ON SEVERAL OCCASIONS, MY 05 FREESTYLE LUNGES FORWARD, TRANSMISSION IS ENGAGED IN THE DRIVE POSITION AND WHEN IN REVERSE, IT ALSO LUNGES. OFTEN WHEN STOPPED AT A LIGHT THE CAR WILL NOT ACCELERATE. IT WILL STUMBLE ALL OVER ITSELF AND DIES. I'VE ALMOST BEEN HIT ON A COUPLE OCCASIONS BECAUSE I COULDN'T GET ACROSS AN INTERSECTION …
Read full complaint
ON SEVERAL OCCASIONS, MY 05 FREESTYLE LUNGES FORWARD, TRANSMISSION IS ENGAGED IN THE DRIVE POSITION AND WHEN IN REVERSE, IT ALSO LUNGES. OFTEN WHEN STOPPED AT A LIGHT THE CAR WILL NOT ACCELERATE. IT WILL STUMBLE ALL OVER ITSELF AND DIES. I'VE ALMOST BEEN HIT ON A COUPLE OCCASIONS BECAUSE I COULDN'T GET ACROSS AN INTERSECTION OR OUT OF THE WAY. ON SEVERAL OCCASIONS WHILE DRIVING, IT LOSES POWER AND WILL NOT ACCELERATE. HAD A A MECHANIC LOOK AT IT. HE SAID THE THROTTLE BODY WAS GUMMED UP AND HE CLEANED IT. IT RAN GOOD FOR A COUPLE DAYS AND IT'S BACK TO DOING THE SAME THING. THE CAR ONLY HAS 72310 MILES ON IT. THIS PROBLEM HAS BEEN GOING ON FOR A COUPLE YEARS AND HAS GOTTEN SIGNIFICANTLY WORSE.
NHTSA ODI #11113656
95,000 miles · Mar 7, 2018
Power TrainUnknown Or Other
2005 FORD FREESTYLE HAS A CONSTANT SCRAPING SOUND FROM THE TRANSMISSION WHEN I AM DRIVING IT. WE PAID $ 200.00 FOR FORD MECHANIC TO CHANGE OUT THE TRANSMISSION FLUID WITH NEW FLUID KIT & HE DID FIND METAL & BRASS SHAVINGS FROM TRANNY IN OIL PAN. MECHANIC SAYS THE TRANSMISSION NEEDS TO BE REPLACED WITH NEW ONE BUT I CAN'T AFFORD …
Read full complaint
2005 FORD FREESTYLE HAS A CONSTANT SCRAPING SOUND FROM THE TRANSMISSION WHEN I AM DRIVING IT. WE PAID $ 200.00 FOR FORD MECHANIC TO CHANGE OUT THE TRANSMISSION FLUID WITH NEW FLUID KIT & HE DID FIND METAL & BRASS SHAVINGS FROM TRANNY IN OIL PAN. MECHANIC SAYS THE TRANSMISSION NEEDS TO BE REPLACED WITH NEW ONE BUT I CAN'T AFFORD TO PAY $4,000.00 IT WILL TAKE TO DO IT. I FOUND OUT THE CVT TRANSMISSIONS ALL SOONER OR LATER ,BUT MOSTLY SOONER ; FAIL BECAUSE THEY ARE NOTORIOUS FOR IT . BAD DESIGN FOR THAT TRANSMISSION & THEY STILL ROBBING THE OWNERS OF THESE VEHICLES AS I SPEAK ! MAN UP & PAY FOR YOUR MISTAKES LIKE THOSE IN SOCIETY MUST WHEN THEY HAVE ROBBED OTHERS AND GOT CAUGHT. I'D LIKE TO KNOW WHY IT'S LET GO THUS FAR & WHO THEN IS ACCOUNTABLE ??
NHTSA ODI #11076742
Mileage unknown · Jan 5, 2017
Unknown Or Other
TRANSMISSION ISSUES. STARTED MAKING AWFUL NOISES AND LOW ACCELERATION. WENT TO MECHANIC AND TOLD THE TRANSMISSION IS SHOT
NHTSA ODI #10940007
114,000 miles · Dec 15, 2016
EngineFuel/propulsion SystemUnknown Or Other
DOOR LATCHES FREEZING EVERY WINTER AND DOORS WILL NOT LATCH AND STAY SHUT. ALSO WENT TO FORD WEBSITE AND REALIZED THERE WAS A RECALL FOR FSA TITLE: ENGINE IDLE RPM SURGE EXTENDED WARRANTY FIELD SERVICE ACTION NUMBER: 12N03. I WAS UNAWARE OF THIS RECALL AND MY CAR DOES THIS QUITE FREQUENTLY AND I AM AFRAID THE TENS YEARS IS UP FO…
Read full complaint
DOOR LATCHES FREEZING EVERY WINTER AND DOORS WILL NOT LATCH AND STAY SHUT. ALSO WENT TO FORD WEBSITE AND REALIZED THERE WAS A RECALL FOR FSA TITLE: ENGINE IDLE RPM SURGE EXTENDED WARRANTY FIELD SERVICE ACTION NUMBER: 12N03. I WAS UNAWARE OF THIS RECALL AND MY CAR DOES THIS QUITE FREQUENTLY AND I AM AFRAID THE TENS YEARS IS UP FOR THIS TO BE TAKEN CARE OF. WHEN PULL UP TO A STOP SIGN OR RED LIGHT, SOMETIMES THE ENGINE WILL REV REALLY HIGH AND LURCH FORWARD CAUSING ME TO STOMP ON BRAKE PEDAL REALLY HARD.
NHTSA ODI #10935411
134,000 miles · Aug 12, 2016
Unknown Or OtherVehicle Speed Control
CAR IS LUNGING FORWARD AND BACKWARDS
NHTSA ODI #10895431
70,000 miles · Aug 4, 2016
Unknown Or OtherVehicle Speed Control
IF WE CHANGE GEARS WITH THE A/C ON THE CAR LUNGES WHEN WE'RE TRYING TO COME TO A STOP. IT LUNGES AS WE'RE PARKING OR PULLING UP TO A STOP SIGN OR STOP LIGHT. AFTER STOPPING IT WILL CONTINUE TO LUNGE WITHOUT WARNING IF IT IS IN DRIVE...IT WILL EVEN LUNGE AS WE TRY TO SHIFT TO PARK. WE ARE AFRAID WE WILL HIT SOMEONE WALKING IN A C…
Read full complaint
IF WE CHANGE GEARS WITH THE A/C ON THE CAR LUNGES WHEN WE'RE TRYING TO COME TO A STOP. IT LUNGES AS WE'RE PARKING OR PULLING UP TO A STOP SIGN OR STOP LIGHT. AFTER STOPPING IT WILL CONTINUE TO LUNGE WITHOUT WARNING IF IT IS IN DRIVE...IT WILL EVEN LUNGE AS WE TRY TO SHIFT TO PARK. WE ARE AFRAID WE WILL HIT SOMEONE WALKING IN A CROSS WALK OR HIT THE CAR IN FRONT OF US WHILE PARKING. DURING LUNGING YOU CAN HEAR THE ENGINE REV LOUDER. LUNGES WHILE STOPPING AND WHILE BEING STOPPED. THIS HAS BEEN HAPPENING FOR SEVERAL YEARS. I'VE READ OTHER POSTS WITH PEOPLE SAYING THE SAME THING HAPPENING. HERE IS ONE EXAMPLE. HTTP://WWW.MYFORDFREESTYLE.COM/FORUMS/VIEWTOPIC.PHP?T=5488
NHTSA ODI #10893287
180,000 miles · May 7, 2016
Power TrainUnknown Or OtherVehicle Speed Control
WHEN DRIVING DOWN A 4 LANE HIGH WAY THE CAR LOST GAS PEDAL CHECK TRANSMISSION LIGHT CAME ON. THIS COULD HAVE BEEN FATAL. WITH OTHER VEHICLE SPEEDS UP TO 65 MPH BEHIND MY CAR... HAVE HAD SEVERAL GARAGES LOOK AT IT AND STILL CANT FIGURE OUT THE PROBLEM. NOW A TOW BILL LABOR AND OTHER COMPOUNDING EXSPENCES.
NHTSA ODI #10863709
Mileage unknown · Mar 3, 2016
Unknown Or Other
I HAVE 2 ISSUES: #1. BACK SEAT PASSENGER DOOR CHILD SAFETY LOCKS ARE ALWAYS ON. EVERY TIME I HAVE A PASSENGER IN THE BACK SEATS THEY ARE TRAPPED, AND CANNOT GET OUT UNLESS SOMEONE OPENS THE DOORS FROM THE OUTSIDE OR THEY PULL UP ON THE LOCK FROM HE INSIDE. IVE HAD THIS PROBLEM SINCE I PURCHASED THE CAR, BUT NEVER THOUGHT I COU…
Read full complaint
I HAVE 2 ISSUES: #1. BACK SEAT PASSENGER DOOR CHILD SAFETY LOCKS ARE ALWAYS ON. EVERY TIME I HAVE A PASSENGER IN THE BACK SEATS THEY ARE TRAPPED, AND CANNOT GET OUT UNLESS SOMEONE OPENS THE DOORS FROM THE OUTSIDE OR THEY PULL UP ON THE LOCK FROM HE INSIDE. IVE HAD THIS PROBLEM SINCE I PURCHASED THE CAR, BUT NEVER THOUGHT I COULD FILE A COMPLAINT UNTIL I BY COINCIDENCE CAME ACROSS YOUR WEBSITE TODAY. #2. THE E-BRAKE DOES HAS NOT WORKED PROPERLY EITHER FOR A LONG PERIOD OF TIME, OVER A YEAR, WHICH I BELIEVE IS A DEFECT. BECAUSE, EVERY TIME I WOULD ENGAGE IT OR DISENGAGE IT, THERE WAS NO TENSION, IT FELT "BLANK" FOR LACK OF BETTER DESCRIPTION, AND JUST RECENTLY, I MESSAGE ON THE DASHBOARD HAS COME UP, AND A BELL KEEPS TINGING, TELLING ME THE EMERGENCY BRAKE IS ENGAGED WHILE DRIVING (WHEN IT IS NOT!) AND IT DOES NOT MATTER WHAT I TRY TO DO, I CANNOT MAKE THE SOUND OR THE MESSAGE GO AWAY, NOR DOES THE E-BRAKE WORK,! IT DOES NOT ENGAGE OR DISENGAGE. THIS DANGEROUS FOR ME, AND MY VEHICLE.
NHTSA ODI #10839776
136,000 miles · Jan 13, 2016
Unknown Or Other
I BOUGHT A 2005 FORD FREESTYLE LAST YEAR 2015,FOR MY DAUGHTER FOR HER FIRST STARTER VEHICLE. JUST LAST NIGHT THE DOOR LATCHES STARTED FREEZING UP AND THE DOOR WONT CLOSE AND OPENS WHILE DRIVING. APPARENTLY THERE IS A RECALL FOR THIS SO I CALLED FORD. THEY TOLD ME THE RECALL WAS TAKEN CARE OF IN 2006. THE PREVIOUS OWNER MAY HAVE …
Read full complaint
I BOUGHT A 2005 FORD FREESTYLE LAST YEAR 2015,FOR MY DAUGHTER FOR HER FIRST STARTER VEHICLE. JUST LAST NIGHT THE DOOR LATCHES STARTED FREEZING UP AND THE DOOR WONT CLOSE AND OPENS WHILE DRIVING. APPARENTLY THERE IS A RECALL FOR THIS SO I CALLED FORD. THEY TOLD ME THE RECALL WAS TAKEN CARE OF IN 2006. THE PREVIOUS OWNER MAY HAVE HAD A GARAGE TO KEEP IT PROTECTED FROM COLD BUT I DON'T HAVE THAT OPTION. SINCE THE REPAIR WAS ALREADY DONE THEY WONT TAKE CARE OF IT AND IT IS MY PROBLEM TO REPAIR. I WOULD THING THIS IS A DANGEROUS SAFETY ISSUE AND THEY WOULD WANT TO TAKE CARE OF IT SINCE THE FIRST FIX DIDN'T WORK. MY DAUGHTER IS 17 AND NOW I HAVE TO WORRY ABOUT THE DOOR OPENING WHILE SHE IS DRIVING EVERY TIME ITS COLD AND CAUSING AN ACCIDENT OR BEING INJURED HERSELF.
NHTSA ODI #10820054
119,800 miles · Oct 24, 2015
Unknown Or Other
THE TRANSMISSION MAKE A NOISE LIKES BLENDING SOMETHING, IT DOESN'T CHANGE GEARS AND AFTER A WILE DOESN'T ACELERATE.
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Ford Freestyle Problems, Complaints & Recalls | Skip That Year
Illustration