NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
155 reportsClear category filterMileage unknown · Oct 20, 2025
Electrical SystemSteeringVehicle Speed Control
While driving in local traffic, my vehicle completely shut down. All power was lost. The engine shut off, shift control was disabled and the power steering did not work. Several warning lights were displayed including a "shift to neutral" warning, which was disabled. I was unable to restart the vehicle. After sitting for 10 minu…
Read full complaint
While driving in local traffic, my vehicle completely shut down. All power was lost. The engine shut off, shift control was disabled and the power steering did not work. Several warning lights were displayed including a "shift to neutral" warning, which was disabled. I was unable to restart the vehicle. After sitting for 10 minutes, the vehicle was started and resumed normal operations. This has happened on more than one occasion. The local dealership has kept the vehicle and cannot duplicate the failure or determine the cause. I am concerned that this could happen on the highway and cause myself or other travelers to be injured.
NHTSA ODI #11694533
77,000 miles · Oct 2, 2025
Electrical SystemPower Train
The contact owns a 2022 Ford Maverick. The contact stated that while making a right turn, the vehicle stalled and failed to restart. The contact was able to coast into the turning lane. The vehicle was towed to the dealer; however, no cause for the failure was found. The vehicle remained at the dealer unrepaired. The manufacture…
Read full complaint
The contact owns a 2022 Ford Maverick. The contact stated that while making a right turn, the vehicle stalled and failed to restart. The contact was able to coast into the turning lane. The vehicle was towed to the dealer; however, no cause for the failure was found. The vehicle remained at the dealer unrepaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 24V267000 (ELECTRICAL SYSTEM, POWER TRAIN). The failure mileage was approximately 77,000.
NHTSA ODI #11691090
Mileage unknown · Aug 14, 2025
Electrical System
Vehicle dashboard started flashing a service warning while driving and then immediately going away. Afterwards, electrical system failed when vehicle was put into park. No lights or any electrical functions were working. Issue is consistent with program 22B39. Ford had not contacted me about this issue in the past when it was fi…
Read full complaint
Vehicle dashboard started flashing a service warning while driving and then immediately going away. Afterwards, electrical system failed when vehicle was put into park. No lights or any electrical functions were working. Issue is consistent with program 22B39. Ford had not contacted me about this issue in the past when it was first discovered.
NHTSA ODI #11680613
Mileage unknown · Jul 18, 2025
Electrical System
Truck will enter a deep sleep. Will not start, will not unlock with fob, lights will not turn on. This has happened 2 times. Battery harness is faulty according to dealership.
NHTSA ODI #11674464
Mileage unknown · Jul 8, 2025
Air BagsElectrical SystemService Brakes
My 2022 Ford Maverick hybrid is known to have an issue with water leaking into the cabin from the cowl. This water is leaking onto the floorboards and there is some mold growing behind the electrical box. WHICH IS NOT GOOD AND IS SAFTEY AND HASZARD TO OUR HEALH TO BREATH THIS IN THIS NEED TO BE SENT OUT AS A RECALL AND FIX FOR F…
Read full complaint
My 2022 Ford Maverick hybrid is known to have an issue with water leaking into the cabin from the cowl. This water is leaking onto the floorboards and there is some mold growing behind the electrical box. WHICH IS NOT GOOD AND IS SAFTEY AND HASZARD TO OUR HEALH TO BREATH THIS IN THIS NEED TO BE SENT OUT AS A RECALL AND FIX FOR FREE OR BUY BACK THE vehicle
NHTSA ODI #11671874
9,000 miles · Jun 27, 2025
Electrical SystemPower Train
The contact owns a 2022 Ford Maverick. The contact stated that the rotary gear shifter was stuck in park(P). The contact had to wait for over 15 minutes for the rotary gear shifter to move. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that rece…
Read full complaint
The contact owns a 2022 Ford Maverick. The contact stated that the rotary gear shifter was stuck in park(P). The contact had to wait for over 15 minutes for the rotary gear shifter to move. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that recently the rotary gear shifter moved independently when touched by the arm. The vehicle was not diagnosed or repaired for the most recent failure. The contact stated that the failure persisted. In addition, while using the USB plug, there were several unknown messages displayed on the screen. The contact stated that after a while, the radio turned off independently. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.
NHTSA ODI #11669761
Mileage unknown · Jun 18, 2025
Electrical SystemEngineFuel/propulsion System
1)After sitting for 2 days the battery was drained or dead. The truck would not start. I jumped the truck and it started up. Every time I park the truck i get a warning that the battery is low and I should drive it to recharge the battery. I drive the truck but it will not recharge. 2) The check engine light comes on. I went to …
Read full complaint
1)After sitting for 2 days the battery was drained or dead. The truck would not start. I jumped the truck and it started up. Every time I park the truck i get a warning that the battery is low and I should drive it to recharge the battery. I drive the truck but it will not recharge. 2) The check engine light comes on. I went to the auto parts and scanned for diagnostics. The scan came back as a fuel tank pressure sensor failure. 3) When I drive the truck it smells as if something is burning. 4) The fuel gage is not showing accurate reading. 5)The fuel door wont open unless I have the truck turned on and then it takes several minutes. 6) After driving on the freeway I came to a stop on the off rap before entering a main street and the truck died.
NHTSA ODI #11667821
Mileage unknown · Jun 16, 2025
Electrical System
Recently, the rear passenger window went down and will not go back up. Searching the internet, this is a common problem. This is a safety issue from weather and noise as well as roadway debris if not repaired. While it is a common problem, Ford is not covering this safety issue as a recall.
NHTSA ODI #11667068
Mileage unknown · Jun 13, 2025
Electrical SystemEnginePower Train
Vehicle lost all power while driving. This was due to a failure of the hybrid system. Created a dangerous situation as vehicle started coasting without power in neutral.
NHTSA ODI #11666668
Mileage unknown · May 29, 2025
Electrical System
Positive battery cable went out which is a $1500 repair. It appears that this is quite a common issue. Ford has previously offered a "battery cable overlay" Program 22B39 which appears to use a smaller gauge wire. Sounds like a mickey mouse fix to an issue that isn't owner related.
NHTSA ODI #11663743
NHTSA investigations
1RQ24014 · Loss Of Motive Power
Opened Nov 15, 2024 · Closed Oct 10, 2025
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration