Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 38 of 461 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 155 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 137 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports1 fire reports3 injury reports
What owners actually said
461 reports
38,000 miles · Aug 14, 2025
SteeringSuspension
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 50-70 MPH, the vehicle shook violently while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer and the front CV axles were replaced under warranty. However, three months after the CV axl…
Read full complaint
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 50-70 MPH, the vehicle shook violently while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer and the front CV axles were replaced under warranty. However, three months after the CV axle repair, the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the CV axles were on backorder. The manufacturer was later notified of the failure and the contact was informed that parts were available; however, the part was no longer covered under warranty. The contact was provided an estimate to cover half the cost of the repair. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 38,000.
NHTSA ODI #11680652
Mileage unknown · Aug 14, 2025
Electrical System
Vehicle dashboard started flashing a service warning while driving and then immediately going away. Afterwards, electrical system failed when vehicle was put into park. No lights or any electrical functions were working. Issue is consistent with program 22B39. Ford had not contacted me about this issue in the past when it was fi…
Read full complaint
Vehicle dashboard started flashing a service warning while driving and then immediately going away. Afterwards, electrical system failed when vehicle was put into park. No lights or any electrical functions were working. Issue is consistent with program 22B39. Ford had not contacted me about this issue in the past when it was first discovered.
NHTSA ODI #11680613
Mileage unknown · Aug 12, 2025
Power Train
Both Front CV Axles failed at the connection point to the transmission. Causing the vehicle and steering wheel to shake while accelerating at 45-65 MPH. The manufacturer's dealer replaced both front CV axles under warranty, as per the 5-year/60,000-mile powertrain coverage.
NHTSA ODI #11680230
Mileage unknown · Aug 11, 2025
Power Train
The CV axle (driver's side) started to fail before 22,000 miles on my 2022 Ford Maverick. When accelerating the vehicle would violently shake back and forth. The tires are starting to wear early due to the constant movement. If the CV axle was to break I would lose power and it could damage nearby components (brakes, brake li…
Read full complaint
The CV axle (driver's side) started to fail before 22,000 miles on my 2022 Ford Maverick. When accelerating the vehicle would violently shake back and forth. The tires are starting to wear early due to the constant movement. If the CV axle was to break I would lose power and it could damage nearby components (brakes, brake lines, cooling lines). I would be stranded on the side of the road. I did not drive it until I could get to the dealer for a repair. The dealer was very aware of the problem. There were no warning, MIL, or any indication the part was failing. The problem is quite evident on line as most of these parts start to fail before 30,000 miles.0
NHTSA ODI #11679901
Mileage unknown · Aug 1, 2025
Power TrainSuspension
Car shakes around 50 mph. Took truck to my mechanic and they said it was the front differentials. They told me that there was a tecall for this issue.
NHTSA ODI #11677735
Mileage unknown · Jul 29, 2025
Power Train
CV Joint failing. Vehicle wobbles during acceleration between 55-65 MPH. Began around 55,000 miles - was very minor at first and believed to be tire related. Now, at roughly 67,000 miles the wobble is very prominent.
NHTSA ODI #11676965
Mileage unknown · Jul 18, 2025
Electrical System
Truck will enter a deep sleep. Will not start, will not unlock with fob, lights will not turn on. This has happened 2 times. Battery harness is faulty according to dealership.
NHTSA ODI #11674464
Mileage unknown · Jul 17, 2025
Unknown Or Other
Windshield cracks. First happened in 2024, nothing hitting the windshield, it cracked. The crack spread and required an entire new windshield that was not covered by any warranty. July 2025 same issue, same area where the crack started last time, on the new windshield. I am concerned about the quality of the windshields installe…
Read full complaint
Windshield cracks. First happened in 2024, nothing hitting the windshield, it cracked. The crack spread and required an entire new windshield that was not covered by any warranty. July 2025 same issue, same area where the crack started last time, on the new windshield. I am concerned about the quality of the windshields installed on Ford Mavericks. One dealership said “the Maverick windshields are known to be incredibly thin and crack”
NHTSA ODI #11674375
Mileage unknown · Jul 8, 2025
Air BagsElectrical SystemService Brakes
My 2022 Ford Maverick hybrid is known to have an issue with water leaking into the cabin from the cowl. This water is leaking onto the floorboards and there is some mold growing behind the electrical box. WHICH IS NOT GOOD AND IS SAFTEY AND HASZARD TO OUR HEALH TO BREATH THIS IN THIS NEED TO BE SENT OUT AS A RECALL AND FIX FOR F…
Read full complaint
My 2022 Ford Maverick hybrid is known to have an issue with water leaking into the cabin from the cowl. This water is leaking onto the floorboards and there is some mold growing behind the electrical box. WHICH IS NOT GOOD AND IS SAFTEY AND HASZARD TO OUR HEALH TO BREATH THIS IN THIS NEED TO BE SENT OUT AS A RECALL AND FIX FOR FREE OR BUY BACK THE vehicle
NHTSA ODI #11671874
Mileage unknown · Jul 7, 2025
Unknown Or Other
Water leak/intrusion into cabin Hybrid back from the dealer for a water leak. As a recap, only a few weeks old bought it used and discovered a pool of water under the floor liners I put in Water leaking in through HVAC Box, down past the BCM and onto the passenger floorboard. Lower Cowl seal for the cabin air intake defective. …
Read full complaint
Water leak/intrusion into cabin Hybrid back from the dealer for a water leak. As a recap, only a few weeks old bought it used and discovered a pool of water under the floor liners I put in Water leaking in through HVAC Box, down past the BCM and onto the passenger floorboard. Lower Cowl seal for the cabin air intake defective. Removed engine bay cowls to access defective part. Damaged seal caused water leak and is apart of the lower cabin air intake cover.
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick Hybrid and 2020 Escape Hybrid vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed February 12, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 15, 2026. This is an expansion of Recalls 24V330 (24S33) and 25V133 (25S16).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ24014 · Loss Of Motive Power
Opened Nov 15, 2024 · Closed Oct 10, 2025
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2022 Ford Maverick Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration