2017 Ford Fusion

I got in my 2017 Fusion SE to leave my house. As I started out of my driveway, I noticed that the steering was hard and I had a " Steering Assist Fault, Service Required" lamp on. I did not drive the car that day. The car drove fine the day before. I called my local mechanic to take my car into the shop to have him check the vehicle. As I drove the vehicle to the shop, I noticed that it was very hard to steer and the steering made a grinding noise. The shop called later and advised that the rack and pinion sensor was bad and needed replacing. The shop advised that the only way to repair it was to replace the rack and pinion. My mechanic advised that he has seen this problem with other 2017 Ford Fusions. The shop advised that the cost would be $3000.00. I was shocked at the cost, but I authorized the repair. The mileage on the vehicle was 39,650. I am just thankful that I was not driving the car on the road at the time that this went bad. There was no warning with this. I did look on this web sight and found that this is not an uncommon problem with the 2017 Fusions. I believe that because the sensor cannot be replaced on its own, that Ford should fix this dangerous problem and do a recall. How long until this happens a second time? Should I sell this vehicle before it happens again? I just hope I am not driving the next time the sensor goes out.

The contact owns a 2017 Ford Fusion. The contact stated while driving 75 MPH, the vehicle started shaking uncontrollably with the check engine warning light illuminated. The contact stated that she was able to drive the vehicle to her residence and later had the vehicle towed to the dealer. The dealer diagnosed the vehicle and determined that coolant was leaking into cylinder #2 and that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 22-2134 which expired on November 30, 2022, and the contact experienced the failure on December 1, 2022. The contact stated that the dealer and the manufacturer denied the repair because the TSB had expired. The approximate failure mileage was 107,300.

My 2017 Ford Fusion suddenly has a brake fluid leak and all fluids have been previously checked on a routine basis. My brakes suddenly wouldn’t work while driving and trying to come to a stop and I had to pull on my emergency brake and then put in park as it will not stop completely while sitting at a red light or intersection. I have read the multiple complaints that have been reported with this problem and I am also reporting this issue with my 2017 Ford Fusion as well!

Over the past 6-8 months, I have replaced the front passenger brake line two times and the front driver side brake line once. If needed, I have receipts showing I have purchased brake fluid and new brake lines on three separate occasions in recent months. I have pictures of the most recent brake line failure. On all three occasions the brake lines have split/burst, I’ve had no warning the brakes are failing or losing fluid or pressure. The low brake fluid light does not come on till minutes after the brakes fail. don’t know there’s a problem till I try to stop and the pedal goes straight to the floor. Right before the brake pedal hits the floor, there’s minimal braking power and you can gradually slow down. The last time this happened I was on the PA turnpike outside of Pittsburgh traveling 70mph. This was extremely unsafe, I thought for sure I was going to cause a major accident as I could not the stop the car in rush hour traffic.

The contact owns a 2017 Ford Fusion. The contact stated while driving 35 MPH, the temperature gauge showed that the engine was overheating. The message “Engine Overheating – Stop Vehicle” was displayed. The vehicle was towed to the dealer to be diagnosed; however, no failure was found. The contact stated that the coolant reservoir was empty. The contact stated that coolant was added; however, the failure recurred. The contact stated that on another occasion while exiting her driveway, the vehicle failed to properly accelerate. The vehicle was taken to an independent mechanic, and he stated that the vehicle was experiencing a failure like the failure listed in Customer Satisfaction Program: 21N12. The vehicle was not repaired. The contact made several attempts to schedule an appointment; however, none of the dealers would assist. The contact stated that another dealer informed her that the Customer Satisfaction Program was no longer valid. The manufacturer was not contacted. The failure mileage was 122,150.

On 12/08/2022, my 2017 Ford Fusion started as normal in a busy parking lot, but once I idled/moved just a little, it became locked as if the emergency brake was on (it was not) and would not shift out of park, regardless of trying to put in neutral, reverse, etc. (It would show N or R on the dash, but remained deadlocked in Park.) There was this error message: "SHIFT SYS FAULT Service Required." It took several people to push the car to a safe area out of the way of traffic. Had to have the car towed at owner's expense to the closest Ford dealership. There were not other messages or signs of the problem prior to this failure on 12/08/2022. Ford dealer on 12/10/2022 removed and replaced transmission shifter cable bushing and installed cap. Ford dealer agreed that most certainly, this 2017 Ford Fusion has the EXACT same recall #22s43 that other 2017 Fusions have had. However, when Ford dealer entered this vehicle VIN, nothing showed up in OASIS. So I had to pay for this repair out of pocket. Like others have stated, the Ford recall #22s43 is too narrow in scope. So why in the world am I having to pay 100% of the cost to fix the EXACT SAME bushing/cap issue (recall 22s43) that others are having with the EXACT SAME YEAR, MAKE, & MODEL?!?! Just because my VIN wasn't included in Ford's original recall? DOES NOT MAKE SENSE! If it's the same issue as the other vehicles are having (of the same year, make, model) why am I paying for the error and they aren't?

The problem is in the gear shifting. The problem is the same problem many others are having on 2017, but are not included in the recall. The recall is Fords number for this recall is 18S08. Several hundreds have filed a complaint but Ford will not expand the recall to include the 2017. This is a safety issue that needs to be addressed by Ford and NHTSA. The current recall effected 650,000 cars but not the 2017 Ford Fusion.