2022 Ford Maverick Hybrid

Had recall updates completed 3-11-24. ..23C41, 24C01, 23E09, 23E07 3-12-24 Maverick dies on the interstate going around 65mph. It just stopped running. I was able to pull over and after waiting several minutes was able to continue driving with the check engine light on. Took it back to the dealer and was told nothing was wrong. It has happened 2 more times dyeing at 65mph. 3-13-24 and 3-19-24

After having two recalls done on 2/29 the next day my vehicle dashboard lit up like a Christmas tree. There was a message about low gear, the shifter was blinking, I lost collision assist, traction control, and something called bill start. I was able to pull over and shut it off. When I restarted a minute later it accelerated on its own with no input from me. Braking worked but it was slowly moving up in speed.

Today I was driving on the highway when the precollision alert came on with no vehicles in front of me. About 5 minutes later I received a series of error messages and the vehicle went into a limo mode where it automatically drove at 20 MPH with no accelerator input from the driver. The following errors popped up on my screen. Check engine light Power train light (wrench)/reduced power Brake light pre-collision light/pre-collision unavailable Hill assist message Will engage in gear selected at low speed. Pulled over, shut it off, turned it back on, put in drive and it started accelerating on its own but only up to about 20mph, stopped and shut it off again. Turned back on and all the messages and light disappeared except check engine light remained on.

This Hybrid XLT maverick is equipped with Auto Brake/Stop while the vehicle is at a stop sign or red light. Two times the vehicle moved forward when the car in the front took their foot off from the brake pedal. The maverick was in full electric mode while Auto Engine Stop was activated and while the other vehicle moved forward, the maverick's Hybrid system switched to regular gas power and moved forward. Onetime the maverick give me the forward collision warning and the other time it didn't and my number plate touched the other car's bumper before i could manually brake the vehicle.

Brakes: ford already issued a TSB but this is more recall level issue (22-2493). At low speeds the breaks as applied so not work and then eventually “wake up” and grab hard due to the operator having to press much harder on the brakes to engage. This is not safe and should be a full recall with an investigation. There are many threads that discuss this on the internet, I am also experiencing it. It’s a matter of time before someone gets rearended because the Maverick brakes don’t work at low speeds well. Separately, flashing lights from the sun through the trees triggered a early collision warning for me once which I thought was odd. The cause is a guess but there were not other cars in front of me.

This is a hybrid braking issue where an extreme loud 'clunk' noise which can be felt coming from under the car at low speed less than 10 miles an hour when braking the car. In addition, the brakes seem to not engage properly at stop and go traffic forcing driver to stomp on the brakes to make the car stop. The brakes sometimes won't release after stopping forcing the driver to hit the throttle where the car suddenly lunges forward after the sudden release of the brakes. The Forward Collision warning also comes on unexpectedly without having another car in front of me. Happened twice since ownership of the car. Seems to be common in cold weather.

While driving in traffic on the highway at about 20-30 mph, traffic in my lane slowed further. In response, I applied what should have been an adequate amount of brake pressure to slow down and stop if needed given the following distance I had left. Initially I progressively applying more braking pressure, but after a ~3 seconds of this I slammed the brake down. Instead, the vehicle did not slow as expected in the following ~5 seconds. Despite having slammed on the brake at that point, the vehicle only then showed the emergency braking alert and emergency braked in addition to my foot being fully down on the brake. However, this was too late as my passenger and I rear-ended a Toyota Tacoma. They and myself have filed against my insurance, so there is an accident on my car report that I know has depreciated my new vehicle’s value. Although I do not currently have the Toyota’s estimate, I believe I can ask the owner or my insurance for this. Previously, I had several rear-ending close calls in the car when in traffic and I knew that I often struggled to slow down at stop lights when they first turn yellow. As a result, I’ve often sped up to beat the red since I knew my vehicle struggles to brake in time. My car is currently being repaired by the closest dealership to my SO, but I no longer trust the vehicle. I believe my hybrid maverick does not adequately mechanically brake since it over relies on the weaker regenerative braking. The dealer has attempted to replicate the issue at this point but my vehicle is available for further inspection upon request. I am happy to answer any additional questions.

Maverick Hybrid brakes are inconsistent. Sometimes you can brake smoothly, sometimes you cannot and the brakes will grab suddenly and lurch. Using Adaptive Cruise is miserable because the truck lurches back and forth and feels like it can't transition between friction and regenerative braking. There are no warnings on dash, truck has 1,000 miles. It is dangerous because getting more braking force than you anticipated can lead to being rear ended and not getting the brake force you anticipate can cause you to rear-end someone else.