Air Bags. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports4 fire reports23 injury reports

Air Bags complaints

319 reports

Clear category filter

89,000 miles · Dec 4, 2020

Air BagsService Brakes

Read full complaint

TL* THE CONTACT'S MOTHER OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT THE PASSENGER'S SIDE AIR BAG WARNING LIGHT REMAINED ILLUMINATED WHILE OCCUPIED OR UNOCCUPIED. THE CONTACT STATED THAT THE FAILURE HAD BEGAN SOON AFTER THE TAKATA AIR BAG WAS REPLACED IN THE VEHICLE. THE CONTACT INITIALLY HAD THE VEHICLE TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC DETERMINED THAT THE AIR BAG WAS DEFECTIVE AND NEEDED TO BE REPLACED. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO SIMI VALLEY FORD (2440 FIRST ST, SIMI VALLEY, CA 93065) WHERE IT REMAINED IN THEIR POSSESSION DUE TO NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PARTS REMAINED UNAVAILABLE. THE CONTACT ALSO STATED THAT HE HAD EXPERIENCED MULTIPLE BRAKE FAILURE DUE TO THE RECALL. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. *BF

NHTSA ODI #11377943

85,000 miles · May 16, 2020

Air Bags

THE AIR BAG SYMBOL APPEARS ON DASH WHILE CAR IN MOTION . THE SYMBOL GOES OFF AFTER CAR IS TURNED OFF. AFTER RESTART APPEARS AGAIN IN MOTION. I RECEIVED A RECALL NOTICE FOR AIR BAGS. TOOK IT TO LOUIS FORD GARAGE IN BEAVER FALLS PA.ON 4/11/2020 . THEY ONLY REPLACED PASSENGER SIDE. SAID THAT WAS THE ONLY ONE RECALLED. THE DASH SYM…

Read full complaint

NHTSA ODI #11324774

Mileage unknown · Jan 22, 2020

Air BagsService BrakesWheels

Read full complaint

I PAID CASH FOR MY CAR BEFORE I REALIZE THAT THE COMPANY HAD OVER 4 RECALLS ON THE CAR. 1ST RECALL I WAS IN A RENTAL FOR OVER A MONTH BECAUSE OF THE NAKATA AIRBAG IF DEPLOYED WOULD HAVE CAUSED HARM TO MY PASSENGER BY DEPLOYING GLASS-LIKE PARTICALS. AND NOW 2ND RECALL IS THE ANTI-LOCK BREAK WHICH CLAIMS IT CAN BE OPEN CAUSING YOU TO HAVE TO BREAKER SOONER POSSIBLE CAUSING A CRASH. I AM CURRENTLY NOT ABLE TO PURCHASE A NEW CAR AND WITH THE FORD SETTLEMENT HAVEN'T HEARD ABOUT THE SAFETY OF US DRIVING UNDER THESE CONDITIONS.

NHTSA ODI #11301144

226,000 miles · Dec 10, 2019

Air BagsCrashInjury

Read full complaint

TL* THE CONTACT OWNED A 2006 FORD FUSION. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE HYDROPLANED, LEFT THE ROADWAY, AND CRASHED INTO A TREE. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED WHIPLASH AND SORENESS. MEDICAL ATTENTION WAS NOT RECEIVED. THE VEHICLE WAS DESTROYED AND TOWED TO A JUNKYARD. THE VEHICLE WAS NOT DIAGNOSED. BALLENTINE FORD (1305 SC-72, GREENWOOD, SC 29649, (864) 223-6656) WAS INFORMED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 226,000.

NHTSA ODI #11288169

Mileage unknown · May 23, 2019

Air BagsStructureCrash

Read full complaint

I HAVE ALREADY CONTACTED NHTSA, REFERENCE # 11119887, I EXPLAINED THAT THE VEHICLE WAS SOLD TO ME ON JANUARY 21, 2017 BY AL PIEMONTE FORD DEALERSHIP IN ILLINOIS. I HAD NO KNOWLEDGE THAT THE VEHICLE ALREADY HAD AN AIRBAG RECALL ON IT AND THEY SOLD IT TO ME WITHOUT DISCLOSING THIS INFORMATION. THEY LATER SENT ME MY FIRST RECALL NOTICE IN THE MAIL 16S26 / NHTSA RECALL 16V-384 WE WERE INVOLVED IN A CAR ACCIDENT AND THE AIRBAGS DID NOT DEPLOY. WHEN I WENT TO MY LOCAL FORD DEALER, WHERE I WAS TOLD TO GO, THE FORD DEALERSHIP INFORMED US THAT THE RECALL WAS ONLY FOR THE PASSENGER SIDE NOT FOR THE DRIVER SIDE AIRBAG. I SHOWED THEM PROOF OF OUR ACCIDENT INCLUDING PICTURES FROM THE INSURANCE SHOWING THE FORD DEALER THAT NEITHER OF THE AIRBAGS DEPLOYED DURING THE ACCIDENT. WE PROVIDED PROOF AND PAPERWORK TO THE FORD DEALER. THEY ONLY REPLACED ONE AIRBAG FOR FREE AND FORCED US TO PAY $536.41 OUT OF POCKET. THIS IS OUR ONLY VEHICLE AND WE HAVE A SMALL CHILD. THEY TOLD US THE FACT THAT THE DRIVER SIDE DID NOT DEPLOY DURING THE CAR ACCIDENT IS NOT THERE PROBLEM AND THERE IS NOTHING THAT THEY COULD DO; SO WE HAD NO OTHER CHOICE, WE WE'RE FORCED TO HAVE BOTH AIRBAGS REPLACED. I HAVE AN OFFICIAL COMPLAINT PUT IN WITH FORD COMPANY, COMPLAINT # [XXX] I SENT THIS COMPLAINT TO THEIR CUSTOMER RELATIONSHIP CENTER IN MICHIGAN. I ALSO SENT THIS COMPLAINT TO THE AL PIEMONTE FORD IN MELROSE PARK, IL WHERE THE VEHICLE WAS ORIGINALLY PURCHASED. I ALSO PUT IN A COMPLAINT WITH THE FEDERAL TRADE COMMISSION, OFFICE OF DEFECT INVESTIGATION COMPLAINT #100426513 I HAVE NOT HEARD BACK FROM ANYONE! NO RESPONSE BACK FROM FORD, NO RESPONSE BACK FROM THE FEDERAL TRADE COMMISSION AND NO RESPONSE BACK FROM NHTSA. DO YOU HAVE AN UPDATE OR ANY STATUS ON MY COMPLAINT? PLEASE ADVISE. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

NHTSA ODI #11209510

204,789 miles · Mar 13, 2019

Air BagsInjury

Read full complaint

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING 20 MPH, THE PASSENGER FRONTAL AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. ALSO, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT SUSTAINED ARM, LEG, AND EYE INJURIES THAT REQUIRED MEDICAL ATTENTION. THE FRONT PASSENGER ALSO SUSTAINED FACE, CHEST, LEG, AND EYE INJURIES, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND LATER TAKEN TO BAYTOWN FORD (LOCATED AT 4110 I-10, BAYTOWN, TX 77521, (855) 760-2180). THE VEHICLE WAS DIAGNOSED, BUT THE CONTACT WAS NOT INFORMED OF THE RESULTS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 204,789.

NHTSA ODI #11186548

Mileage unknown · Feb 22, 2019

Air Bags

'TAKATA RECALL" - I HAD RECEIVER A DOCUMENT BACK IN MARCH 2017 THAT THERE WAS A RECALL ON THE AIRBAG IN MY VEHICLE AND STILL HAVEN'T RECEIVED ANY INFORMING ME OF ANY UPDATE ON THE RECALL SOLUTIONS.

NHTSA ODI #11182062

Mileage unknown · Feb 22, 2019

Air Bags

CONSUMER WRITES IN REGARD TO TAKATA AIRBAG SAFETY RECALL. *LD *TR THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. *JS THE CONSUMER STATED SHE RECEIVED A LETTER THAT PARTS ARE AVAILABLE FOR A RECALL AND MADE AN APPOINTMENT FOR REPAIRS.

NHTSA ODI #11175412

Mileage unknown · Feb 19, 2019

Air Bags

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V024000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. PENSKE FORD (8970 LA MESA BLVD, LA MESA, CA 91942, (619) 464-7777) WAS CONTACTED AND CONFIRMED THAT THE PA…

Read full complaint

NHTSA ODI #11181197

Mileage unknown · Feb 7, 2019

Air Bags

TAKATA RECALL MY VEHICLE FALLS UNDER THE RECALL CATEGORY AND I HAVE BEEN CALLING FOR MONTHS TRYING TO GET IT SERVICED AND THERE HAS BEEN NO RESOLUTION. THIS IS INCREDIBLY IRRESPONSIBLE.

NHTSA ODI #11174982

Official recalls

21V158000 · Air Bags:frontal:driver Side:inflator Module

Mar 10, 2021

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 18, 2019

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Consequence & remedy

Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

17V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

16V384000 · Air Bags:frontal:passenger Side:inflator Module

May 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA12009 · Floor Mat Interference With Accelerator

Opened Dec 12, 2012 · Closed Jun 12, 2014

Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal

On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.

Additional source detail variants (2)

Vehicle Speed Control:accelerator Pedal

Vehicle Speed Control