Air Bags. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports4 fire reports23 injury reports

What owners actually said

730 reports

254,447 miles · Mar 15, 2022

Air BagsCrashInjury

Read full complaint

The contact owned a 2006 Ford Fusion. The contact's husband was driving in poor weather conditions speed unknown, hit ice and the vehicle skidded into a streetlight pole on the passenger side door. The vehicle caromed across the road and hit the opposite curb and rolled onto the roof. The contact stated she was not aware of any warning lights being illuminated. The contact said that the driver’s side airbags did not deploy, and the passenger side airbags deployed but did not inflate. The police wrote out a traffic report and the driver were transported by ambulance to a hospital with injuries to his back, neck and head requiring emergency surgery. The passenger was being taken by the contact to a hospital today sustaining head pain and wrist pain. The vehicle was towed to an impound lot. The vehicle had not been diagnosed. The vehicle will not be repaired. The contact stated that she had received a recall letter for the air bags and that the vehicle had been taken to a local dealer. The manufacturer had not been informed of the failure. The failure mileage was approximately 25,4447.

NHTSA ODI #11456789

Mileage unknown · Nov 18, 2021

Exterior Lighting

Read full complaint

My front right turn signal suddenly stopped working. It lights up but won't flash. Due to this problem I have had numerous near crashes because other cars cannot tell that I am signaling to turn or change lanes. It was only because I double check where surrounding cars are that I have been able to avoid a crash. I have taken it to the dealers service center but they were not able to fix it in the three and a half days they had it. I finally had to go get it because I needed a vehicle to go to work and could not wait any longer. There were no signs that there was a problem until I noticed it wasn't flashing. The inside display and sound of the turn signal are all normal and I am unsure of when the problem first happened because the inside display has no abnormalities.

NHTSA ODI #11440942

Mileage unknown · Sep 13, 2021

Electrical System

Faulty evap temperature sensor on my 06 Ford Fusion I purchased a couple of months ago. It is a huge safety issue, the vehicle thinks it’s running ICE COLD when it’s over 100 degrees outside. It emits hot or fluctuating air at random and it’s giving wrong readings which can cause the car to overheat or not sense when it is overh…

Read full complaint

NHTSA ODI #11432703

Mileage unknown · Aug 21, 2021

Service Brakes

I've been hearing air in my brakes for two days and my brakes were not working as good as before. I haven't lost any brake fluid. As I was driving down the road and while braking to stop my brake pedal hit the bottom of my foot really hard and brakes went completely out and all I could hear was air and the brakes became almost i…

Read full complaint

NHTSA ODI #11429994

Mileage unknown · Jun 18, 2021

Service Brakes

Read full complaint

Safety Recall Notice 19S54/NHTSA Recall 19V-904 Received recall notice April 2021 that the parts HCU (hydraulic control unit) for the antilock brake system is faulty. Brought to the dealer on April 21, 2021, Sayville Ford, Sayville NY and they told me to pick up the vehicle, had the same soft pedal. Drove it home and 2 weeks later hit an uneven surface and pedal went to the floor, had to pump numerous times to stop, almost hit a parked car. This had happened 2 times before I received the recall notice and both times ended up in the intersection. Brought it back to Sayville Ford they had it for 2 weeks and called me to tell me that Ford Motors Denied the claim and will not fix the problem. I bought this vehicle new in 2006 for my wife and I will not let her drive it. It is very dangerous to be driven on the road at this point. The vehicle has only 32,000 miles I spoke to Ford Motor Corp and they will not honor this Recall 19S54. Please help, I do not know where to go from here. My name is [XXX] and my wife name is [XXX], we live in Bohemia NY my phone #[XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11421411

Mileage unknown · Jun 7, 2021

Exterior Lighting

The headlights are so foggy that night driving is dangerous. I applied a liquid to the exterior of both lights and that improved visibility for about a year. I believe this is caused by a reaction to the plastic used on the lenses. The vehicle is available for inspection however I have not taken it to a dealership for this prob…

Read full complaint

NHTSA ODI #11420028

Mileage unknown · Jun 1, 2021

Air BagsService Brakes, Hydraulic

Read full complaint

The contact owns a 2006 Ford Fusion. The contact stated that the brake pedal would depress to the floorboard without warning. The contact had the brake master cylinder replaced by an independent mechanic however, the failure persisted. The contact stated that the air bag warning light illuminated on the instrument panel. The contact received notifications for NHTSA campaign numbers: 19V904000 (Service Brakes, Hydraulic) and 21V158000 (Air Bags) however, the parts to do the recall repairs were not yet available. The dealer was contacted and confirmed that the parts were not yet available. The contact then called Century Ford of Mt. Airy (302 Century Dr, Mt Airy, MD 21771) where she was informed that part could be ordered. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was unknown. Vin tool confirms parts not available.

NHTSA ODI #11419153

50,000 miles · May 11, 2021

Unknown Or Other

Read full complaint

THERE'S A BLATANT TRANSMISSION SAFETY CONCERN FOR ALL 2006 FORD FUSIONS. ACCORDING TO MULTIPLE WEBSITES WITH FORUMS, HUNDREDS OF PEOPLE HAVE BEEN EXPERIENCING TRANSMISSION CONCERNS. THE ISSUE IS WHEN ACCELERATING, THE CAR SLIPS OUT OF GEAR AND VIOLENTLY LURCHES FORWARD AND NO LONGER ACCELERATES, CREATING AN EXTREME SAFETY HAZARD ESPECIALLY ON THE HIGHWAY. THE ONLY WAY, AT LEAST FOR ME, TO GET IT BACK INTO GEAR IS TO COMPLETELY STOP ACCELERATING FOR A FEW SECONDS AND THEN TRY ACCELERATING AGAIN. THIS IS ABSOLUTELY A SAFETY HAZARD ON THE HIGHWAY AND STREET DRIVING. NO MECHANICS OR FORD MECHANICS HAVE BEEN ABLE TO FIX THIS ISSUE, ONLY RECOMMEND THAT THE TRANSMISSION BE REPLACED, WHICH IS NOT AN IDEAL REPAIR, ESPECIALLY WHEN THIS IS HAPPENING AS SOON AS 50,000 MILES HAVE BEEN PUT ON THE CAR. I'M SCARED TO DRIVE MY CAR, ESPECIALLY ON THE HIGHWAY BECAUSE MY ACCELERATION IS LIMITED AND THIS COULD HAPPEN AT ANY TIME. THIS HAS BEEN HAPPENING TO MY CAR SINCE IT HIT 50,000 AND THERE'S NO WAY I CAN AFFORD A NEW TRANSMISSION, NOR SHOULD I HAVE TO REPLACE IT SINCE THIS HAS HAPPENED IN MULTIPLE 2006 FORD FUSIONS. THIS ISSUE HAS ALSO HAPPENED TO MY DRIVING AROUND TOWN. THERE ARE MANY REPORTS ON HTTPS://REPAIRPAL.COM/TRANSMISSION-PROBLEM-242 AND SOME ON HTTPS://WWW.CARCOMPLAINTS.COM/FORD/FUSION/2006/TRANSMISSION/TRANSMISSION_FAILURE.SHTML AND HTTPS://FORDPROBLEM.COM/2006-FORD-FUSION-POWER-TRAIN-AUTOMATIC-TRANSMISSION-PROBLEMS-DEFECTS/AMP/

NHTSA ODI #11416167

50,000 miles · May 11, 2021

Unknown Or Other

THE TRANSMISSION SLIPS WHEN ACCELERATING AND VIOLENTLY LURCHES THE CAR FORWARD. THIS IS EXTREMELY UNSAFE AND THERE'S NO REASON WHY THE TRANSMISSION SHOULD BE REPLACED. I AM NOT THE ONLY ONE WHO EXPERIENCES THIS, THERE ARE TONS OF REPORTS OF INDIVIDUALS WITH THE SAME ISSUES WITH THEIR 2006 FORD FUSIONS.

NHTSA ODI #11416072

Mileage unknown · May 4, 2021

Air Bags

2006 FORD FUSION. CONSUMER STATED THAT THEY NO LONGER OWN VEHICLE. *LD *JS

NHTSA ODI #11414841

Official recalls

21V158000 · Air Bags:frontal:driver Side:inflator Module

Mar 10, 2021

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 18, 2019

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Consequence & remedy

Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

17V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

16V384000 · Air Bags:frontal:passenger Side:inflator Module

May 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA12009 · Floor Mat Interference With Accelerator

Opened Dec 12, 2012 · Closed Jun 12, 2014

Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal

On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.

Additional source detail variants (2)

Vehicle Speed Control:accelerator Pedal

Vehicle Speed Control