NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
508 reports98,606 miles · Oct 25, 2016
Vehicle Speed Control
MY 2010 FORD FUSION HYBRID EXPERIENCED IDENTICAL SYMPTOMS (TWICE) TO THOSE OF CUSTOMER SATISFACTION PROGRAM 13N03 HOWEVER THE HYBRID VERSION OF THE FORD FUSION IS NOT INCLUDED IN THE PROGRAM (FORD CLAIMS IT DOES NOT HAVE THE ISSUE). I FIRST HAD THE ISSUE IN AUGUST 2015. I WAS DRIVING ON I-40 IN RALEIGH, GOING UP A SLIGHT …
Read full complaint
MY 2010 FORD FUSION HYBRID EXPERIENCED IDENTICAL SYMPTOMS (TWICE) TO THOSE OF CUSTOMER SATISFACTION PROGRAM 13N03 HOWEVER THE HYBRID VERSION OF THE FORD FUSION IS NOT INCLUDED IN THE PROGRAM (FORD CLAIMS IT DOES NOT HAVE THE ISSUE). I FIRST HAD THE ISSUE IN AUGUST 2015. I WAS DRIVING ON I-40 IN RALEIGH, GOING UP A SLIGHT HILL WHEN I NOTICED THE CAR WASN'T GOING, IT WAS JUST DECELERATING NO MATTER HOW MUCH I PRESSED THE GAS. VERY SCARY ON A HIGH SPEED INTERSTATE IN THE MIDDLE LANE. THE TWO WRENCH LIGHTS CAME ON. I WAS ABLE TO 'LIMP HOME'. WHEN WE GOT TO THE FORD DEALER, THE WRENCH LIGHTS WERE NO LONGER ON. THE DEALER CLAIMED FORD FUSION HYBRIDS DID NOT HAVE THE ETB PROBLEM. WE ASKED THEM TO DRIVE THE CAR AROUND, WHICH THEY DID, AND COULDN'T REPRODUCE THE PROBLEM. THEY SAID THERE WAS NOTHING THEY COULD DO UNLESS I CAME IN WITH THE PROBLEM HAPPENING. THE PROBLEM DIDN'T SURFACE AGAIN UNTIL ALMOST 10,000 MILES LATER. THIS TIME I WAS ON A LOWER SPEED ROAD, SO INITIALLY IT WASN'T QUITE AS SCARY; HOWEVER AFTER THE EXPERIENCE AT THE DEALER LAST TIME, I WANTED TO GET TO THE FORD DEALER WHILE THE PROBLEM WAS OCCURRING. THIS REQUIRED ME TO DRIVE IN THE POURING RAIN, ON A 55 MPH ROAD, WHERE GOING UP THE HILL MY SPEED DROPPED TO 15 MPH THE DEALER DID PULL THE CODES, AND WAS ABLE TO CONFIRM THE P2112 CODE, THROTTLE STUCK OPEN. I HAD TO PAY FOR REPAIRS, AND FORD REFUSES TO REIMBURSE ME. *TR
NHTSA ODI #10918738
59,000 miles · Oct 19, 2016
Steering
ON MULTIPLE OCCASIONS DURING PAST 3 YEARS, I EXPERIENCED A SUDDEN LOSS OF POWER STEERING, WHICH COULD BE REINSTATED BY PULLING OVER, SHUTTING OFF ENGINE AND RESTARTING CAR. A FEW WEEKS AGO, IT COULD NOT BE REINSTATED AND I HAVE HAD A PERMANENTLY LOSS OF STEERING. THE ISOLATED INCIDENTS OCCURRED WHILE DRIVING, SOMETIMES IN A PA…
Read full complaint
ON MULTIPLE OCCASIONS DURING PAST 3 YEARS, I EXPERIENCED A SUDDEN LOSS OF POWER STEERING, WHICH COULD BE REINSTATED BY PULLING OVER, SHUTTING OFF ENGINE AND RESTARTING CAR. A FEW WEEKS AGO, IT COULD NOT BE REINSTATED AND I HAVE HAD A PERMANENTLY LOSS OF STEERING. THE ISOLATED INCIDENTS OCCURRED WHILE DRIVING, SOMETIMES IN A PARKING LOT WHERE I CAME CLOSE TO HITTING CARS BECAUSE I COULD BARELY MUSTER THE PHYSICAL STRENGTH NECESSARY TO STEER IN TIGHT SPOTS, OTHER TIMES WHILE DRIVING IN CITY STREETS. THEY APPEARED TO OCCUR RANDOMLY ABOUT ONCE OVER FEW MONTHS UNTIL IT FINALLY HAPPENED PERMANENTLY. SO FAR, I HAVE NOT HAD ANY ACCIDENTS OR INJURIES, ALTHOUGH I CANNOT LET MY WIFE DRIVE THE CAR BECAUSE SHE LACKS THE PHYSICAL STRENGTH TO OVERCOME THE LOSS OF POWER STEERING. THE CAR IS NOW WITH THE DEALERSHIP WHERE I BOUGHT IT AND THEY ARE CHARGING ME APPROXIMATELY $1,900 TO REPLACE THE ENTIRE STEERING ASSEMBLY. THE SPECIFIC INFORMATION GIVEN BELOW IS FOR THE LAST, PERMANENT OCCURRENCE. *TR
NHTSA ODI #10917414
Mileage unknown · Oct 19, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTI…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10917379
160 miles · Oct 14, 2016
Vehicle Speed Control
WHILE DRIVING ON THE HIGHWAY 70 MPH SPEED LIMIT THE CAR STOP ACCELERATING AND SLOWED DOWN TO THE EQUIVALENT OF DRIVING IN "CRUISE CONTROL" AT 30 MPH. A YELLOW WRENCH WARNING LIGHT TURNED ON. TOOK CAR TO FORD DEALER AND THEY FELT PROBLEM WAS CONSISTENT WITH A THROTTLE PART PROBLEM AND THEY RECOMMENDED REPLACING THE PART WHICH I D…
Read full complaint
WHILE DRIVING ON THE HIGHWAY 70 MPH SPEED LIMIT THE CAR STOP ACCELERATING AND SLOWED DOWN TO THE EQUIVALENT OF DRIVING IN "CRUISE CONTROL" AT 30 MPH. A YELLOW WRENCH WARNING LIGHT TURNED ON. TOOK CAR TO FORD DEALER AND THEY FELT PROBLEM WAS CONSISTENT WITH A THROTTLE PART PROBLEM AND THEY RECOMMENDED REPLACING THE PART WHICH I DID AND FIXED THE PROBLEM. OF NOTE, BY THE TIME I HAD THE CAR TOWED TO FORD DEALER (DAY AFTER INCIDENT) THE WARNING LIGHT WAS OFF AND FORD DEALER SAID THAT THE CAR SYSTEM HAD NO RECORD OF EVENT.
NHTSA ODI #10916111
60,000 miles · Oct 3, 2016
Steering
POWER STEERING WENT OUT WITHOUT WARNING WHILE DRIVING.
NHTSA ODI #10913563
21,500 miles · Oct 3, 2016
Steering
WHILE MAKING A LEFT TURN I SEEMED TO LOOSE CONTROL OF THE STEERING AND HIT THE OPPOSITE CURB SO HARD THAT A LARGE CHUNK WAS TORN IN BOTH PASSENGER SIDE TIRES. I WAS DRIVING ON A SUBURBAN STREET AND HAD A LEFT TURN TRAFFIC SIGNAL. I DID NOT KNOW HOW IT HAPPENED AND CALLED AAA TO BE TOWED TO A STATION AND HAD TO PURCHASE TWO NEW …
Read full complaint
WHILE MAKING A LEFT TURN I SEEMED TO LOOSE CONTROL OF THE STEERING AND HIT THE OPPOSITE CURB SO HARD THAT A LARGE CHUNK WAS TORN IN BOTH PASSENGER SIDE TIRES. I WAS DRIVING ON A SUBURBAN STREET AND HAD A LEFT TURN TRAFFIC SIGNAL. I DID NOT KNOW HOW IT HAPPENED AND CALLED AAA TO BE TOWED TO A STATION AND HAD TO PURCHASE TWO NEW TIRES.
NHTSA ODI #10911389
50,000 miles · Oct 2, 2016
Air Bags
THE TAKATA RECALL HAS RENDERED MY FRONT PASSENGER SIDE SEAT UNUSABLE FOR FEAR OF MY PASSENGERS BEING IMPACTED BY SHRAPNEL SPRAYING OUT OF WHAT SHOULD HAVE BEEN A RELIABLE SAFETY FEATURE. NEARLY FOUR MONTHS SINCE THE ISSUE WAS DISCOVERED THERE HAS BEEN NO FURTHER COMMUNICATION FROM FORD ABOUT A FIX. I CAN'T HELP BUT FEEL THE SAFE…
Read full complaint
THE TAKATA RECALL HAS RENDERED MY FRONT PASSENGER SIDE SEAT UNUSABLE FOR FEAR OF MY PASSENGERS BEING IMPACTED BY SHRAPNEL SPRAYING OUT OF WHAT SHOULD HAVE BEEN A RELIABLE SAFETY FEATURE. NEARLY FOUR MONTHS SINCE THE ISSUE WAS DISCOVERED THERE HAS BEEN NO FURTHER COMMUNICATION FROM FORD ABOUT A FIX. I CAN'T HELP BUT FEEL THE SAFETY RATINGS FOR THESE CARS ARE A JOKE IF AIR BAGS THAT BEHAVE MORE LIKE FRAGMENTATION GRENADES ARE NOT CONSIDERED A TOP PRIORITY.
NHTSA ODI #10911039
37,500 miles · Sep 28, 2016
Power TrainVehicle Speed Control
TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING 55 MPH, THE VEHICLE DECELERATED AND THE POWER TRAIN WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO REPAIR THE THROTTLE BODY; HOWEVER, THE CONTACT WAS INFORMED THAT THE REPAIR WAS NOT PART OF A RECALL AND WAS OUTSIDE OF THE EXTENDED WARRAN…
Read full complaint
TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING 55 MPH, THE VEHICLE DECELERATED AND THE POWER TRAIN WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO REPAIR THE THROTTLE BODY; HOWEVER, THE CONTACT WAS INFORMED THAT THE REPAIR WAS NOT PART OF A RECALL AND WAS OUTSIDE OF THE EXTENDED WARRANTY DUE TO THE VEHICLE BEING A HYBRID. THE CONTACT WAS INQUIRING ABOUT REIMBURSEMENT ELIGIBILITY. THE FAILURE MILEAGE WAS 37,500. THE CONSUMER STATED SHE IMMEDIATELY LOST SPEED AND HAD TROUBLE ACCELERATING. UPDATED 10/27/16.*JB..UPDATED 12/20/16 *BF *TR
NHTSA ODI #10910137
83,000 miles · Sep 26, 2016
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS); HOWEVER, THE REMEDY WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT …
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 FORD FUSION HYBRID. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS); HOWEVER, THE REMEDY WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. THE VIN WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10909758
75,000 miles · Sep 22, 2016
Electrical SystemEngine
TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED AND THE WRENCH WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE RESTARTED NORMALLY AND WAS TAKEN TO THE DEALER THE FOLLOWING DAY, BUT WAS NOT DIAGNOSED. THE MANUFACTURER WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2010 FORD FUSION HYBRID. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED AND THE WRENCH WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE RESTARTED NORMALLY AND WAS TAKEN TO THE DEALER THE FOLLOWING DAY, BUT WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #10908768
NHTSA investigations
6DP26004 · Anti-lock Brake System (abs) Malfunction Indicator Lamp (mil) Illuminated
Opened Apr 9, 2026 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) received a petition on December 22, 2025, requesting a defect investigation into the hydraulic control unit (HCU) for the Anti-lock Braking System (ABS) on the MY 2010 Ford Fusion Hybrid. The petition alleges that an illuminated ABS MIL is associated with a failure of the ABS HCU, resulting in ABS malfunction, loss of traction and electronic stability control functions, and reduced braking performance, particularly on slippery road surfaces. A defect petition has been opened to evaluate the issue and determine whether to grant or deny the petition.The petition can be reviewed at NHTSA.gov under ODI number 11647929.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
EA17004 · Power Steering Failure
Opened Nov 20, 2017 · Closed Feb 9, 2024
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:rack And Pinion; Steering:rack And Pinion:rack
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Steering:electric Power Assist System
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16011 · Power Steering Failure
Opened Sep 28, 2016 · Closed Dec 25, 2017
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On September 28th, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-011 to investigate claims of power steering assist loss on model year 2010 Ford Fusion vehicles.ODI has received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at speed with no warning.During the PE16-011 investigation, Ford Motor Company (Ford) provided 1851 unique reports and 1720 warranty claims related to the alleged problem.As the result of investigation PE14-030, Ford previously conducted a recall (15V-340) of the 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist.An analysis of the subject vehicle complaint data indicates an increased likelihood of failure as the vehicles age.The rate of occurrence of this failure is comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030.Therefore, the Preliminary Evaluation (PE16-011) has been upgraded to an Engineering Analysis to further assess the scope, frequency and consequence of this failure. ODI reports cited above can be reviewed at https://www.nhtsa.gov/recalls#vehicle under the identification (NHTSA ID) numbers found in the attached list.
Additional source detail variants (2)
Steering:electric Power Assist System
On September 28th, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-011 to investigate claims of power steering assist loss on model year 2010 Ford Fusion vehicles.ODI has received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at speed with no warning.During the PE16-011 investigation, Ford Motor Company (Ford) provided 1851 unique reports and 1720 warranty claims related to the alleged problem.As the result of investigation PE14-030, Ford previously conducted a recall (15V-340) of the 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist.An analysis of the subject vehicle complaint data indicates an increased likelihood of failure as the vehicles age.The rate of occurrence of this failure is comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030.Therefore, the Preliminary Evaluation (PE16-011) has been upgraded to an Engineering Analysis to further assess the scope, frequency and consequence of this failure. ODI reports cited above can be reviewed at https://www.nhtsa.gov/recalls#vehicle under the identification (NHTSA ID) numbers found in the attached list.
Steering
On September 28th, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-011 to investigate claims of power steering assist loss on model year 2010 Ford Fusion vehicles.ODI has received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at speed with no warning.During the PE16-011 investigation, Ford Motor Company (Ford) provided 1851 unique reports and 1720 warranty claims related to the alleged problem.As the result of investigation PE14-030, Ford previously conducted a recall (15V-340) of the 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist.An analysis of the subject vehicle complaint data indicates an increased likelihood of failure as the vehicles age.The rate of occurrence of this failure is comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030.Therefore, the Preliminary Evaluation (PE16-011) has been upgraded to an Engineering Analysis to further assess the scope, frequency and consequence of this failure. ODI reports cited above can be reviewed at https://www.nhtsa.gov/recalls#vehicle under the identification (NHTSA ID) numbers found in the attached list.
PE14030 · Electric Power Steering Failure
Opened Oct 2, 2014 · Closed Sep 10, 2015
Status: closed (inferred from source dates) · Steering:electric Power Assist System
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with the model year (MY) 2010 Ford Fusion and Mercury Milan.The system is comprised of a mechanical steering rack-and-pinion gear with torque sensor, electric assist motor, motor position sensor and a power steering control module (PSCM). The PSCM is self-monitoring and designed to detect faults within the system and can store diagnostic trouble codes (DTCs) if a problem is detected.There are 29 potential DTCs the system can detect.Many of these allow the system to go into reduced-assist steering mode by using the default vehicle speed signal should the live speed signal be lost, if voltage to EPAS system falls below 10.7 or goes above 17 volts, the temperature at the PSCM goes above 105C (221F), or if high friction is detected.Some DTCs will cause the system to go into manual steering mode (no assist). On July 1, 2015, Ford filed a Defect Information Report (DIR) identifying a safety related defect in TRW GEN I EPAS systems installed in some of the subject vehicles (NHTSA Recall 15V-340, Ford No. 15S18).The DIR indicated that intermittent electrical connections caused by quality issues associated with conformal coat contamination and ribbon cable pin misalignment within the steering gear motor may lead to a loss of the motor position sensor signal, resulting in a sudden loss of power assist while driving.The recall covers approximately 393,623 vehicles built from September 2010 through February 2012:2011-12 Fusion built SEP 2010 - FEB 2012; 2011-12 Lincoln MKZ built SEP 2010 - FEB 2012; 2011 Milan built SEP 2010 - DEC 2010; 2011-13 Taurus built SEP 2010 - FEB 2012; 2011-13 Flex with 3.5L GTDI engine built SEP 2010 - FEB 2012; and 2011-13 MKS, MKT with 3.5L GTDI engine built SEP 2010 - FEB 2012.The repair consists of updating the PSCM software to prevent a loss of steering assist while driving. The revised software will provide audible and visual warnings to the driver. If one or more of the following DTCs are stored, C1B00-62, C200B-2F, C200B-61, C200B-62, C200C-2F, C200D-49, U0300-00, U2011-49, U2011-61, U3000-46, U3000-49, U3000-61, U3000-72, U3000-96, P07AE-09, the dealer will replace the EPAS system at no charge to the owner.ODI's analysis of failure data for this PE identified a total of 2,584 complaints to ODI and Ford and 9,967 Ford warranty claims related to the alleged defect.The recalled vehicles account for 1,634 of the complaints and 7,311 of the warranty claims.ODI's analysis identified 40 complaints alleging crashes that may be related to loss of steering assist while driving, 20 of which involved vehicles included in Ford's recall.The information available for the alleged crashes were not sufficient to assess specific causes of the incidents or to verify EPAS malfunctions in each case.Most of the crashes were low-speed impacts with curbs or roadside objects resulting in wheel or minor body damage.None of the injury claims indicated medical attention was required.In addition, statistical modeling of the failure data by NHTSA's National Center for Statistics and Analysis projected 10-year failur
EA12009 · Floor Mat Interference With Accelerator
Opened Dec 12, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Vehicle Speed Control
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Illustration