IllustrationDoors will not close in cold weather. This is a safety issue that was not resolved with prior recall.
2005 Ford Freestyle
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Ford Freestyle do not stand out strongly from the model-year median of 893.
About this comparison →How this year compares
Owner complaints by model year
Compare all Freestyle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1140–25K
15325–50K
33950–75K
31275–100K
307100–150K
74150K+
1,299 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 587 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 447 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports3 fire reports11 injury reports
Unknown Or Other complaints
72 reportsDriving my 2005 Ford Freestyle today when I suddenly heard a loud explosion or crash sound overhead. At first I thought something had fallen from the sky and crashed into the top of our vehicle. I immediately slowed down and pulled the car off the side of the road. My husband was a passenger in the vehicle. He carefully got ou…
Read full complaint
Driving my 2005 Ford Freestyle today when I suddenly heard a loud explosion or crash sound overhead. At first I thought something had fallen from the sky and crashed into the top of our vehicle. I immediately slowed down and pulled the car off the side of the road. My husband was a passenger in the vehicle. He carefully got out of the vehicle and looked on top of and around the vehicle. That is when we discovered that the glass in the sunroof had literally exploded and blown out of the vehicle. The track was still in place and operating normally. The glass was completely blown out of the vehicle. Because the Ford Freestyle was only in production for 3 years (I believe), there probably are not many still in use. Thus, there are probably not many Ford Freestyle owners having or reporting this problem. Besides being scared, the potential for being hit by the exploding glass and suffering substantial injuries to our heads, eyes, face, shoulders, bodies, could have been tremendous, if not deadly. I reported the incident to Ford Motor Company. The vehicle has not been inspected yet by manufacturer, police, insurance, or others. There were no warning lamps, messages or other symptoms of the problem prior to the sunroof glass failure.
Says transmission data error check engine and trac control all display and only allow me to drive 20-35 MPH some time I can turn the car off and back on and the codes will shut off but they come back on in the middle of the highway what usually takes me 30 minutes takes me an hour and a half to get to some times 2 hours I can't …
Read full complaint
Says transmission data error check engine and trac control all display and only allow me to drive 20-35 MPH some time I can turn the car off and back on and the codes will shut off but they come back on in the middle of the highway what usually takes me 30 minutes takes me an hour and a half to get to some times 2 hours I can't run my AC cuz that over does my alternator and heats my car I've only had it a year and it's been giving me problems 5 months after getting it I have kids and it gets rough going slow in the heat and hoping if I press to much on the gas please help I am broke and have nothing but this car left and I've spent $2000 for people to tell me nothing is wrong with it
STATIONARY AND IN MOTION MY AWD MALFUNCTION LIGHT WILL COME ON, IT DOES THIS MULTIPLE TIMES A DAY, I JUST GOT THIS FORD THE OTHER DAY, NOBODY KNOWS WHAT THE ISSUE IS, BUT I'VE SEEN THOUSANDS OF OTHER PEOPLE HAVE THIS ISSUE. THAT ALMOST CAUSED ME AN ACCIDENT TODAY IN THE SNOW. NOT VERY HAPPY ABOUT IT, AND I DON'T WANT IT TO HAPPE…
Read full complaint
STATIONARY AND IN MOTION MY AWD MALFUNCTION LIGHT WILL COME ON, IT DOES THIS MULTIPLE TIMES A DAY, I JUST GOT THIS FORD THE OTHER DAY, NOBODY KNOWS WHAT THE ISSUE IS, BUT I'VE SEEN THOUSANDS OF OTHER PEOPLE HAVE THIS ISSUE. THAT ALMOST CAUSED ME AN ACCIDENT TODAY IN THE SNOW. NOT VERY HAPPY ABOUT IT, AND I DON'T WANT IT TO HAPPEN AGAIN. IT'S BEEN DOING THIS SINCE I GOT IT. I'M LUCKY IT'S NOT TOTALED.
THIS VEHICLE TRANSMISSION DOESNT WORK AND CAN NOT BE FIX. THIS PROBLEM CAME WITH THE VEHICLE. IT MAKE NOISE LIKE A HELICOPTER. I TOOK THE CAR TO THE DEALER AND THEY TOLD ME THEY COULDNT DO ANYTHING AND TO CALL FORD MOTOR AS THERE IS RECALL IN THIS MODEL..
THE CAR STOPS RANDOMLY AT TIMES AND SOMETIMES WILL NOT EVEN STARTUP. CHECK ENGINE LIGHT IS ON AND I RECENTLY HIT SOMEONE IN FRONT OF ME DUE TO JERKING OR LERCHING WHILE AT A STOP LIGHT. VERY DANGEROUS
MY VEHICLE STALLS EVERY WEEK STEERING AND BRAKES HARD TO CONTROL, MY WIFE DRIVES THE VEHICLE. TOOK IT TO MANY SHOPS, NO CODES STORED IN COMPUTER CANNOT FIND PROBLEM. I HAD THE THROTTLE BODY CLEANED, REPLACED FUEL PUMP, SAME FAULT. THE CAR IS UNSAFE HARD TO STOP SOMETIMES WHEN ENGINE SHUTS OFF. FORD DEALER CANNOT FIND THE PROBLEM…
Read full complaint
MY VEHICLE STALLS EVERY WEEK STEERING AND BRAKES HARD TO CONTROL, MY WIFE DRIVES THE VEHICLE. TOOK IT TO MANY SHOPS, NO CODES STORED IN COMPUTER CANNOT FIND PROBLEM. I HAD THE THROTTLE BODY CLEANED, REPLACED FUEL PUMP, SAME FAULT. THE CAR IS UNSAFE HARD TO STOP SOMETIMES WHEN ENGINE SHUTS OFF. FORD DEALER CANNOT FIND THE PROBLEM.
MY 2005 FORD FREESTYLE SPEEDOMETER FLUCTUATES ON ITS ON CAUSING THE CAR TO JUMP FORWARD AND TAKE OFF SLOW WITH VERY LITTLE POWER IT DOES IT WHEN SITTING IN PARK WITH THE CAR TURNED ON AND WHILE DRIVING
ALL ENGINE LIGHTS COME ON AT VARIOUS TIMES WITH NO WORKING GAUGES, BUT CAR DRIVES. WITHING PAST YEAR, HAD INSTRUMENT CLUSTER REPLACED 2 TIMES, ALTERNATOR REPLACED TWICE, INJECTOR COILS & SPARK PLUGS, CLEANED/REPLACED, BATTERY REPLACED, THROTTLE BODY ASSEMBLY & GASKET, . HAD DIAGNOSED AT 2 FORD DEALERS IN DIFFERENT STATES AND N…
Read full complaint
ALL ENGINE LIGHTS COME ON AT VARIOUS TIMES WITH NO WORKING GAUGES, BUT CAR DRIVES. WITHING PAST YEAR, HAD INSTRUMENT CLUSTER REPLACED 2 TIMES, ALTERNATOR REPLACED TWICE, INJECTOR COILS & SPARK PLUGS, CLEANED/REPLACED, BATTERY REPLACED, THROTTLE BODY ASSEMBLY & GASKET, . HAD DIAGNOSED AT 2 FORD DEALERS IN DIFFERENT STATES AND NEITHER CAN FIGURE OUT WHAT IS CAUSING ALL THE DASHBOARD LIGHTS TO STAY ON. BOTH DEALERS WERE ADAMENT IT WAS THE INSTRUMENT CLUSTER, WHICH CLEARLY IT IS NOT SINCE THE ERROR LIGHTS ARE STILL ON. HAVE BEEN TOLD IT COULD BE ELECTRICAL OR RCM, BUT THERE IS NO WAY TO TEST FOR EITHER. DEALER WANTS ME TO FOOT THE (HOURLY / UNION) LABOR RATE WHILE THEY TRY TO FIGURE IT OUT. CURRENTLY CAR IS CURRENTLY WITH LOCAL MECHANIC WHO IS GOING OVER THE CAR TO FIGURE IT OUT. NOTHING HAS BEEN DETERMINED YET.
WAS STOPPED IN TRAFFIC, THEN WHEN I SLOWLY TOOK MY FOOT OFF THE BRAKE TO MOVE, THE ENGINE REVVED UP, THEN SURGED FORWARD VERY QUICKLY, I STEPPED ON THE BRAKE AGAIN, BUT IT WASN'T ENOUGH TO STOP THE CAR. I NEVER TOUCHED THE GAS PEDAL. THIS RESULTED IN ME SLAMMING INTO THE CAR IN FRONT OF ME
Official recalls
206V383000 · Latches/locks/linkages:doors:latch
Oct 5, 2006
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
05V515000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Nov 9, 2005
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE07058 · Instrument Cluster Failure
Opened Nov 16, 2007 · Closed Mar 11, 2008
Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.