2022 Ford Maverick Hybrid

While driving at normal speeds. Car completely stopped working. Dashboard flashed to get to safe area. I could not shift the car neutral. Steering became stiff. The lights and infotainment was still on but the car had no power to accelerate. Had this been on the highway I would have been in a collision since my car went to the right very quick. Once car was stopped could not shift to neutral.

Front end of vehicle suddenly started to shake violently when accelerating. Issue was reproduced any time when accelerating. No warning was indicated by the vehicle. Car was undrivable above 50 mph. Vehicle had 25K miles. Dealer reproduced issue. Diagnosed it as a catastrophic failure of both CV joints and front bearing(s). Dealer would not release vehicle as it was undrivable due to extreme safety issue. Parts arrived after a week and both CV joints & front bearing(s) were replaced. Online reporting for this vehicle shows this is a repeated issue which the manufacturer has a customer satisfaction bulletin but no recall.

While driving in local traffic, my vehicle completely shut down. All power was lost. The engine shut off, shift control was disabled and the power steering did not work. Several warning lights were displayed including a "shift to neutral" warning, which was disabled. I was unable to restart the vehicle. After sitting for 10 minutes, the vehicle was started and resumed normal operations. This has happened on more than one occasion. The local dealership has kept the vehicle and cannot duplicate the failure or determine the cause. I am concerned that this could happen on the highway and cause myself or other travelers to be injured.

The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 50-70 MPH, the vehicle shook violently while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer and the front CV axles were replaced under warranty. However, three months after the CV axle repair, the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the CV axles were on backorder. The manufacturer was later notified of the failure and the contact was informed that parts were available; however, the part was no longer covered under warranty. The contact was provided an estimate to cover half the cost of the repair. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 38,000.

I have a 2022 ford maverick pickup truck and have a vibration in steeling wheel at acceleration so I took it to a very reapable tire ,brake and suspension dealer who checked the brakes, tires, balance, steering joints etc and found nothing wrong and said he had no clue what it could be and no Ford Recall issued but web sites show other customers with same problem and dealers are not wanting to completely check out because of no Recall please help us!!!

On 5/20/2024 - At 39,254 miles, both my CV axles lost stability, and were replaced. Less than a year later on 3/3/2025 - At 59780 miles both the CV axles started wobbling and were replaced. In doing a little research online, found many Ford Maverick Hybrid vehicles were having the same issue from poor quality parts. I would request for the NHTSA to take this issue up with Ford and address it as a recall on the poor-quality parts or have an extended warranty provision from Ford on them, as the warranty on these axles expires at 60,000 miles.

After performing a panic stop where the Pre-Collision activation message and chime activated, nothing happened until a few miles down the road. At that time, The "Service AdvanceTrac," "Pre-Collision Assist Not Available" and "Hill Start Assist" warning messages scrolled on the cluster with a chime to go with them. Additionally, the amber tell tale warning lights for the ABS system, electric park brake system, stability control system and pre-collision assist were illuminated. The lights turned themselves off one by one approximately five 5-6 miles after that, then all came back on with the same three warning messages about 2-3 miles after they had gone off. All remained illuminated even at the start of the next key cycle but promptly went away before leaving the parking lot. It should be noted that while the warning lights were on, the vehicle did not have electronic power steering assist though no warnings or lights told of this failure. I could just tell from the increased effort in low speed, parking lot maneuvers.

CV axles in the 2022 Ford Maverick Fail Prematurely: This is a known and common problem, with no recall, TSB, or additional warranty from Ford. This results in severe shuttering during acceleration, and especially heavy loads (e.g. highway on-ramp). Additionally, the failure wears out other steering components, and potentially tire tread. The premature failure of this part (CV axle) creates additional risk for vehicle occupants, and should be remediated.