2017 Ford Fusion

The engine over heats out of nowhere. We took it to a Ford dealer, our car has 68,000 miles on it and we are being told we need a full engine replacement at a cost of $9,000. There was a technical service bulletin put out 12/10/2019. Ford is aware of this issue on two models for a few years. No compensation or recalls are being offered.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at various speeds, the engine misfired, causing the vehicle to jerk while depressing the accelerator pedal. The contact also stated that white colored smoke was coming from the exhaust pipe with the check engine light illuminated. The vehicle was initially taken to an independent mechanic who discovered that coolant had leaked into the engine block. The vehicle was then taken to a dealer who confirmed the failure. The manufacturer was notified of the failure, and the contact was informed that the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 105,000.

I purchased a Ford “Reclaim” from a dealership that said the vehicle was in good working order and that Ford had fixed all prior issues and I was ensured by the dealer that Ford can not put an “unsafe” reclaim back out on the market. After starting to have issues with the vehicle myself (at approx 50k miles). I located the previous warranty claims on the vehicle. At 33k miles the previous owner had the short block engine repaired in 2020 due to coolant leaking into cylinder 3. In October of 2022 I took the 2017 Ford Fusion 1.5L into a independent shop with concerns that it was blowing white smoke out of the tailpipe. A chemical test was ran and “no indication of a blown head gasket”. I was advised to take it to the dealer. I did, they were unable to run diagnostic at that time but put a mark on the coolant reservoir. In May 2023 the car was still blowing white smoke from tailpipe on start up, I had lost approx 2” of coolant from reservoir and oil was reading overfilled but no milkiness. I took it back to dealer who did diagnostic and coolant was once again leaking into a cylinder; they said repair was possibly covered under a ford CSP program as long as I was under 84k miles. I was at 80150. They are replacing the short block (for the second time) under the CSP, however this should be an investigation or even a full recall as so many people have reported this issue and fords “all access” to this CSP only lasted 4 months, and now has a mileage cap. This 2017 Fusion has needed two engines block replacements in less than 84k miles. I am fortunate I did not sustain an accident or injuries due to engine failure.

The contact's partner owns a 2017 Ford Fusion. The contact stated while his partner was driving 40 MPH, the check engine warning light illuminated, and the temperature gauge started rising. The driver stated the vehicle started to vibrate and lost motive power while attempting to accelerate. The driver continued driving to the residence. The contact inspected the vehicle and noticed the engine short block needed to be replaced. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 55,000.

The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was idling, the vehicle shuddered. Additionally, the check engine warning light was illuminated. The vehicle was taken to the dealer, who informed the contact that there was coolant intrusion into the cylinder and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was 60,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the engine misfired and the vehicle decelerated. The contact then stated that the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that coolant had leaked into the cylinder and cylinder #4 misfired. The contact was informed that the short block and head gasket needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the VIN was not included in a recall. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The contact was provided a case number. The failure mileage was approximately 70,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving 45 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer and the dealer stated that coolant was leaking into the engine and that the vehicle was previously repaired under Customer Satisfaction Program: 19B37. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was not under recall and advised to contact the NHTSA Hotline for assistance. The failure mileage was 108,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the ABS warning light illuminated intermittently and the steering wheel seized. The vehicle was taken to an independent mechanic, who informed the contact there was a failure with the serpentine belt. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.