2017 Ford Fusion

Engine light came on and heat and defrosters stopped working in vehicle. Took it into dealer and was told diagnostic code was for misfire in cylinder 3. They did a coolant leak test and immediately found coolant leaking into the engine. Was told this was a known issue with the 2.0L ecoboosts (TSB 22-2229 dated 6/9/22) and that I would need an entire engine block replacement. Due to being out of warranty I would be on the hook for $6,856 for the repairs. Car only had 45,000 miles on it at time of service.

Vehicle lost ability to drive forward & reverse on the freeway. Upon inspection, the torque converter had gone bad & contaminated the transmission fluid causing the transmission to go out. Now my vehicle needs a new torque converter & transmission. There was a recall "17V427000" but it did not include my vehicle; however, it looks like the same issue.

About 4 weeks ago my car lost the ability to move while driving. The wrench light popped up to see manual. Upon checking the manual it stated that the problem was with the power train. I took it to get looked at and the service center further confirmed that it was a piece inside the transmission. I see that there was a safety recall issued in 2017 for the power train torque converter for 2017 Ford Fusions. However, when I type in my VIN number the recall does not appear for my car. Is there a way for the recall to be issued for my car being that I drive the exact car type that was affected and am having the same problem?

The contact owns a 2017 Ford Fusion. The contact stated that upon the start of the vehicle, the engine backfired with a cylinder misfire message displayed on the instrument panel. The vehicle was initially taken to an independent mechanic however, the cause of the failure was not determined. The contact was informed that the coolant level was very low. The contact frequently checked the coolant level and discovered that coolant was leaking but the location of the leak was not determined. The vehicle was then taken to two dealers, and it was discovered that there was coolant intrusion into cylinder #3, causing the engine to misfire. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was 73,719.

I went to my dealership because of a check engine light. After many hours of searching, I was told that a coolant leak had been found. I was informed that the head gasket was damaged and causing a leak into the engine. The cheapest repair would cost nearly $8000. The extended warranty that I purchased for the car has expired. Searching Google, I see that Ford is aware of the problem, and has known about it for some time. Ford should not be able to get away with this.

The contact owns a 2017 Ford Fusion. The contact stated that while parking the vehicle, the vehicle stalled. Upon restarting the vehicle, the vehicle failed to move forward or reverse. The system default warning light was displayed. The contact called the local dealer and was informed that the vehicle was not covered under the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 77,432.

The contact owns a 2017 Ford Fusion. The contact stated while driving 55 MPH, there was an abnormal sound coming from the engine compartment, after which the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that coolant had leaked into the engine, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was unknown.

The contact owns a 2017 Ford Fusion. The contact stated while accelerating from a complete stop, the vehicle shuddered and was sluggish. The contact stated that the failure recurred while driving and while reversing. The vehicle was taken to an independent mechanic, where the spark plugs were replaced; however, the failure recurred while driving at various speeds. The contact stated that the vehicle failed to exceed 30 MPH on one occasion. The check engine warning light was illuminated. The contact veered to the side of the road. The vehicle was towed to another independent mechanic, where it diagnosed that there was coolant intrusion in cylinder #3, and the engine needed to be replaced. The contact was referred to the dealer for repair. The vehicle was towed to the dealer, where the same assessment was made. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N12 and TSB Number: 22-2134; however, the dealer informed the contact that the vehicle was not covered. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2017 Ford Fusion. The contact stated that while starting the vehicle, there was blue smoke coming from the exhaust pipe. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed that there was coolant intrusion into the engine and determined that the short block needed to be replaced. The vehicle was then taken to the dealer to be repaired under NHTSA Campaign Number: 23V162000 (Service Brakes, Hydraulic) however, the dealer declined to perform Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion) associated with the VIN had expired. The failure mileage was approximately 130,000.