IllustrationI was driving and the car just stopped it wouldn't let me put in park or drive it just stayed in neutral. And I was stuck it kept the the emergency break on. Then it wouldn't turn off all the way which caused the car to drain battery.
2017 Ford Fusion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2017 Ford Fusion do not stand out strongly from the model-year median of 1,109.
About this comparison →How this year compares
Owner complaints by model year
Compare all Fusion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
920–25K
7925–50K
14550–75K
14975–100K
113100–150K
29150K+
607 reports with mileage · 502 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 394 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 310 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 134 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports8 fire reports24 injury reports
What owners actually said
1,109 reportsCoolant leak into engine block, ford dealership said $8,000 to replace engine cars only at 65k miles. Problem is from manufacturer defect in the 2.0l TT turbo engines in fusions and should be recalled as it’s not the owner/operators wrong doings.
Coolant intrusion, problem.
The contact owns a 2017 Ford Fusion. The contact stated that while driving approximately 35 MPH, the rear end of the vehicle unexpectedly locked up. There was no warning light illuminated. The vehicle became inoperable and was towed to the residence. The dealer was contacted. The vehicle was not diagnosed or repaired. The contac…
Read full complaint
The contact owns a 2017 Ford Fusion. The contact stated that while driving approximately 35 MPH, the rear end of the vehicle unexpectedly locked up. There was no warning light illuminated. The vehicle became inoperable and was towed to the residence. The dealer was contacted. The vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Campaign Number: 24V102000 (Power Train). The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.
Component/System: Engine — 1.5L EcoBoost short block coolant intrusion leading to catastrophic engine failure. Vehicle is available for inspection upon request. Safety Risk: Vehicle overheated while in operation, creating risk of engine fire, loss of vehicle control, and stranding of occupant on a public roadway. Ford's own TSB …
Read full complaint
Component/System: Engine — 1.5L EcoBoost short block coolant intrusion leading to catastrophic engine failure. Vehicle is available for inspection upon request. Safety Risk: Vehicle overheated while in operation, creating risk of engine fire, loss of vehicle control, and stranding of occupant on a public roadway. Ford's own TSB 22-2322 acknowledges this defect creates a fire risk. Confirmed by dealer/shop: YES Inspected by manufacturer/police/insurance: Ford Motor Company was contacted on 17APR26 and opened case number XXX but denied coverage citing vehicle assembly location [XXX] ) despite the defect being present in all 1.5L EcoBoost engines regardless of assembly plant. Warning symptoms: Vehicle exhibited overheating warning prior to failure. Coolant intrusion into cylinder bores is a known documented defect covered under Ford Customer Satisfaction Program XXX and TSB XXX for identical engines in US-assembled vehicles. Mileage at failure: Approximately 65,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Coolant light and check engine lights kept coming on. The car was diagnosed by the Ford Dealership as Ford TSB 22-2229, which is a design flaw in specific EcoBoost engines, where an "open deck" block causes coolant to leak into cylinders 2 and 3, leading to severe engine failure. To fix this issue, the TSB requires replacing the…
Read full complaint
Coolant light and check engine lights kept coming on. The car was diagnosed by the Ford Dealership as Ford TSB 22-2229, which is a design flaw in specific EcoBoost engines, where an "open deck" block causes coolant to leak into cylinders 2 and 3, leading to severe engine failure. To fix this issue, the TSB requires replacing the entire long block assembly with a redesigned version featuring enhanced sealing surfaces. The cost for this new engine was quoted as $8000 to $9000.
Dec 2022 I purchased a 2017 Ford Fusion. In June 2023 the engine needed replaced which was covered under warranty. In March 2026, the flex plate breaks and now needs to be replaced. This is the original part for this car as I confirmed with the dealer that this part isn't required to be replaced when the engine is replaced. S…
Read full complaint
Dec 2022 I purchased a 2017 Ford Fusion. In June 2023 the engine needed replaced which was covered under warranty. In March 2026, the flex plate breaks and now needs to be replaced. This is the original part for this car as I confirmed with the dealer that this part isn't required to be replaced when the engine is replaced. So it's not covered under vehicle warranty or the motor repair warranty. However, there is a known issue of these flex plates breaking and there is Customer Satisfaction Program 22N12 for Ford Fusions regarding this known issue that only covers years 2019 & 2020. I want the 2017 year to be added to this as a known issue.
Rear Backup Camera keeps malfunctioning. The display screen from camera glitches or goes black and eventually it will state that rear camera is not available.
Engine failure due to coolant intrusion.
2017 ford fusion started to drive rough and minutes later the check engine light illuminated. The car was immediately turned off and taken to a mechanic. The mechanic diagnosed it with coolant intrusion and advised to check for recall. There are no active recalls associated with the VIN. The car needs a new engine at 70,000 mile…
Read full complaint
2017 ford fusion started to drive rough and minutes later the check engine light illuminated. The car was immediately turned off and taken to a mechanic. The mechanic diagnosed it with coolant intrusion and advised to check for recall. There are no active recalls associated with the VIN. The car needs a new engine at 70,000 miles.
Official recalls
423V162000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Mar 10, 2023
Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.
18V167000 · Steering: Steering Wheel/handle Bar
Mar 12, 2018
Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
Consequence & remedy
Consequence: A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.
17V427000 · Power Train:automatic Transmission:torque Converter
Jul 6, 2017
Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Consequence & remedy
Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Remedy: Ford or Lincoln will notify owners, and dealers will replace the torque converters, free of charge. The recall began August 25, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16.
16V874000 · Seats:mid/rear Assembly
Dec 5, 2016
Ford Motor Company (Ford) is recalling certain 2017 Ford Fusion vehicles manufactured September 27, 2016, to September 28, 2016. The left rear seat backs pivot pins may have been improperly welded.
Consequence & remedy
Consequence: During a crash, the improper welds may fail, allowing any stowed luggage to move into the passenger compartment, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the left hand, second row seat back frame, free of charge. The recall began January 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S43.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ22004 · Front Brake Jounce Hose Failures
Opened Aug 8, 2022 · Closed Mar 24, 2023
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On August 8, 2022, the Office of Defects Investigation (ODI) opened this investigation based on 50 Vehicle Owner Questionnaires (VOQs) alleging front brake jounce hose ruptures on model year (MY) 2013-2018 Ford Fusion and Lincoln MKZ vehicles. A ruptured front brake hose results in a brake fluid leak. As a result, the driver may experience an increase in pedal travel and a reduction in the rate of deceleration, increasing the risk of a crash. It should be noted that the subject vehicles identified fell outside the scope of NHTSA Safety Recall 20V-469, which addressed front brake hoses rupturing on certain MY 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The result causes a brake fluid leak, lengthening the distance needing to stop the vehicle, increasing the risk of a crash.On March 10, 2023, Ford Motor Company (Ford) submitted to NHTSA Safety Recall 23V-162 (Ford Recall 23S12) to address front brake jounce hoses that may rupture. Ford found the rupture occurs from a localized failure of the internal reinforcement braid due to cyclic fatigue through tensile/bending and torsional inputs during suspension and steering articulations. The supplier for the front brake jounce hoses is Hitachi. This recall affects the subject vehicles equipped with non-hybrid engines and the suspect front brake jounce hoses (a total of 1,280,726 vehicles). The recall covers subject vehicles built from February 3, 2012 to July 19, 2017 when the suspect hoses were used in vehicle production. The remedy is for dealerships to replace both front brake jounce hoses with new hoses that have a revised braid material at no cost. The vehicles equipped with hybrid engines are excluded from the recall because the internal hose pressure is much lower due to the regenerative braking provided by the hybrid brake system. No failures of brake hoses on hybrid vehicles have been reported to ODI or Ford.Ford's actions address ODIs concerns at this time. Hybrid vehicles will be monitored for related failures. The agency reserves the right to take further action if warranted by new circumstances.The 103 ODI numbers cited above can be viewed at NHTSA.gov under the following ID numbers:11511014, 11510867, 11510318, 11509030, 11505993, 11504989, 11504400, 11502147, 11502082, 11501820, 11501283, 11498439, 11498296, 11496842, 11496335, 11494931, 11494851, 11494252, 11493001, 11492084, 11492070, 11491444, 11491274, 11488858, 11488027, 11487627, 11487416, 11487233, 11486150, 11484924, 11484526, 11484080, 11483948, 11483926, 11483739, 11483723, 11482773, 11482690, 11481077, 11480788, 11480294, 11480052, 11479338, 11479334, 11479252, 11479247, 11479187, 11479094, 11479048, 11478985, 11478953, 11478729, 11478216, 11476892, 11476282, 11470558, 11468994, 11467109, 11466294, 11462746, 11461217, 11456065, 11455367, 11444848, 11436419, 11436376, 11430685, 11428329, 11425083, 11421026, 11420738, 11420735, 11420298, 11418197, 11403926, 11397549, 11366991, 11366757, 11361016, 11359968, 11354569, 11352165, 11350344, 11348799, 11343929, 11343205, 11331947, 11329020, 11319596, 11310529, 11292271, 11288455, 11254787, 11253479, 11253244, 11234622, 11230669, 11230050, 11228240, 11221111, 11143630, 11129392 and 11120228.