2022 Ford Maverick Hybrid

Issue: Shift SYS Fault, DTC P07E6 System: Transmission Description: Emergency parking brake failed to disengage (solenoid could be heard attempting to move), as a result the transmission would not shift out of park. Check engine light and multiple codes/warnings illuminated on dash. Vehicle could not be moved or shifted into neutral. Waited 10-15 minutes before 2nd attempt, parking brake still failed to disengage. Then waited for 3 hours for third attempt, at which point emergency brake successfully disengaged. Check engine light no longer lit and no codes/warnings present on dash. Nothing changed or was done to the truck between the 2nd and 3rd attempt. Reproduction: Will drop off at dealer for confirmation in coming weeks. Warnings: Engine check light, Shift SYS fault, DTC P07E6, See dealership -> all illuminated after parking brake attempted to disengage during 1st and 2nd attempt.

After completing all recalls at the dealer, most recently the PCM re-programming, my 2022 Maverick Hybrid engine would just stop running with no warning. Electrical system was intact, there was no response to the gas pedal. Car would just slow down and I had to pull over. I pressed the stop button, sat for a few seconds and pushed it again and the vehicle started and ran properly. This has happened three times over the past 3 months (most recently on [XXX]) while driving at night at highway speeds, during the day at 50 mph and 35 mph. All acted the same way. I only caught what may have been a part of a warning message on the dash that I believe said "connected" after the first incident. The truck has been at the West Richmond, VA Ford dealership for the past 10 days and they have not been able to diagnose the problem. This is a very dangerous situation and I can't drive the vehicle until a fix has been found and implemented. The NHTSA issued a report on a similar situation back in April of this year (24V267000) so it appears like Ford has not provided their dealers with a satisfactory answer to this problem. My truck did not exhibit an electrical shutdown or flash numerous trouble codes or the check engine light. The engine simply shuts off for no apparent reason. The technicians see nothing recorded in the onboard computer(s) either. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The CV axle on my 2022 Ford Maverick keeps failing. Has been repaired/replaced 3 times same Ford dealership completing repairs. It starts with shuddering and shaking when accelerating then a clicking noise and unable to keep vehicle straight. Lucky enough no accidents where caused, however the second time this happened I was on interstate going at least 75mph the clicking started then could not control the vehicle, couldn't maintain lane. I am a little surprised how lightly the issue is precevied. It's becoming routine like getting oil change and cv axles are changed out. I making this complaint because after 3rd time it is starting to have same symptoms again and drivability of vehicle.

I was driving for about 10 minutes at speed 35 mph then noticed the car is in electric mode but unable to accelerate. It feels nothing happened when I depressed the gas pedal. The car came to a complete stop at traffic light but failed to accelerate when I pressed on the gas pedal. I turned off the car and started it back up and everything return to normal.

I was driving on the highway at about 65 MPH. Without warning, the vehicle dashboard displayed “Selected Gear Will Engage at Lower Speed,” the vehicle shifted itself to neutral, the accelerator pedal stopped responding, and the vehicle began coasting to a stop. I had to avoid high speed highway traffic to make it to the side of the road. When I had slowed to about 5 MPH, the vehicle forcibly shifted to park, and engaged the parking brake on its own — causing an abrupt stop. I could not shift out of park. The check engine light, wrench icon, traction icon all illuminated, the chime sounded and a series of errors displayed: “Service Advance Trac” “Collision Prevention Unavailable” “Hill Start Unavailable” “Service Engine Soon” among others. After power cycling the vehicle, the warning messages and icons remained, but I could shift into drive. However, the vehicle wouldn’t travel above 30 MPH, and seemed to accelerate on its on, as if it were on cruise control set at 30 MPH. Abruptly stopping on the highway is very dangerous, and could have caused a serious accident. Unless there is a catastrophic failure (which there wasn’t) the vehicle should never uncontrollably stop, especially on the freeway.

I got recall notices in the mail in May. Unfortunately Ford of Kirkland (WA) Could not schedule me for an update until July 25th, that is their first opening because of all the recalls. On [XXX], 2024 at [XXX] I was traveling NW on [XXX] from Yakima WA to Ellensburg WA. I was traveling about 75 mph when the car shifted itself to a lower gear, then lights started flashing all over the dash for numerous things. the monitor stated something about low gear, service engine light on, diagnostic was being run, all in a matter of seconds. As I was looking to see if I could get over the truck's collision brakes activated even though there was no one in front of me. I lurched forward while my truck was slamming on the brakes out of the blue. I managed to make it to the side of the highway and shut off the truck. If anyone had been behind me they would have slammed right into me. This would have been a high speed rear end collision and I as well as others could easily have been killed! This was needless to say, terrifying! A tow truck came and towed the truck to Valley Ford in Yakima WA, I haven't yet heard what the analysis of this total system failure was. I waited in the truck for an hour for a tow along side a very busy highway with numerous large semi's passing me less that a couple feet from the driver's side where I was seated. This should NEVER happen to anyone. Ford cannot manufacture a vehicle that is this inherently dangerous! It's just a miracle no one was right behind me or there would have been major injuries, and it would not have been my fault, or their fault. It would have been Ford's fault! These trucks need to be taken off the roads. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Was driving at 60 mph, without warning vehicle displayed error with power train module and shifted in to neutral. Vehicle lost engine power and would not respond. Vehicle would not shift into drive, pressing on accelerator pedal did nothing. Without warning vehicle shifted itself into park very abruptly. Could not shift into drive or low drive. Turned vehicle off and the. back on, vehicle would shift into drive. Attempted to get out of the flow of traffic, would not accelerate, almost collided with another vehicle. Vehicle would only accelerate to 30-35mph.

The vehicle shakes when accelerating from between 10 miles and 50 miles. Took the vehicle to the dealership and found out both the front CV axles were defective. My truck only has 39K miles, and when I researched online, saw many other owners whose vehicles were built in 2022 and 2023 complain of the same issue. It tells me the CV axles and associated hardware is of poor quality and should not have been installed in the first place. Ford needs to offer a replacement/recall on these CV axles and extend the power train warranty beyond 60K for such shoddy quality parts.

The Maverick unexpectedly switched to limp mode and had engine failure while in motion. The Maverick would not go over approximately 25mph unless coasting faster on a downhill. On some uphills, it struggled to maintain 10mph. Turning the vehicle off and back on again did not alleviate the issue. Approximately two months ago, I started to have a check engine light on. It took the dealership two months to get my Maverick in for service. The service finally occurred this past Monday/Tuesday (13-14 May). Ford thought they fixed the issue which they had not. They also did the current recalls on the truck. This most recent highly dangerous issue happened after those recall software updates. The FordPass Alert: "The powertrain control module has detected the engine timing chains have exceeded 95% of their useful life and requires service now. The control system invokes a symptom of limited power." This is a common issue amongst Maverick Hybrid owners and Ford is not doing anything to fix the issue. Many Maverick owners are having it happen multiple times and at speeds up to 70 or 75 mph. it is preferable that Ford be forced to take responsibility and fix the issue before people are serious injured or killed. Thank you.