I AM THE OWNER OF A 2002 FORD/MERCURY MOUNTAINEER I HAD TO HAVE MY RIGHT FRONT WINDOW FIXED. I LET IT DOWN AND IT WOULD NOT COME BACK UP SO I TOOK IT TO MY LOCAL BODY SHOP AND HE SAID THIS IT THE 6TH ONE HE HAS HAD TO FIX IN THE LAST FEW MONTHS. IS THERE A RECALL ON THIS PART. IT COST ME OVER $200.00 TO HAVE A GASKET/SEAL PUT ON…
Read full complaint
I AM THE OWNER OF A 2002 FORD/MERCURY MOUNTAINEER I HAD TO HAVE MY RIGHT FRONT WINDOW FIXED. I LET IT DOWN AND IT WOULD NOT COME BACK UP SO I TOOK IT TO MY LOCAL BODY SHOP AND HE SAID THIS IT THE 6TH ONE HE HAS HAD TO FIX IN THE LAST FEW MONTHS. IS THERE A RECALL ON THIS PART. IT COST ME OVER $200.00 TO HAVE A GASKET/SEAL PUT ON THE WINDOW. IT WAS NOT THE MOTOR BUT A PART THAT ATTACHES TO THE WINDOW. *NM
NHTSA ODI #10173854
37,550 miles · Oct 21, 2004
Visibility
RE: 2002 MOUNTAINER , SAFETY RECALL, REAR GLASS BROKEN OUT, REPLACE DEFECTIVE WINDOW MOTOR. *BF CONSUMER SHUT THE BACK WINDOW AND THE GLASS BLEW OUT THROWING GLASS THROUGHOUT THE VEHICLE. TOP PART OF THE BACK DOOR FELL ON THE CONSUMER. *TC
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
Consequence & remedy
Consequence: IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04045 · Rear Liftgate Glass Assembly
Opened Jun 2, 2004 · Closed Sep 28, 2004
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:hinge And Attachments
COMPLAINTS REPORT FAILURE OF THE REAR LIFTGATE GLASS SUPPORT WHILE THE OPERATOR IS OPENING OR CLOSING THE GLASS.THE FALLING GLASS CAN STRIKE THE OPERATOR OR BYSTANDER.THE INJURIES REPORTED ARE BRUISES TO THE HEAD, NECK OR BACK, CUTS TO THE FACE, ARM OR HAND.ON SEPTEMBER 9, 2004, FORD NOTIFIED THE AGENCY THAT IT WILL RECALL APPROXIMATELY 955,732 MY 2002 AND 2003 FORD EXPLORER AND MERCURY MOUNTAINEER VEHICLES TO REPLACE THE LIFTGATE GLASS STRUT BRACKETS AND/OR HINGES.SEE NHTSA RECALL 04V442 FOR DETAILS. THIS INVESTIGATION IS CLOSED.
SQ01015 · Inoperative Air Bag System
Opened Dec 12, 2001 · Closed Jul 2, 2002
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
2002 Ford Mountaineer Problems, Complaints & Recalls | Skip That Year
Illustration