NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
447 reportsClear category filterMileage unknown · Jul 23, 2015
Power Train
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED AND APPROACHING A STOP SIGN, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. MULTIPLE UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE RE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED AND APPROACHING A STOP SIGN, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. MULTIPLE UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS THEN TAKEN TO A DEALER WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10736119
104,000 miles · Jun 18, 2015
Power Train
BOUGHT CAR AND WITHIN TWO WEEKS IT HAD A COMPLETE TRANSMISSION FAILURE. CAR MAKES A HORRNEDOUS NOISE AND WILL NOT DRIVE FORWARD. PRIOR TO THIS HAPPENED THE CAR WOULD SUDDENLY ACCELERATE OR SURGE. TOOK TO TRANSMISSION REPAIR SHOP WHO QUOTE ME $4,250 TO REMOVE AND REPLACE THE TRANSMISSION. AT THAT PRICE I ASKED WHAT A NEW TRANSMIS…
Read full complaint
BOUGHT CAR AND WITHIN TWO WEEKS IT HAD A COMPLETE TRANSMISSION FAILURE. CAR MAKES A HORRNEDOUS NOISE AND WILL NOT DRIVE FORWARD. PRIOR TO THIS HAPPENED THE CAR WOULD SUDDENLY ACCELERATE OR SURGE. TOOK TO TRANSMISSION REPAIR SHOP WHO QUOTE ME $4,250 TO REMOVE AND REPLACE THE TRANSMISSION. AT THAT PRICE I ASKED WHAT A NEW TRANSMISSION WOULD COST AND THEY INFORMED THERE ARE NO NEW TRANSMISSIONS AVAILABLE. THEY ALSO INFORMED ME THAT FORD HAD ABANDONED THE FREESTYLE AND ITS CVT TRANSMISSION. I CHECK WIHT JUNKYARDS AND FOUND THE CHEAPEST I COULD FIND A CVT TRANSMISSION WAS AROUND $3,000. CAR HAS BECOME A LAWN ORNAMENT FOR THE PAST TWO YEARS. FORD REFUSES TO DO ANYTHING OHTER THAN TO SAY IT IS OUT OFWARRANTLY. TERE ARE CLASS ACTION SUITS BROUGHT OVER THIS.
NHTSA ODI #10725880
148,255 miles · May 29, 2015
Power Train
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. WHILE DRIVING AT 15 MPH, THE VEHICLE WOULD NOT ACCELERATE WHEN GOING UP A HILL. THE VEHICLE ALSO JERKED VIOLENTLY AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ONLY WHEN THE VEHICLE WAS DRIVEN UP A HILL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. WHILE DRIVING AT 15 MPH, THE VEHICLE WOULD NOT ACCELERATE WHEN GOING UP A HILL. THE VEHICLE ALSO JERKED VIOLENTLY AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ONLY WHEN THE VEHICLE WAS DRIVEN UP A HILL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 148,255.
NHTSA ODI #10722303
101,000 miles · May 3, 2015
Power Train
WAS TRAVELING AT APPROXIMATELY 40 MPH WHEN CAR SUDDENLY JOLTED, AS IF IT HAD STRUCK SOMETHING. AFTER LOOKING TO INSURE NOTHING HAD BEEN STRUCK, WE PROCEEDED AND THE CAR MADE ANOTHER ODD NOISE AND CEASED TO GO FORWARD. THE TRANSMISSION HAD BLOWN AND ALL FLUIDS ESCAPED. THE CAR IS RUINED AND FROM ALL I HAVE READ, THIS IS A SERIOUS…
Read full complaint
WAS TRAVELING AT APPROXIMATELY 40 MPH WHEN CAR SUDDENLY JOLTED, AS IF IT HAD STRUCK SOMETHING. AFTER LOOKING TO INSURE NOTHING HAD BEEN STRUCK, WE PROCEEDED AND THE CAR MADE ANOTHER ODD NOISE AND CEASED TO GO FORWARD. THE TRANSMISSION HAD BLOWN AND ALL FLUIDS ESCAPED. THE CAR IS RUINED AND FROM ALL I HAVE READ, THIS IS A SERIOUS AND EXTREMELY COSTLY FLAW COSTING CONSUMERS A SMALL FORTUNE AND ENDANGERING LIVES ON HIGHWAYS. *TR
NHTSA ODI #10714280
Mileage unknown · May 2, 2015
Electrical SystemPower Train
AWD MALFUNCTION LIGHT STARTED COMING ON OCCASIONALLY LAST FALL. IT IS NOW ON ALL THE TIME. TALKED TO A MECHANIC AND WAS TOLD IT WAS EITHER A SENSOR OR A WHEEL BEARING. IN THE PROCESS OF REPLACING THE WHEEL BEARING RIGHT NOW. *TR
NHTSA ODI #10714158
100 miles · Apr 26, 2015
Power TrainSteeringVehicle Speed Control
I PURCHASED THE 2005 FORD FREESTYLE USED. ISSUES: (1) SHORTLY AFTER PURCHASING THE TRANSMISSION LIGHT CAME ON, THEN I TOOK IT TO A TRANSMISSION SHOP, WHO REPLACED THE FLUID, WHICH SEEMED TO FIX THE PROBLEM. (2) RANDOM SURGES OF POWER, WHICH ALMOST RESULTED IN A FEW ACCIDENTS AND WAS SEVERELY FRIGHTENING (CORRECTED BEFORE A RE…
Read full complaint
I PURCHASED THE 2005 FORD FREESTYLE USED. ISSUES: (1) SHORTLY AFTER PURCHASING THE TRANSMISSION LIGHT CAME ON, THEN I TOOK IT TO A TRANSMISSION SHOP, WHO REPLACED THE FLUID, WHICH SEEMED TO FIX THE PROBLEM. (2) RANDOM SURGES OF POWER, WHICH ALMOST RESULTED IN A FEW ACCIDENTS AND WAS SEVERELY FRIGHTENING (CORRECTED BEFORE A RECALL) (3) THIS PAST WINTER PROBLEMS WITH SHUTTING THE FRONT DOORS, THEN WITH OUT WARNING ( WITH TWO CHILDREN IN THE BACK SETS ) THE BACK PASSENGER DOOR FEW OPEN WHEN I TURNED THE CORNER. THE CHILDREN SCREAMED, I WAS THANKFUL THAT A CHILD WAS NOT SEVERALLY INJURED AND THEN, I HAD CALL SOMEONE TO PICK US UP. I CALLED FORD AND WAS TOLD I WAS THE ONLY COMPLAINT! LATER AT A CHILDREN'S RECREATION, I PARKED NEXT TO A WOMAN WITH CHILDREN DRIVING THE SAME MODEL. I ASKED HER IF SHE EXPERIENCED DOOR ISSUES, SHE STATED BOTH DOORS FLEW OPEN WITH THE CHILDREN IN THE BACK SEATS, AND STATED HER HUSBAND LUBED THE DOORS DOWN. (4) NOW THE TRANSMISSION WILL RANDOMLY DECIDE NOT TO MOVE, BUT IF I TURN THE FREE STYLE ON AND OFF IT MIGHT GO INTO GEAR. NO TRANSMISSION LIGHT ON INDICATED AN ISSUE. MY OPINION IS THE 2005 FORD FREESTYLE WAS CREATED TO MARKET TOWARD FAMILIES, THE DESIGN AND MARKETING WORKED, BUT AS A RESULT SEVERAL FAMILIES ARE NOW IN DANGER. *TR
NHTSA ODI #10712899
Mileage unknown · Apr 2, 2015
EnginePower Train
VEHICLE LUNGES FORWARD WHEN DRIVER'S FOOT HAS THE BRAKE PRESSED WHILE PULLING INTO A PARKING SPACE PRIOR TO SHIFTING INTO PARK. *TR
NHTSA ODI #10703424
145,000 miles · Mar 29, 2015
Power Train
STOPPED AT A RED LIGHT, WHEN WE WENT TO TAKE OFF, THERE WAS NO REVERSE OR FORWARD. ENGINE JUST REVS WHEN GAS IS PUSHED, NO MOVEMENT FROM VEHICLE. *TR
NHTSA ODI #10702432
109,000 miles · Mar 19, 2015
Power TrainVehicle Speed Control
TL*THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE AWD WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE AWD SYSTEM FAILED. NO FURTHER INFORMATION WAS AVAILABLE. THE CONTACT ALSO STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, T…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE AWD WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE AWD SYSTEM FAILED. NO FURTHER INFORMATION WAS AVAILABLE. THE CONTACT ALSO STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY LOOSE POWER AND WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10695321
30,000 miles · Feb 27, 2015
Power TrainVehicle Speed Control
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE PROCEEDING AFTER A COMPLETE STOP, THE VEHICLE ABRUPTLY ACCELERATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALIST WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE TRANSMISSION WAS REPLACED. HOWEVER, THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED THAT WHILE PROCEEDING AFTER A COMPLETE STOP, THE VEHICLE ABRUPTLY ACCELERATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A TRANSMISSION SPECIALIST WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE TRANSMISSION WAS REPLACED. HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO ABRUPTLY ACCELERATE. THE VEHICLE WAS TAKEN FOR A SECOND DIAGNOSTIC TO AN INDEPENDENT MECHANIC WHOM LOCATED A FAILURE CODE AT THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #10691072
Official recalls
2Oct 5, 2006
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 9, 2005
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE07058 · Instrument Cluster Failure
Opened Nov 16, 2007 · Closed Mar 11, 2008
Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration