2017 Ford Fusion

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel was extremely loose, prompting the contact to pull over to the shoulder of the roadway. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related it to NHTSA Campaign Number: 18V167000 (Steering), but the VIN was not included. The failure mileage was 82,000.

The contact owns a 2017 Ford Fusion. The contact stated while reversing, the steering wheel was significantly loose. There was no warning light illuminated. The contact stated that the failure persisted while driving. The dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because the recall repair of NHTSA Campaign Number: 18V167000 (Steering) was previously completed on the vehicle. The contact stated that the recall remedy failed to fix the vehicle. The failure mileage was approximately 90,000.

I got in my 2017 Fusion SE to leave my house. As I started out of my driveway, I noticed that the steering was hard and I had a " Steering Assist Fault, Service Required" lamp on. I did not drive the car that day. The car drove fine the day before. I called my local mechanic to take my car into the shop to have him check the vehicle. As I drove the vehicle to the shop, I noticed that it was very hard to steer and the steering made a grinding noise. The shop called later and advised that the rack and pinion sensor was bad and needed replacing. The shop advised that the only way to repair it was to replace the rack and pinion. My mechanic advised that he has seen this problem with other 2017 Ford Fusions. The shop advised that the cost would be $3000.00. I was shocked at the cost, but I authorized the repair. The mileage on the vehicle was 39,650. I am just thankful that I was not driving the car on the road at the time that this went bad. There was no warning with this. I did look on this web sight and found that this is not an uncommon problem with the 2017 Fusions. I believe that because the sensor cannot be replaced on its own, that Ford should fix this dangerous problem and do a recall. How long until this happens a second time? Should I sell this vehicle before it happens again? I just hope I am not driving the next time the sensor goes out.

The contact owns a 2017 Ford Fusion. The contact stated that after his son came to a stop at a stop signal, there was a loss of power steering functionality, and the steering wheel became difficult to maneuver. The TPMS warning light was intermittently illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the power steering control module needed to be updated and the steering gear assembly needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 59,250.

Driving vehicle, Steering Assist Fault light comes on, steering wheel locks and vehicle becomes very difficult to operate. Locally, Ford dealership will not inspect as they will not take any calls in the service department. This is the second time this has happened to this vehicle. Vehicle has been previously taken to dealership, to which dealer was “unable to diagnose issue.” Vehicle was subsequently repaired, as an independent service center was able to diagnose issue and repair. Vehicle drove well for 4 months until today, when second incident occurred. In this situation, other vehicles on the road were in danger as I was unable to turn from turning lane, driving into outer tuning lane, almost striking another vehicle. Luckily, I had slowed down enough for vehicle to drive passed me without incident. There is something inherently wrong with the 2017 Fusion’s Power rack and Pinion Gear, and I implore Ford to do the right thing and look into this matter, as this issue is ongoing and widespread.

Steering wheel wobbles and is loose. Can pivot up, or right / left about an inch. NOT a rotational loose (like worn bushings). Pivot point is right behind the wheel itself, as if it was the bolt that is part of other recalls (but 'not applicable' to my VIN???). Only 33k miles on car. 2017 year Fusion. Taking to dealer to "fix" today. Issue noticed during light morning commute on 5/18/2022 No other inspection to date. No warning lamps, messages, or other notices, now, or prior.

Power Steering became difficult to turn and handle while driving, this just suddenly happened without warning, my Son's safety was at risk by not being able to handle the steering, shortly after the Steering Assist Fault warning light came on, Service Traction Advance warning light and Hill Assist not working light came on. He shut the car off for about 10 mins and restarted the same lights are on. He is unable to drive it due to the steering is so hard. About 2 weeks prior to the above incident, transmission went out (it was repaired). Waiting to hear back from warranty company

The contact owns a 2017 Ford Fusion. The contact stated while driving 75 MPH, the service advancetrac and another unknown warning light was illuminated. The contact stated that the steering wheel became difficult to turn. The contact was able to drive to his destination. The contact took the vehicle to the local dealer and made them aware of the failure. The contact was informed that NHTSA Campaign Number: 18V167000 (Steering) was not associated to the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 132,748.