUT THE STRUCTURES HOLDING THE SPARE TIRE,GAS TANK AND ENTIRE SUPPORT SYSTEM. *TR
UPON ACTIVATING TURN SIGNAL ON A DARK MORNING, THE HEADLIGHTS COMPLETELY FAILED. ACTIVATING THE DIM/BRIGHT LEVER PROVIDED INTERMITTENT ACTIVATION. UPON RELEASE OF THE DIM/BRIGHT FUNCTION THE HEADLIGHTS WOULD NOT REMAIN ON IN EITHER DIM OR BRIGHT MODE. OTHER USERS OF VEHICLE REPORT COMPLETE HEADLIGHT FAILURE. THEY TOO …
Read full complaint
UPON ACTIVATING TURN SIGNAL ON A DARK MORNING, THE HEADLIGHTS COMPLETELY FAILED. ACTIVATING THE DIM/BRIGHT LEVER PROVIDED INTERMITTENT ACTIVATION. UPON RELEASE OF THE DIM/BRIGHT FUNCTION THE HEADLIGHTS WOULD NOT REMAIN ON IN EITHER DIM OR BRIGHT MODE. OTHER USERS OF VEHICLE REPORT COMPLETE HEADLIGHT FAILURE. THEY TOO HAVE BEEN ABLE TO RESTORE HEADLIGHT FUNCTION INTERMITTENTLY AFTER SEVERAL FRANTIC SECONDS OPERATING THE LIGHT SWITCH OR THE DIMMING LEVER WHILE TRAVELING IN THE DARK. *TR
PARKED OUT ON THE STREET IN FRONT OF MY HOUSE, CAUGHT ON FIRE AROUND 9 PM. FIRE TRUCKS CAME AND PUT IT OUT AND KNOCKED ON THE DOOR AROUND 9:25 PM. *TR
TL* THE CONTACT OWNS A 1998 FORD RANGER. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY RUSTED. THE DEALER WAS NOTIFIED OF THE FAILURE BUT DID NOT RETURN THE CONTACTS CALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 125,348.
I HAVE A 1998 FORD RANGER EXTENDED CAB, MY FRAME HAST RUSTED THROUGH CAUSING MY BED TO BE UNATTACHED. *TR
THE FRAME ON MY 1998 FORD RANGER IS BASICALLY RUSTED THROUGH. MY BROTHER'S 1999 FORD RANGER HAD TO HAVE THE FRAME REPLACED DUE TO EXCESSIVE RUST. *TT
GAS TANK STRAPS RUSTED THROUGH AND GAS TANK FELL OUT. I FIXED IT BY INSTALLING MY OWN STRAPS BOUGHT AT A HARDWARE STORE. THIS IS A VERY DANGEROUS PROBLEM. *TT
SPARE TIRE CARRIED UNDER TRUCK COMPLETELY RUSTED AWAY AND SPARE FELL ON HIGHWAY AND REAR FRAME COMPLETELY RUSTING AWAY. ORIGINAL RIMS HAD TO BE CHANGED ALSO BECAUSE THEY RUSTED SO BAD WOULDN'T HOLD AIR. *TR
1998 FORD RANGER HAS SECURITY ISSUE WHICH ALLOWS ANY INDIVIDUAL TO UNLOCK THE DOOR AND NO ONE WOULD EVEN KNOW IT UNTIL YOU FIND YOUR STUFF MISSING. ALL IT TAKES IS A SCREW DRIVE UNDER THE DOOR HANDLE TO UNLOCK THE DOOR AND GAIN ENTRY. THIS IS COMMON TO MOST ALL RANGERS AND IT IS HARD TO REPORT ANY LOSS WITHOUT PROOF THAT THERE W…
Read full complaint
1998 FORD RANGER HAS SECURITY ISSUE WHICH ALLOWS ANY INDIVIDUAL TO UNLOCK THE DOOR AND NO ONE WOULD EVEN KNOW IT UNTIL YOU FIND YOUR STUFF MISSING. ALL IT TAKES IS A SCREW DRIVE UNDER THE DOOR HANDLE TO UNLOCK THE DOOR AND GAIN ENTRY. THIS IS COMMON TO MOST ALL RANGERS AND IT IS HARD TO REPORT ANY LOSS WITHOUT PROOF THAT THERE WAS ILLEGAL ENTRY BECAUSE THERE IS NO DAMAGE TO THE DOOR OR THE DOOR HANDLE. THIS MUST NOT BE TAKEN LIGHTLY AND FORD NEEDS TO COME UP WITH SOMETHING TO PREVENT THIS. *TR
Official recalls
507V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
99V204000 · Power Train:automatic Transmission
Jul 28, 1999
VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.
Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
99V062001 · Vehicle Speed Control
Mar 30, 1999
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
98V021000 · Equipment:other:labels
Feb 2, 1998
VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.
Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
97V186001 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Oct 28, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE99045 · Steering Knuckle Separations
Opened Jul 6, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
There is no summary currently available