2017 Ford Fusion

The contact owns a 2017 Ford Fusion. The contact stated that after reversing the vehicle and then shifting to drive(D), the vehicle rolled backward with the transmission failure warning light illuminated. The contact was able to depress the brake pedal to stop the vehicle. The contact stated that the vehicle stopped, stalled, and could not be restarted. The contact disconnected the battery and waited for several minutes before restarting the vehicle and driving to the residence. The dealer and the manufacturer were contacted but offered no assistance. The contact was notified that the VIN was not included in NHTSA Campaign Number: 22V413000 (Power Train). The failure mileage was 91,000.

All right, so I have a little bit of bad news for you, so we hooked up a code reader to the car. And there were a couple of misfires. So there's a cylinder to misfire a cylinder or a random misfire detected, a cylinder 3, misfire a cylinder one misfire. So our service advisor thinks that it's probably not an issue with a coolant. An issue with the head gasket, and he would recommend that that gets replaced. And he said, at some point, you might need to replace the entire engine.

The contact owns a 2017 Ford Fusion. The contact stated that upon taking the vehicle to the dealer for servicing, he was informed that all twenty of the lug nuts were swollen and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The dealer and the manufacturer were informed of the failure. The contact was notified that the failure was a known issue. The failure mileage was approximately 34,920.

Stopped vehicle at a drive though and put in in park. Afterword would not shift into drive, only in reverse. Had to back all the way through a parking lot to find a safe place to try to park as not to be in the way of other vehicles. Fortunately, at the time no one was parked behind me. after turning off the car, it would not start again and had to have the vehicle towed to a dealership for repair. There is a recall on many Ford vehicles for this exact same issue due to a shift cable bushing, but for some reason not on this particular vehicle. No warning lights appeared before the issue, only after I killed the car and tried to restart it.

Driving vehicle, Steering Assist Fault light comes on, steering wheel locks and vehicle becomes very difficult to operate. Locally, Ford dealership will not inspect as they will not take any calls in the service department. This is the second time this has happened to this vehicle. Vehicle has been previously taken to dealership, to which dealer was “unable to diagnose issue.” Vehicle was subsequently repaired, as an independent service center was able to diagnose issue and repair. Vehicle drove well for 4 months until today, when second incident occurred. In this situation, other vehicles on the road were in danger as I was unable to turn from turning lane, driving into outer tuning lane, almost striking another vehicle. Luckily, I had slowed down enough for vehicle to drive passed me without incident. There is something inherently wrong with the 2017 Fusion’s Power rack and Pinion Gear, and I implore Ford to do the right thing and look into this matter, as this issue is ongoing and widespread.

The contact owns a 2017 Ford Fusion. The contact stated that while accelerating at 65 MPH, the vehicle began to shake and hesitated with the check engine warning light illuminated. The contact stated that the vehicle would not accelerate above 60 MPH; the contact was able to drive the vehicle to the residence. The vehicle was then towed from the home to the dealer where a diagnostic test discovered that coolant had leaked into the cylinders. The manufacturer had been notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 75,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving approximately 70 MPH, coolant entered the engine and the engine overheated. The check engine warning light was illuminated. The vehicle lost motive power and stalled in a construction area. The contact refilled the coolant reservoir and drove to his residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 181,000.