NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
48 reportsClear category filter73,000 miles · Aug 15, 2013
Power Train
VEHICLE SUDDENLY LOSES POWER AND DECELERATES TO ABOUT 35 MPH. VERY DANGEROUS IN HIGHWAY DRIVING. HAVE HAD TO PULL OVER TO EMERGENCY LANE OF ROAD TO SHUT OFF ENGINE FOR A FEW MINUTES AND RESTART. AFTER DOING SO, SOMETIMES IT CONTINUES TO HAVE LOW POWER, OTHER TIMES IT IS OK. THIS MORNING I WAS ON AN INCLINE OF A BRIDGE AND TH…
Read full complaint
VEHICLE SUDDENLY LOSES POWER AND DECELERATES TO ABOUT 35 MPH. VERY DANGEROUS IN HIGHWAY DRIVING. HAVE HAD TO PULL OVER TO EMERGENCY LANE OF ROAD TO SHUT OFF ENGINE FOR A FEW MINUTES AND RESTART. AFTER DOING SO, SOMETIMES IT CONTINUES TO HAVE LOW POWER, OTHER TIMES IT IS OK. THIS MORNING I WAS ON AN INCLINE OF A BRIDGE AND THE CAR SUDDENLY DECELERATED FROM ABOUT 55 MPG TO 20 MPH. THERE WAS NOWHERE TO PULL OVER AND HAD TO TURN ON MY FLASHERS AS CARS AND TRUCKS RAPIDLY CAME UP BEHIND ME. *TR
NHTSA ODI #10535469
61,000 miles · Aug 13, 2013
Power Train
I WAS GOING DOWN A SLIGHT HILL AT APPROXIMATELY 20MPH WITHOUT BRAKES BECAUSE THE VEHICLE WAS STAYING AT A STEADY SPEED WITHOUT THEM. SUDDENLY THE VEHICLE STARTED ACCELERATING ON ITS OWN. I BRIEFLY APPLIED THE BRAKES AND THEN LET UP ON THE BRAKES. THE VEHICLE AGAIN STARTED TO ACCELERATE. ABOUT THAT TIME I NOTICED A YELLOW WRE…
Read full complaint
I WAS GOING DOWN A SLIGHT HILL AT APPROXIMATELY 20MPH WITHOUT BRAKES BECAUSE THE VEHICLE WAS STAYING AT A STEADY SPEED WITHOUT THEM. SUDDENLY THE VEHICLE STARTED ACCELERATING ON ITS OWN. I BRIEFLY APPLIED THE BRAKES AND THEN LET UP ON THE BRAKES. THE VEHICLE AGAIN STARTED TO ACCELERATE. ABOUT THAT TIME I NOTICED A YELLOW WRENCH ICON (SIMILAR TO ENGINE LIGHT). WHILE I WAS LOOKING AT THE WARNING LIGHT THE VEHICLE CAME DANGEROUSLY CLOSE TO THE VEHICLE IN FRONT OF ME. THIS IS THE 4TH TIME THIS HAS HAPPENED WITH THIS VEHICLE OVER A PERIOD OF ABOUT A YEAR. BASICALLY THE VEHICLE ACCELERATES TO 30MPH AND STAYS THERE REGARDLESS OF WHAT YOU DO WITH THE ACCELERATOR. IN ORDER TO STOP IT FROM ACCELERATING YOU NEED TO CONSTANTLY RIDE THE BRAKES. I HAVE ATTEMPTED TO HAVE THE VEHICLE REPAIRED AFTER EACH INCIDENT. THE FORD DEALERSHIP APPARENTLY HAS NO IDEA WHAT THE PROBLEM IS AND HAS NO IDEA HOW TO PREVENT IT FROM HAPPENING AGAIN. THE LAST TIME I WAS IN ALL THEY DID WAS CHANGE THE 12V BATTERY. *TR
NHTSA ODI #10535170
54,865 miles · Aug 12, 2013
Power TrainVehicle Speed Control
POWERTRAIN WARNING LIGHT APPEARED AND CAR WOULD NOT ACCELERATE ABOVE 25MPH. ISSUE CLEARED AND THEN LIGHT CAME ON AGAIN A DAY LATER, THIS TIME CAR DROVE FINE. TOOK TO DEALER AND DIAGNOSED STICKING THROTTLE BODY ASSEMBLY. DEALER REPORTED THIS HAPPENS FREQUENTLY AND $500 COST IS NOT COVERED UNDER WARRANTY. QUICK INTERNET SEARCH S…
Read full complaint
POWERTRAIN WARNING LIGHT APPEARED AND CAR WOULD NOT ACCELERATE ABOVE 25MPH. ISSUE CLEARED AND THEN LIGHT CAME ON AGAIN A DAY LATER, THIS TIME CAR DROVE FINE. TOOK TO DEALER AND DIAGNOSED STICKING THROTTLE BODY ASSEMBLY. DEALER REPORTED THIS HAPPENS FREQUENTLY AND $500 COST IS NOT COVERED UNDER WARRANTY. QUICK INTERNET SEARCH SHOWED THIS SEEMS TO BE A PERVASIVE SAFETY ISSUE THAT IS NOT BEING ADDRESSED ADEQUATELY BY FORD. *TR
NHTSA ODI #10535003
76,600 miles · Jul 12, 2013
EnginePower TrainUnknown Or Other
WHY HAS NOTHING BEEN DONE YET? I'M A FAIRLY POOR UPSTANDING MEMBER OF SOCIETY, AND I WAS TRYING TO BE GREEN. NOW I'M STUCK WITH A $16,000 GO CART THAT I CANT DRIVE ON A HIGHWAY BECAUSE IT CAN'T GO OVER 35MPH. I HAD 2 YELLOW WRENCHES ON MY DASH. I WAS STUCK IN A ONE LANE RODE WITH NO PLACE TO PULL OVER AND ABOUT 100 PEOPLE HONKI…
Read full complaint
WHY HAS NOTHING BEEN DONE YET? I'M A FAIRLY POOR UPSTANDING MEMBER OF SOCIETY, AND I WAS TRYING TO BE GREEN. NOW I'M STUCK WITH A $16,000 GO CART THAT I CANT DRIVE ON A HIGHWAY BECAUSE IT CAN'T GO OVER 35MPH. I HAD 2 YELLOW WRENCHES ON MY DASH. I WAS STUCK IN A ONE LANE RODE WITH NO PLACE TO PULL OVER AND ABOUT 100 PEOPLE HONKING AT ME. I HAVE BEEN A FAITHFUL FORD OWNER FOR OVER 13 YEARS; I'VE BEEN TELLING MY FRIENDS AND CO-WORKERS HOW GREAT THEY ARE. NOW I HAVE TO BEG FOR THEM TO FIX MY CAR, OR I CAN GO GET RIPPED OFF BY MY LOCAL DEALER. PLEASE HELP. I THOUGHT YOU PEOPLE WERE BETTER THAN THIS. *TR
NHTSA ODI #10524616
26,147 miles · May 4, 2013
EnginePower TrainVehicle Speed Control
I WAS ON THE LEFT LANE GOING 55MPH ON A FREEWAY UP A SLIGHT INCLINE WHEN I NOTICED I WAS LOSING SPEED. PRESSED THE GAS PEDAL A LITTLE HARDER THINKING I NEEDED TO COMPENSATE FOR THE INCLINE, BUT THE CAR WOULD NOT ACCELERATE. I NOTICED A YELLOW WRENCH APPEAR ON THE LEFT SIDE OF THE DASH DISPLAY. I HAD THE GAS PEDAL TO THE GROUND A…
Read full complaint
I WAS ON THE LEFT LANE GOING 55MPH ON A FREEWAY UP A SLIGHT INCLINE WHEN I NOTICED I WAS LOSING SPEED. PRESSED THE GAS PEDAL A LITTLE HARDER THINKING I NEEDED TO COMPENSATE FOR THE INCLINE, BUT THE CAR WOULD NOT ACCELERATE. I NOTICED A YELLOW WRENCH APPEAR ON THE LEFT SIDE OF THE DASH DISPLAY. I HAD THE GAS PEDAL TO THE GROUND AND CAR STILL WOULD NOT ACCELERATE BUT DECELERATED ALL THE WAY DOWN TO 30MPH WHERE IT STOPPED DECELERATING AND MAINTAINED THIS SPEED. I HAD TO MANEUVER AT 30MPH OFF THE FREEWAY TO GET INTO THE RIGHT SHOULDER LANE. TURNED THE CAR OFF, THEN BACK ON. YELLOW WRENCH NO LONGER VISIBLE AND CAR OPERATED NORMALLY. THIS POSES A VERY DANGEROUS SITUATION. LUCKILY IT WAS NOT DURING RUSH HOUR TRAFFIC AND THE CARS BEHIND ME YIELDED TO MY HAZARD LIGHTS AND LET ME GET TO THE RIGHT SHOULDER LANE. *TR
NHTSA ODI #10510651
15,300 miles · Apr 21, 2013
Power Train
TONIGHT WE STARTED CAR, PULLED OUT, BUT THE CAR WOULD NOT ACCELERATE PROPERLY. WE NOTICED THAT THE WRENCH LIGHT HAD GONE ON. THE HIGHEST SPEED IT COULD GET TO WAS 30 MPH, BUT EVERY TIME WE STOPPED, IT TOOK A LONG TIME TO ACCELERATE. THIS IS AN EXTREMELY DANGEROUS PROBLEM; WE ALMOST GOT REAR-ENDED SEVERAL TIMES LATE AT NIGHT AND…
Read full complaint
TONIGHT WE STARTED CAR, PULLED OUT, BUT THE CAR WOULD NOT ACCELERATE PROPERLY. WE NOTICED THAT THE WRENCH LIGHT HAD GONE ON. THE HIGHEST SPEED IT COULD GET TO WAS 30 MPH, BUT EVERY TIME WE STOPPED, IT TOOK A LONG TIME TO ACCELERATE. THIS IS AN EXTREMELY DANGEROUS PROBLEM; WE ALMOST GOT REAR-ENDED SEVERAL TIMES LATE AT NIGHT AND HAD DIFFICULTY MOVING THROUGH INTERSECTIONS. LOOKING ONLINE WHEN WE GOT HOME, WE'VE DISCOVERED THAT THERE ARE MANY WEBSITES DETAILING THIS PROBLEM. IT APPEARS TO BE THE THROTTLE BODY? SAFETY RECALL IS NEEDED!!! *TR
NHTSA ODI #10508960
57,600 miles · Apr 6, 2013
Electrical SystemPower Train
JUST GOT THE CAR HOME FROM THE DEALER AND 1 WEEK AFTER THEY UPDATED THE COMPUTER FOR THE SAME PROBLEM AGAIN TODAY. DRIVING THE CAR , WRENCH LIGHT COMES ON THEN CAR IDLES AND GOES LIMP DOES NOT GO OVER 40 MPH AND THE HYBRID SIGNAL WOULD NOT GO OVER 20 ON THE SCREEN WITH THE LEAVES. TOOK THE CAR HOME AND THEN ENGINE LIGHT COMES O…
Read full complaint
JUST GOT THE CAR HOME FROM THE DEALER AND 1 WEEK AFTER THEY UPDATED THE COMPUTER FOR THE SAME PROBLEM AGAIN TODAY. DRIVING THE CAR , WRENCH LIGHT COMES ON THEN CAR IDLES AND GOES LIMP DOES NOT GO OVER 40 MPH AND THE HYBRID SIGNAL WOULD NOT GO OVER 20 ON THE SCREEN WITH THE LEAVES. TOOK THE CAR HOME AND THEN ENGINE LIGHT COMES ON TOWED BACK TO SAME DEALER WHO STATED IT NEEDS A 425 DOLLAR THROTTLE VALVE THAT I SAID IT NEEDED LAST WEEK AND WAS TOLD MY CAR DOES NOT HAVE ONE. THESE CARS SHOULD LAST BETTER THAN 60 000 MILES WITHOUT A MAJOR POWERTRAIN PROBLEM THAT IS NOT COVERED UNDER THE WARRENTY. I LOVE THE FEATURES AND STYLE OF THIS CAR BUT I SEE LARGE REPAIRS IN THE FUTURE SO TRADE IN HERE I COME . *TR
NHTSA ODI #10507362
56,800 miles · Mar 18, 2013
Power Train
DRIVING MY DAUGHTER TO SCHOOL PUT THE CAR IN PARK TO DROP HER OFF CAR WAS IDLING, WHEN I PUT THE CAR BACK IN GEAR A WRENCH APPEARED ON THE DASHBOARD SCREEN. I DROVE THE CAR HOME AND COULD NOT GET THE CAR TO ACCELERATE . IT WOULD ONLY GO 30 MPH . THIS WAS DANGEROUS BECAUSE I HAD TO CROSS A MAJOR ROAD TO GET BACK HOME AND HA…
Read full complaint
DRIVING MY DAUGHTER TO SCHOOL PUT THE CAR IN PARK TO DROP HER OFF CAR WAS IDLING, WHEN I PUT THE CAR BACK IN GEAR A WRENCH APPEARED ON THE DASHBOARD SCREEN. I DROVE THE CAR HOME AND COULD NOT GET THE CAR TO ACCELERATE . IT WOULD ONLY GO 30 MPH . THIS WAS DANGEROUS BECAUSE I HAD TO CROSS A MAJOR ROAD TO GET BACK HOME AND HAD TO WAIT SINCE THE CAR WOULD NOT ACCELERATE . CALLED FORD DEALER AND WAS TOLD TO TOW IT NOT DRIVE TO DEALERSHIP. *TR
NHTSA ODI #10503385
NHTSA investigations
6DP26004 · Anti-lock Brake System (abs) Malfunction Indicator Lamp (mil) Illuminated
Opened Apr 9, 2026 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) received a petition on December 22, 2025, requesting a defect investigation into the hydraulic control unit (HCU) for the Anti-lock Braking System (ABS) on the MY 2010 Ford Fusion Hybrid. The petition alleges that an illuminated ABS MIL is associated with a failure of the ABS HCU, resulting in ABS malfunction, loss of traction and electronic stability control functions, and reduced braking performance, particularly on slippery road surfaces. A defect petition has been opened to evaluate the issue and determine whether to grant or deny the petition.The petition can be reviewed at NHTSA.gov under ODI number 11647929.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
EA17004 · Power Steering Failure
Opened Nov 20, 2017 · Closed Feb 9, 2024
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:rack And Pinion; Steering:rack And Pinion:rack
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Steering:electric Power Assist System
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16011 · Power Steering Failure
Opened Sep 28, 2016 · Closed Dec 25, 2017
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On September 28th, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-011 to investigate claims of power steering assist loss on model year 2010 Ford Fusion vehicles.ODI has received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at speed with no warning.During the PE16-011 investigation, Ford Motor Company (Ford) provided 1851 unique reports and 1720 warranty claims related to the alleged problem.As the result of investigation PE14-030, Ford previously conducted a recall (15V-340) of the 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist.An analysis of the subject vehicle complaint data indicates an increased likelihood of failure as the vehicles age.The rate of occurrence of this failure is comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030.Therefore, the Preliminary Evaluation (PE16-011) has been upgraded to an Engineering Analysis to further assess the scope, frequency and consequence of this failure. ODI reports cited above can be reviewed at https://www.nhtsa.gov/recalls#vehicle under the identification (NHTSA ID) numbers found in the attached list.
Additional source detail variants (2)
Steering:electric Power Assist System
On September 28th, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-011 to investigate claims of power steering assist loss on model year 2010 Ford Fusion vehicles.ODI has received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at speed with no warning.During the PE16-011 investigation, Ford Motor Company (Ford) provided 1851 unique reports and 1720 warranty claims related to the alleged problem.As the result of investigation PE14-030, Ford previously conducted a recall (15V-340) of the 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist.An analysis of the subject vehicle complaint data indicates an increased likelihood of failure as the vehicles age.The rate of occurrence of this failure is comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030.Therefore, the Preliminary Evaluation (PE16-011) has been upgraded to an Engineering Analysis to further assess the scope, frequency and consequence of this failure. ODI reports cited above can be reviewed at https://www.nhtsa.gov/recalls#vehicle under the identification (NHTSA ID) numbers found in the attached list.
Steering
On September 28th, 2016, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE16-011 to investigate claims of power steering assist loss on model year 2010 Ford Fusion vehicles.ODI has received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at speed with no warning.During the PE16-011 investigation, Ford Motor Company (Ford) provided 1851 unique reports and 1720 warranty claims related to the alleged problem.As the result of investigation PE14-030, Ford previously conducted a recall (15V-340) of the 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist.An analysis of the subject vehicle complaint data indicates an increased likelihood of failure as the vehicles age.The rate of occurrence of this failure is comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030.Therefore, the Preliminary Evaluation (PE16-011) has been upgraded to an Engineering Analysis to further assess the scope, frequency and consequence of this failure. ODI reports cited above can be reviewed at https://www.nhtsa.gov/recalls#vehicle under the identification (NHTSA ID) numbers found in the attached list.
PE14030 · Electric Power Steering Failure
Opened Oct 2, 2014 · Closed Sep 10, 2015
Status: closed (inferred from source dates) · Steering:electric Power Assist System
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with the model year (MY) 2010 Ford Fusion and Mercury Milan.The system is comprised of a mechanical steering rack-and-pinion gear with torque sensor, electric assist motor, motor position sensor and a power steering control module (PSCM). The PSCM is self-monitoring and designed to detect faults within the system and can store diagnostic trouble codes (DTCs) if a problem is detected.There are 29 potential DTCs the system can detect.Many of these allow the system to go into reduced-assist steering mode by using the default vehicle speed signal should the live speed signal be lost, if voltage to EPAS system falls below 10.7 or goes above 17 volts, the temperature at the PSCM goes above 105C (221F), or if high friction is detected.Some DTCs will cause the system to go into manual steering mode (no assist). On July 1, 2015, Ford filed a Defect Information Report (DIR) identifying a safety related defect in TRW GEN I EPAS systems installed in some of the subject vehicles (NHTSA Recall 15V-340, Ford No. 15S18).The DIR indicated that intermittent electrical connections caused by quality issues associated with conformal coat contamination and ribbon cable pin misalignment within the steering gear motor may lead to a loss of the motor position sensor signal, resulting in a sudden loss of power assist while driving.The recall covers approximately 393,623 vehicles built from September 2010 through February 2012:2011-12 Fusion built SEP 2010 - FEB 2012; 2011-12 Lincoln MKZ built SEP 2010 - FEB 2012; 2011 Milan built SEP 2010 - DEC 2010; 2011-13 Taurus built SEP 2010 - FEB 2012; 2011-13 Flex with 3.5L GTDI engine built SEP 2010 - FEB 2012; and 2011-13 MKS, MKT with 3.5L GTDI engine built SEP 2010 - FEB 2012.The repair consists of updating the PSCM software to prevent a loss of steering assist while driving. The revised software will provide audible and visual warnings to the driver. If one or more of the following DTCs are stored, C1B00-62, C200B-2F, C200B-61, C200B-62, C200C-2F, C200D-49, U0300-00, U2011-49, U2011-61, U3000-46, U3000-49, U3000-61, U3000-72, U3000-96, P07AE-09, the dealer will replace the EPAS system at no charge to the owner.ODI's analysis of failure data for this PE identified a total of 2,584 complaints to ODI and Ford and 9,967 Ford warranty claims related to the alleged defect.The recalled vehicles account for 1,634 of the complaints and 7,311 of the warranty claims.ODI's analysis identified 40 complaints alleging crashes that may be related to loss of steering assist while driving, 20 of which involved vehicles included in Ford's recall.The information available for the alleged crashes were not sufficient to assess specific causes of the incidents or to verify EPAS malfunctions in each case.Most of the crashes were low-speed impacts with curbs or roadside objects resulting in wheel or minor body damage.None of the injury claims indicated medical attention was required.In addition, statistical modeling of the failure data by NHTSA's National Center for Statistics and Analysis projected 10-year failur
EA12009 · Floor Mat Interference With Accelerator
Opened Dec 12, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Vehicle Speed Control
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Illustration