IllustrationWHEN THE WEATHER HERE DROPPED TO THE TEENS, THE FRONT PASSENGER DOOR WOULD NOT LATCH. YOU COULD OPEN IT, GET IN, THEN NOT BE ABLE TO CLOSE IT. *TR
2005 Ford Freestyle
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Ford Freestyle do not stand out strongly from the model-year median of 893.
About this comparison →How this year compares
Owner complaints by model year
Compare all Freestyle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1140–25K
15325–50K
33950–75K
31275–100K
307100–150K
74150K+
1,299 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 587 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 447 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports3 fire reports11 injury reports
Latches/locks/linkages complaints
37 reportsIN COLD WEATHER FRONT DOORS DO NOT LATCH . NOT ABLE TO CLOSE AND DOORS OPEN WHILE DRIVING. THIS ITEM WAS A FORD RECALL WORKED FOR ONE SEASON . FORD CLAIMS ITEM THE LATCH WERE REPAIRED AND RECALL WAS HONORED. THIS IS A MAJOR SAFETY ISSUE. PLEASE HELP! *TR
TL*THE CONTACT OWNS A 2005 FORD FREESTYLE. WHEN THE WEATHER IS VERY COLD, THE DRIVER'S SIDE DOOR LATCH WOULD STICK AND NOT REMAIN SHUT. IT TOOK THE CONTACT 45 MINUTES OF PLAYING WITH THE DOOR TO GET IT TO REMAIN CLOSED. THE FAILURE WAS DUE TO THE LATCH LINKAGE SYSTEM. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 32,000. …
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD FREESTYLE. WHEN THE WEATHER IS VERY COLD, THE DRIVER'S SIDE DOOR LATCH WOULD STICK AND NOT REMAIN SHUT. IT TOOK THE CONTACT 45 MINUTES OF PLAYING WITH THE DOOR TO GET IT TO REMAIN CLOSED. THE FAILURE WAS DUE TO THE LATCH LINKAGE SYSTEM. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 32,000.
REAR DOORS FAIL TO LATCH IN COLD WEATHER. THE FRONT DOORS HAD THE SAME PROBLEM THAT WAS REPAIRED UNDER A FORD MOTOR COMPANY RECALL IN 2006 THAT FOCUSED ON ABOUT 20 NORTHERN STATES, WASHINGTON WAS NOT INCLUDED IN THE RECALL LETTER. REPAIRS WERE DONE ON THE FRONT DOORS IN WA. STATE ON OWNERS REQUEST. THE REAR DOORS SUFFER THE SAM…
Read full complaint
REAR DOORS FAIL TO LATCH IN COLD WEATHER. THE FRONT DOORS HAD THE SAME PROBLEM THAT WAS REPAIRED UNDER A FORD MOTOR COMPANY RECALL IN 2006 THAT FOCUSED ON ABOUT 20 NORTHERN STATES, WASHINGTON WAS NOT INCLUDED IN THE RECALL LETTER. REPAIRS WERE DONE ON THE FRONT DOORS IN WA. STATE ON OWNERS REQUEST. THE REAR DOORS SUFFER THE SAME LATCHING FAILURE THAT HAS NOT BEEN ADDRESSED. 2005 FORD FREESTYLES THAT MOVE NORTH FROM SOUTHERN STATES WILL LIKELY SUFFER FRONT AND REAR DOOR LATCHING PROBLEMS IN WINTER. *TR
RE. NHTSA CAMPAIGN ID # 06V383000 : I HAD MY LOCAL DEALER PERFORM THE SERVICE OUTLINED IN THE RECALL IN LATE NOVEMBER. SINCE THEN, ON TWO OCCASIONS THE DRIVERS DOOR HAS FAILED TO LATCH WITHOUT REPEATED HARD SLAMMING. I DON'T THINK WHAT THEY DID HAS FIXED THE PROBLEM. *JB
SIDE DOOR LOCKS AND FREEZE DURING THE WINTER. DOOR HAS OPENED WHILE DRIVING. *JB
AFTER PURCHASING A NEW 2005 FORD FREESTYLE I NOTICED THAT THE REAR DOORS WOULD NOT UNLOCK FROM INSIDE OR OUTSIDE AFTER THE ENGINE WAS TURNED OFF. I WAS TOLD BY FORD DEALER THAT IT IS A SAFETY ISSUE. IN ORDER TO OPEN THE REAR DOORS, YOU HAVE TO HIT THE ELECTRONIC DOOR LOCK SWITCH FROM THE DRIVER OR PULL THE LOCK ROD LOCATED AT EA…
Read full complaint
AFTER PURCHASING A NEW 2005 FORD FREESTYLE I NOTICED THAT THE REAR DOORS WOULD NOT UNLOCK FROM INSIDE OR OUTSIDE AFTER THE ENGINE WAS TURNED OFF. I WAS TOLD BY FORD DEALER THAT IT IS A SAFETY ISSUE. IN ORDER TO OPEN THE REAR DOORS, YOU HAVE TO HIT THE ELECTRONIC DOOR LOCK SWITCH FROM THE DRIVER OR PULL THE LOCK ROD LOCATED AT EACH DOOR. MY CONCERN IS THAT IF AN ACCIDENT OCCURRED AND SOMETHING HAPPENED TO THE ELECTRICAL SYSTEM, THE REAR PASSENGERS WOULD BE TRAPPED AND RESCUERS ON THE OUTSIDE COULD NOT OPEN THE DOORS. MY WIFE DRIVES DAILY WITH YOUNG GRANDCHILDREN INSIDE AND THEY COULD NOT OPEN THE DOORS USING THE LOCK-RODS. IF THIS REALLY WAS A SAFETY SITUATION AS FORD DESCRIBES IT, THEN THE FRONT DOORS SHOULD NOT OPEN EITHER. UPON FURTHER INVESTIGATION, I FOUND THAT MY 2003 FORD EXPEDITION OPERATES IN THE SAME MANNER. THIS POTENTIAL PROBLEM COULD BE TAKEN CARE OF WITH A SIMPLE COMPUTER CODE CHANGE. AS IT STANDS, I BELIEVE THAT SERIOUS INJURIES COULD BE EXPECTED WITH TRAPPED CHILDREN OR HANDICAPPED IN THE REAR SEATS. *JB
Official recalls
206V383000 · Latches/locks/linkages:doors:latch
Oct 5, 2006
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR LATCH PAWL MAY NOT RETURN TO THE LATCH POSITION WHEN THE DOOR IS CLOSED, AND THE DOOR COULD OPEN WHILE THE VEHICLE IS MOVING.
Remedy: DEALERS WILL INSTALL A SHIELD OVER THE FRONT LATCHES; SEAL A DRAIN HOLE IN THE REAR WINDOW TRIM MOLDING ON THE FREESTYLE REAR SIDE DOORS; AND APPLY GREASE TO ALL FRONT AND REAR SIDE-DOOR LATCH MECHANISMS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
05V515000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Nov 9, 2005
ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequence & remedy
Consequence: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE11018 · Idle Instability
Opened May 11, 2011 · Closed Feb 7, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control
On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this in
PE07058 · Instrument Cluster Failure
Opened Nov 16, 2007 · Closed Mar 11, 2008
Status: closed (inferred from source dates) · Electrical System: Instrument Cluster/panel
THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO SWEEP AND THEN RECOVER TO NORMAL FUNCTION.IN AUGUST 2006, FORD ISSUED A TECHNICAL SERVICE BULLETIN (TSB 06-17-9) TO PROVIDE GUIDELINES TO SERVICE TECHNICIANS FOR DIAGNOSIS AND REPAIR OF THIS CONDITION.ODI'S REVIEW OF FORD'S RESPONSE TO THE AGENCY'S INFORMATIONREQUEST LETTER REVEALS THAT THE MAJORITY OF THE REPORTS TO FORD (63%) INDICATE THAT THE INSTRUMENT CLUSTER WOULD EXPERIENCE INTERMITTENT LOSS OF POWER.FORD REPORTS THAT THISLASTS FOR ONLY A FEW SECONDS.ALSO FORD STATES, THE VEHICLE'S EXTERIOR LIGHTING WOULD NOT FAIL TO ILLUMINATE EVEN IN THE EVENT OF POWER INTERRUPTION TO THE CLUSTER BECAUSE THE EXTERIOR LIGHTS ARE POWERED SEPARATELY AND DO NOT RELY ON ANY SIGNAL FROM THE CLUSTER.ADDITIONALLY, ODI CONTACTED COMPLAINANTS WHO AFFIRMED THE INTERMITTENT CONDITION AND THAT NONE OF THE EXTERIOR LIGHTS ON THE SUBJECT VEHICLES WOULD BE AFFECTED BY POWER INTERRUPTIONS TO THE INSTRUMENT CLUSTER.ODI LAST RECEIVED A REPORT REGARDING THIS ISSUE IN AUGUST OF 2007.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.ODI WILL HOWEVER CONTINUE TO MONITOR THE ISSUE AND WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.