2018 Ford Mustang

Was driving my vehicle roughly 10-15mph after a stop, noticed vehicle wasn’t shifting into the gears properly as it was only in 2nd gear and the RPMs kept climbing, when it finally shifted into 3rd gear my transmission proceeded to lockup cause my rear tires to skid and stop in the middle of traffic and in the middle of an intersection disrupting the flow of traffic. Vehicle displayed a wrench light on the dash saying “see manual” as related to a Powertrain issue. Vehicle is in limp mode and barely drives, any shifting after 1st gear will cause the vehicle to lockup and lose all power for several seconds. ONLY HAS 28,330 MILES, DID NOT REACH THE FIRST SERVICE INTERVAL FOR MAINTENANCE ON THE TRANSMISSION.

My 2018 Ford Mustang EcoBoost with the 10R80 automatic transmission began experiencing hesitation, delayed engagement, and harsh jerking during low-speed acceleration (15-20 mph), especially when cold. Engine RPM would increase, but the vehicle would hesitate before engaging. The condition worsened over time and eventually the vehicle entered limp mode, causing a significant loss of power and illuminating a wrench warning light. An authorized Ford dealership diagnosed DTC P07F6 (Gear 9 Incorrect Ratio). The dealer verified fluid level, updated the PCM, and performed adaptive relearn procedures, but the problem remained. The transmission fluid was found to be dark with a burnt odor, and the dealer diagnosed an internal transmission failure requiring complete transmission replacement at an estimated cost of $9,250. This created a safety concern because the vehicle did not consistently accelerate as expected when entering traffic, crossing intersections, or merging onto roadways. Delayed engagement and loss of power reduced the ability to accelerate when needed. The vehicle has approximately 82,256 miles and has been maintained according to Ford's recommended service schedule. I am also aware of numerous publicly documented owner reports, technical discussions, and litigation involving the Ford 10R80 transmission used in vehicles from this generation. One of the commonly discussed concerns involves the CDF drum design in earlier 10R80 transmissions. My understanding is that Ford later revised the CDF drum design in subsequent production; however, when I contacted Ford regarding this transmission failure and requested assistance with repair const, they advised that my vehicle was not covered by any recall, customer satisfaction program, or warranty extension related to this issue. I am submitting this report so that my experience can be considered together with other reports to determine whether a broader safety-related defect exists.

While completing a turn at a T-intersection, the vehicle experienced a complete loss of motive power for several seconds, leaving the car stationary in the path of oncoming traffic. The transmission (10R80) failed to engage, a known symptom of internal CDF Drum sleeve failure (TSB 24-2254). This follows a 'Green' inspection by a dealer on March 23rd where an axle seal leak and shifting issues were overlooked. The failure to engage gear during a turn creates an unreasonable risk of a T-bone collision.

I was driving down the road in my 2018 Mustang ecoboost. When all of the sudden slowing down it locked the rear wheels up. I slid off the road and fortunately I didn’t hit anything but it did pop my side skirt off in the rear of the car. Thankfully the person behind me reacted in quick enough time to get around me considering the rainy weather conditions. This is very dangerous. It’s throwing a code for a solenoid B. Had traction control lights. And says see manual. But they all illuminated after the problem first happened. The car has been parked for a while. However someone suggested I try this website. There were no pre warnings to what was going on. The car drove fine up until the point of it just randomly deciding to lock the rear wheels up. I still owe money on the car and have been paying for it for almost two years since it happened. The car has around 100k miles. I saw online where my car is not the only case. One of the cases the car almost got hit by a train. Yikes.

The contact owns a 2018 Ford Mustang. The contact stated that while driving at an undisclosed speed, the vehicle suddenly came to a stop while attempting to shift to second gear. The contact pulled over to the side of the road. The contact stated that the failure had been recurring while driving in second gear, which required the contact to release the accelerator pedal before the vehicle could shift to second gear. The vehicle was taken to O'Reilly’s, where it was diagnosed with transmission failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.

The vehicle jolts when placed from park or reverse to Drive after being driven 30 or more minutes or driving 10+ miles. I had previously sent it to 3 different dealerships and only one was able to temporarily resolve the issue. They had to adjust the issue through a computer system. However, after 6-12 months, it is happening again. I feel that is a property or safety issue for drivers because, the transmission or shift change makes the vehicle jump forward and if not carefully could possibly hit another vehicle or person that passes through the front side of the vehicle.

For roughly 4mths beginning in April 2025, my 2018 Ford Mustang Ecoboost has been suffering from a sporadic misfire, with it the system reporting the misfire and the check engine light coming on, the Ford App identifying the misfire occurring. It was initially repaired with replacing all spark plugs, ignition leads. The sporadic misfire would continue to occur, Ford dealership kept the car for 2 days in late July, took everything apart said they were unable to replicate the misfire, cleared the codes (P0303 being the main one that appears consistently) and said to come back if it occurred again. Roughly 2 weeks later the issue occurred again, took the vehicle back to Ford where they kept the car for 2 days, went through the same process and could not replicate the issue. They dug deeper into the issue and found that the coolant would not hold pressure and with the use of a video scope found that the Intake Valve had fractured and was leaking coolant into the engine as well as distributing multiple shards and pieces of metal from the Valve Intake Fracture. Informed me that the only option was to replace with a new engine and turboboost. They reviewed and found that there were no recalls related to this issue for this vehicle. After undertaking my own research, I found this to be a known issue for Ford and that roughly 100k vehicles had been recalled starting with the 2020 vehicles for the same issue. The out of pocket expense is around 14k, and the vehicle is currently waiting on a replacement engine to arrive. Currently Ford are not offering any assistance in the cost of the replacement, been though they have been servicing the car since 2020 and it is regularly maintained per their guidelines of vehicle needs based on the mileage driven.

I have a 2018 Mustang GT with the 10R80 transmission. The transmission started giving me problems like slamming and slipping while shifting and sometimes jumping in and out of gear when drinking in the highway.The problem came from an engineering is with the CDF Drum... Ford has updated the CDF Drum and has fixed the problem. Ford never issues a recall to fix this problem with the vehicles produced with this issue but instead just used the updated production parts in the later models leaving the customers like myself to have to either pay out of pocket or rely on a warranty or after market warranty company to have this very expensive issue fixed. Right now as I am writing this, my car is in the transmission shop. Please help me. When I did a Google search of the CDF Drum issue, this is what was quoted: "The 2018 Ford Mustang GT with the 10R80 transmission can experience issues with the CDF (Clutch-Drum-Forward) drum, specifically with its bushing. This problem can lead to slippage, harsh shifting, and potential transmission failure. Ford has addressed this issue with design revisions to the CDF drum, including adding a lip to the bushing to prevent it from moving and causing fluid leaks."

The contact owns a 2018 Ford Mustang. The contact stated while attempting to accelerate from a stop, the vehicle jerked until shifting into gear. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the CDF drum and the main control were faulty and needed to be replaced. The vehicle was not repaired. The contact referenced Technical Service Bulletin: 25-2126 as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage 102,000.

The contact owns a 2018 Ford Mustang. The contact stated that while the vehicle was parked, the contact stated that the vehicle failed to shift into reverse properly, with several unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 70,000.