Air Bags. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports4 fire reports23 injury reports

Service Brakes complaints

27 reports

Clear category filter

Mileage unknown · Jun 9, 2025

Service BrakesSuspensionWheelsCrash

Read full complaint

Tuve un Choque mi carro no freno y Choque a un carro que iba a dar vuelta a la izquierda, frene y mi carro no lo hizo , el impacto fue el que freno , mi carro se dano todo el frente , el punto es que yo lleve mi carro a remplazar las bolsas de aire al dealer , hace como 7 messes que porque estaban defectuosas ,, a mi carro no le hicieron ningun cambio de bolsas de aire solo las desconectaron , y al dia siguiente me prende en el tablero el foco De la bolsa de aire .no debieron desconectar eso no fue lo que me dijeron a mi

NHTSA ODI #11665852

Mileage unknown · Aug 21, 2021

Service Brakes

I've been hearing air in my brakes for two days and my brakes were not working as good as before. I haven't lost any brake fluid. As I was driving down the road and while braking to stop my brake pedal hit the bottom of my foot really hard and brakes went completely out and all I could hear was air and the brakes became almost i…

Read full complaint

NHTSA ODI #11429994

Mileage unknown · Jun 18, 2021

Service Brakes

Read full complaint

Safety Recall Notice 19S54/NHTSA Recall 19V-904 Received recall notice April 2021 that the parts HCU (hydraulic control unit) for the antilock brake system is faulty. Brought to the dealer on April 21, 2021, Sayville Ford, Sayville NY and they told me to pick up the vehicle, had the same soft pedal. Drove it home and 2 weeks later hit an uneven surface and pedal went to the floor, had to pump numerous times to stop, almost hit a parked car. This had happened 2 times before I received the recall notice and both times ended up in the intersection. Brought it back to Sayville Ford they had it for 2 weeks and called me to tell me that Ford Motors Denied the claim and will not fix the problem. I bought this vehicle new in 2006 for my wife and I will not let her drive it. It is very dangerous to be driven on the road at this point. The vehicle has only 32,000 miles I spoke to Ford Motor Corp and they will not honor this Recall 19S54. Please help, I do not know where to go from here. My name is [XXX] and my wife name is [XXX], we live in Bohemia NY my phone #[XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11421411

90,000 miles · Apr 1, 2021

Service BrakesService Brakes, Hydraulic

Read full complaint

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WOULD INTERMITTENTLY DEPRESS TO THE FLOORBOARD WITHOUT WARNING. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #11405916

150,000 miles · Feb 2, 2021

Service BrakesService Brakes, Hydraulic

Read full complaint

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT AFTER DRIVING OVER A POTHOLE AT 30 MPH, THE BRAKE PEDAL DEPRESSED TO THE FLOORBOARD WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. ON ANOTHER OCCASION, THE CONTACT STATED THAT THE BRAKE PEDAL DEPRESSED TO THE FLOORBOARD WHILE DRIVING AT 25 MPH WITH THE TRACTION CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT WAS ABLE TO REGAIN NORMAL BRAKING OPERATION AFTER MULTIPLE ATTEMPTS TO RESTART THE VEHICLE. THE CONTACT THEN RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. FAMILY FORD, INC. (30 NJ-183, NETCONG, NJ 07857) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #11394350

89,000 miles · Dec 4, 2020

Air BagsService Brakes

Read full complaint

TL* THE CONTACT'S MOTHER OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE PASSENGER'S SIDE AIR BAG WARNING LIGHT REMAINED ILLUMINATED WHILE OCCUPIED OR UNOCCUPIED. THE CONTACT STATED THAT THE FAILURE HAD BEGAN SOON AFTER THE TAKATA AIR BAG WAS REPLACED IN THE VEHICLE. THE CONTACT INITIALLY HAD THE VEHICLE TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC DETERMINED THAT THE AIR BAG WAS DEFECTIVE AND NEEDED TO BE REPLACED. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO SIMI VALLEY FORD (2440 FIRST ST, SIMI VALLEY, CA 93065) WHERE IT REMAINED IN THEIR POSSESSION DUE TO NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PARTS REMAINED UNAVAILABLE. THE CONTACT ALSO STATED THAT HE HAD EXPERIENCED MULTIPLE BRAKE FAILURE DUE TO THE RECALL. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. *BF

NHTSA ODI #11377943

205 miles · Nov 18, 2020

EngineForward Collision AvoidanceService BrakesCrash

THE CAR HAS A PROBLEM WITH THE BRAKES, IT DOES NOT BRAKE VERY WELL AND IS NOT SAFE TO DRIVE ON THE STREET

NHTSA ODI #11375222

63,000 miles · Nov 5, 2020

Service BrakesVehicle Speed Control

MY CAR SLIPS OUT FO GEAR, SLOWS DOWN ON THE HIGHWAY, REVVS AT HIGH RPM'S, AND WON'T ACCELERATE AGAIN UNLESS I SLAM THE GAS PEDAL DOWN. IT ONLY DOES THIS SOMETIMES. ALSO, I HAVE BEEN EXPERIENCING INTERMITTENT BRAKE FAILURE. I APPLY MY FOOT ONTO THE BREAK, AND IT GOES STRAIGHT TO THE FLOOR. DELAYS STOP TIME SUBSTANTIALLY.

NHTSA ODI #11373100

186,000 miles · Oct 9, 2020

Service BrakesCrash

I HIT ANOTHER VEHICLE IN THE REAR WHEN THE BRAKES ON MY 2006 FORD FUSION FAILED. I WAS TRAVELING ABOUT 30 MILES AN HOUR WHEN TRAFFIC STOPPED AND I APPLIED THE BRAKES BUT CAR DIDNT STOP HITTING ANOTHER VEHICLE. I HAD CALLED THE LOCAL FORD TO HAVE THE BRAKE RECALL FIXED BUT THEY DID NOT HAVE THE PARTS AT THE TIME * (RECALL RELATE…

Read full complaint

NHTSA ODI #11363543

152,000 miles · Oct 8, 2020

Service Brakes

Read full complaint

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD BUT FAILED TO STOP THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT CONTINUED TO DEPRESS THE BRAKE PEDAL UNTIL THE VEHICLE STOPPED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE REAR BRAKE PADS, CALIPERS AND DRUMS WERE REPLACED. THE CONTACT CALLED SMITH MOTOR CO INC (359 NJ-31, WASHINGTON, NJ 07882; (908) 835-8100) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 152,000.

NHTSA ODI #11363436

Official recalls

21V158000 · Air Bags:frontal:driver Side:inflator Module

Mar 10, 2021

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 18, 2019

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Consequence & remedy

Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

17V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

16V384000 · Air Bags:frontal:passenger Side:inflator Module

May 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA12009 · Floor Mat Interference With Accelerator

Opened Dec 12, 2012 · Closed Jun 12, 2014

Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal

On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.

Additional source detail variants (2)

Vehicle Speed Control:accelerator Pedal

Vehicle Speed Control