IllustrationABS COMPUTER FAILED AGAIN AFTER FORD DEALER REPLACED ORIGINAL. UPPER SHOCK/SPRING MOUNT COMPLETELY RUSTED AWAY CAUSING LOSS OF STEERING AND SUSPENSION. LOCAL DEALER REFUSED TO REVIEW FOR POSSIBLE MANUFATURERS DEFECTS. *AK
1992 Ford Ranger
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Ford Ranger do not stand out strongly from the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 189 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports32 fire reports10 injury reports
Service Brakes, Hydraulic complaints
17 reportsMAIN BRAKE LINE RUPTURED DUE TO RUBBING ON PARKING BRAKE CABLE, CAUSING COMPLETE BRAKE FAILURE. *AK
RIGHT FRONT SAGGED.PULLED OVER SAW FLUID LEAKING LOOK IN FENDER WELL SAW SPRING HANGER RUSTED OUT AND SPRING PUSH UP INTO INNER FENDER AND BRAKE LINE BROKE
WHILE DRIVING RIGHT FRONT OF VEHICLE WENT DOWN. THEN, BRAKE LIGHT CAME ON, AND THERE WERE NO BRAKES. PULLED UP TO A LIGHT TO CHECK, AND NOTICED BRAKE FLUID RUNNING OUT,. TRUCK WAS SITTING LOW BECAUSE THE SHOCKS HAD DROPPED DOWN ON THE BRAKE LINE. *AK
BRAKE PEDAL DROPPED TO THE FLOOR, AND BRAKES FAILED. CONSUMER LOST CONTROL, RESULTING IN A COLLISION. THERE WERE NO INJURIES. *AK
TRANSMISSION MANUAL FAILED OUTPUT SHAFT AT 20 MPH REPLACED INTERNAL GEARS GAVE OUT AT 65 MPH.//ABS BRAKES BECAME SPONGY & LOCK IN REAR PULL TO RIGHT IN FRONT .//HEADLIGHTS BEGAN BLINKING OFF &ON AFTER 15 MINUTES OF DRIVING.//TRANSFER CASE SPLIT WHILE IN 2 WHEEL DRIVE AT 35 MPH.//FRONT SUSPENSION GIVING OUT CAN'T ALIGN FRONT END …
Read full complaint
TRANSMISSION MANUAL FAILED OUTPUT SHAFT AT 20 MPH REPLACED INTERNAL GEARS GAVE OUT AT 65 MPH.//ABS BRAKES BECAME SPONGY & LOCK IN REAR PULL TO RIGHT IN FRONT .//HEADLIGHTS BEGAN BLINKING OFF &ON AFTER 15 MINUTES OF DRIVING.//TRANSFER CASE SPLIT WHILE IN 2 WHEEL DRIVE AT 35 MPH.//FRONT SUSPENSION GIVING OUT CAN'T ALIGN FRONT END ,ERATIC STEERING & WORN TIRES.//REAR SPRINGS SLIPPED OUT ON LEFT SIDE AXLE SLID FORWARD TO BODY.//HEATER BEGAN RATTLIING ,MORE AS YOU TURN FAN UP.
WHILE MAKING A NORMAL BRAKE APPLICATION THE MASTER CYLINDER ATTACHMENTS STUDS FAILED, RESULTING IN A COLLISION, DUE TO LOSS OF CONTROL, PRIOR TO RECALL NOTICE (96V024). *YC
READ BRAKE DRUMS HAVE WARPED 3 OR 4 TIMES EACH SIDE, MAKES BRAKE PEDAL PULSATE. TURNED BY DEALER ONCE AND POSSIBLY REPLACED ONCE, CONSTANT PROBLEM. HAVE SMELLED MELTING WIRE INSULATION SEVERAL TIMES. OUTSIDE MIRRORS FOLD BACK OVER 55 MPH. REPLACED ONCE, STILL PROBLEM. GAS TANK DRIPS GAS, PLASTIC TANK IN CONTACT WITH METAL CROS…
Read full complaint
READ BRAKE DRUMS HAVE WARPED 3 OR 4 TIMES EACH SIDE, MAKES BRAKE PEDAL PULSATE. TURNED BY DEALER ONCE AND POSSIBLY REPLACED ONCE, CONSTANT PROBLEM. HAVE SMELLED MELTING WIRE INSULATION SEVERAL TIMES. OUTSIDE MIRRORS FOLD BACK OVER 55 MPH. REPLACED ONCE, STILL PROBLEM. GAS TANK DRIPS GAS, PLASTIC TANK IN CONTACT WITH METAL CROSSBAR. APPEARS TO BE ORIGINAL INSTALLATION PROBLEM. NEED WARRANTY FIX ON THIS.
ABS LOCKS UP.
ANTI-LOCK BRAKING SYSTEM FAILURE IS INDICATED ON THE INSTRUMENT PANEL. DEALER STATED THAT IT WAS ONLY A TEST SYSTEM FAILURE.
Official recalls
296V024001 · Service Brakes, Hydraulic:power Assist:hydraulic
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
92V006000 · Structure:body:door
Jan 14, 1992
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.