OUR CAR IN FEB 2017 WHILE DRIVING ON ROAD SUDDENLY STOPPED WITH ALL THE DASHBOARD LIGHTS ON. CAR GOT STUCK AND WE COULD NOT START ENGINE IN NEXT FEW MINS. AFTER FEW MINS EVERYTHING BACK TO NORMAL. WE STARTED DRIVING AGAIN. SAME PROBLEM AGAIN. TOOK CAR TO LOCAL SHOP. THEY SAID SERIOUS PROBLEM BIT WHERE THEY COULD NOT DIAGNOSE. NE…
Read full complaint
OUR CAR IN FEB 2017 WHILE DRIVING ON ROAD SUDDENLY STOPPED WITH ALL THE DASHBOARD LIGHTS ON. CAR GOT STUCK AND WE COULD NOT START ENGINE IN NEXT FEW MINS. AFTER FEW MINS EVERYTHING BACK TO NORMAL. WE STARTED DRIVING AGAIN. SAME PROBLEM AGAIN. TOOK CAR TO LOCAL SHOP. THEY SAID SERIOUS PROBLEM BIT WHERE THEY COULD NOT DIAGNOSE. NEXT WENT TO INVERGROVE FORD DEALER. SAME ISSUE HAPPENED IN FRONT OF THEM . THEY DID SOMETHING. GAVE CAR BACK. BUT AGAIN SAME PROBLEM. WE CALLED THEM AGAIN AND THIS TIME THEY HAD SIMILAR EXPERIENCE WHILE DRIVING CAR BACK TO SHOP. BUT AFTER GOING THERE THEY COULD NOT REPRODUCE PROBLEM. SO THEY SAID TO TAKE CAR BACK BUT ADVISED TO BE CAREFUL WHILE DRIVING AS CAR MIGHT STOP ANYTIME
NHTSA ODI #10972345
97,000 miles · Aug 1, 2016
Unknown Or Other
WHILE DRIVING THE CAR IT SHIFTS HARD INTO GEARS AND THEN IT DOESN'T WANT TO STAY IN 4TH GEAR WHILE DRIVING DOWN THE HIGHWAY. IT DOWN SHIFTS AND THEN WANTS TO RUN 3,000 OR HIGHER RPMS WHILE DRIVING 60 MPH DOWN THE HIGHWAY.
NHTSA ODI #10892313
108,000 miles · May 12, 2016
Electrical SystemEngineUnknown Or Other
2008 FORD FOCUS DOES NOT ACCELERATE PROPERLY OR STALLS RANDOMLY. ON MULTIPLE OCCASIONS I WAS IN TRAFFIC ON BOTH CITY STREETS AND HIGHWAYS AND NEARLY GOT HIT MORE THAN ONCE. I HAD THE PCM REPLACED BY A CERTIFIED FORD MECHANIC IN 11/14, IT HAD A TWO YEAR WARRANTY. IN 1/16 IT BEGAN DOING THE SAME THING. IT HAD TO BE REPLACED IN …
Read full complaint
2008 FORD FOCUS DOES NOT ACCELERATE PROPERLY OR STALLS RANDOMLY. ON MULTIPLE OCCASIONS I WAS IN TRAFFIC ON BOTH CITY STREETS AND HIGHWAYS AND NEARLY GOT HIT MORE THAN ONCE. I HAD THE PCM REPLACED BY A CERTIFIED FORD MECHANIC IN 11/14, IT HAD A TWO YEAR WARRANTY. IN 1/16 IT BEGAN DOING THE SAME THING. IT HAD TO BE REPLACED IN 4/16. AFTER REPLACING THE PCM AT A FORD DEALERSHIP THE SECOND TIME MY CAR STALLED OUT ON ME THE NEXT DAY. THE PCM CODE WAS THE SAME AT EACH LOCATION (CODE P00607). BOTH PCM'S WERE PURCHASED FROM FORD BRAND NEW. I AM NOW BEING TOLD BY THE FORD DEALERSHIP THAT THE FOLLOWING CODE (P0320) WAS OBTAINED. THEY INDICATED THE FOLLOWING WORK NEEDS TO BE DONE IN THE AMOUNT OF $575.00: THE COST OF THE REPAIRS INCLUDE: TUNE UP IS $260.00 THIS INCLUDES SPARK PLUGS ,SPARK PLUG BOOTS, AND 2 IGNITION COILS AND THE LABOR TO INSTALL THEM. THE COST TO REPLACED THE VALVE COVER GASKET THAT IS LEAKING OIL INTO THE SPARK PLUG VALLEYS IS $315.00 THIS INCLUDES THE PARTS AND LABOR. (SPARK PLUG VALLEYS #3 AND #4 HAVE OIL IN THEM.) MY CONCERN IS THAT THIS WAS NEVER A PCM ISSUE; HOWEVER, IT IS SOMETHING ELSE FEEDING MISINFORMATION TO THE PCM TO SEND INACCURATE CODES TO THE ENTIRE SYSTEM. THE PROBABILITY OF THREE PCM'S BEING FAULTY IN 1 YEAR IS NOT LIKELY. THIS VEHICLE HAS STALLED IN TRAFFIC ON MORE THAN ONE OCCASION AND IS A RISK TO OTHERS AND MYSELF ON THE ROADS. I HAVE GRAVE CONCERNS REGARDING THE RELIABILITY AND SAFETY OF THE 2008 FORD FOCUS SE. FORD NEEDS TO INVESTIGATE AND CORRECT THIS SAFETY ISSUE.
NHTSA ODI #10864695
100,000 miles · Mar 23, 2016
Unknown Or Other
THE KEY HAS TO BE PUSHED IN EXTREMELY HARD TO TURN ON THE ENGINE. IT TAKES SOMETIMES UP TO 5 MINUTES REPEATEDLY TURNING THE KEY FOR IT TO ENGAGE.
NHTSA ODI #10851182
86,000 miles · Dec 5, 2015
Unknown Or Other
2008 FORD FOCUS - 2 DR DRIVER DOOR ONLY KEYED ENTRY POINT... LOCKED CAR CAME BACK ...DOOR WOULDN'T OPEN WITH KEY .CALLED ROADSIDE ASSISTANCE AFTER THE 1ST TIME JUST LEFT UNLOCKED. TOOK CAR FOR OIL CHANGE FORGOT TO TELL THEM DON'T LOCK AND OF COURSE THEY LOCKED WHEN DONE.HAD TO CALL ROAD SIDE ASSISTANCE TO GET IT UNLOCKED.…
Read full complaint
2008 FORD FOCUS - 2 DR DRIVER DOOR ONLY KEYED ENTRY POINT... LOCKED CAR CAME BACK ...DOOR WOULDN'T OPEN WITH KEY .CALLED ROADSIDE ASSISTANCE AFTER THE 1ST TIME JUST LEFT UNLOCKED. TOOK CAR FOR OIL CHANGE FORGOT TO TELL THEM DON'T LOCK AND OF COURSE THEY LOCKED WHEN DONE.HAD TO CALL ROAD SIDE ASSISTANCE TO GET IT UNLOCKED. THIS IS REALLY UNSAFE IS THERE A RECALL ON THIS.
NHTSA ODI #10808568
115,000 miles · Aug 2, 2015
Unknown Or Other
THE ELECTRONIC DOOR LOCKS BEGAN TO SEIZE UP OVER THE COURSE OF ABOUT A YEAR. NOW ONLY ONE DOOR WILL LOCK AND UNLOCK USING THE ELECTRONIC LOCKING SYSTEM. THE DOORS CAN BE LOCKED AND UNLOCKED MANUALLY BY PULLING AND PUSHING ON THE PLASTIC MANUAL DOOR LOCKS.
NHTSA ODI #10745625
77,000 miles · Jun 12, 2015
Unknown Or Other
CAR STALLED IN TRAFFIC AND I COULD NOT GET IT STARTED. STARTED HAVING PROBLEMS WITH THE IGNITION TO GET THE CAR STARTED. HAVE TO KEEP THE KEY PUSHED IN, STRAIGHTEN THE STEERING WHEEL TO GET IT STARTED AND SOMETIMES WOULD TAKE 10 TIMES. NOT A GOOD THING IN TRAFFIC. TOOK IT TO A DEALER AND FOUND OUT THAT THERE WAS A MISSING SCREW …
Read full complaint
CAR STALLED IN TRAFFIC AND I COULD NOT GET IT STARTED. STARTED HAVING PROBLEMS WITH THE IGNITION TO GET THE CAR STARTED. HAVE TO KEEP THE KEY PUSHED IN, STRAIGHTEN THE STEERING WHEEL TO GET IT STARTED AND SOMETIMES WOULD TAKE 10 TIMES. NOT A GOOD THING IN TRAFFIC. TOOK IT TO A DEALER AND FOUND OUT THAT THERE WAS A MISSING SCREW IN AN ENCLOSED CRIMPED AREA OF THE HOUSING FOR THE IGNITION WHICH I WAS THEN TOLD THAT WAS IMPOSSIBLE EXCEPT FOR AN ASSEMBLY ERROR. WAS TOLD THERE WAS NO WAY IT COULD HAVE FALLEN OUT. WE HAVE A STICK SHIFT SO IT IS VERY EASY TO STALL IT WHILE IN TRAFFIC IF NOT PAYING ATTENTION. WE ALMOST GOT HIT BECAUSE WE COULD NOT GET IT STARTED. THIS PROBLEM STARTING IT HAS GONE ON FOR SOME TIME, BUT IT HAD CONTINUED TO GET WORSE. WAS TOLD THIS ONE SCREW HOLDS THE HOUSING IN PLACE SO THE KEY WORKS PROPERLY.
NHTSA ODI #10725045
30,000 miles · Jan 24, 2013
Unknown Or Other
MANUAL DOOR LATCHES ON 4-DOOR, KEY ENTRY. USE OF KEY TO GAIN ENTRY ON BOTH FRONT DOORS BEGAN A GRADUAL FAILURE. HAD TO WORK THE KEY, APPLY PRESSURE TO THE DOORS, ETC, UNTIL BOTH LOCKS FAILED TO OPEN WITH KEY. TWICE HAD PUT CHILDREN IN THE CAR, ACCIDENTALLY LOCKED DOORS, THEN UNABLE TO OPEN DOORS WITH KEYS. FORD SAYS IT ISN'T COV…
Read full complaint
MANUAL DOOR LATCHES ON 4-DOOR, KEY ENTRY. USE OF KEY TO GAIN ENTRY ON BOTH FRONT DOORS BEGAN A GRADUAL FAILURE. HAD TO WORK THE KEY, APPLY PRESSURE TO THE DOORS, ETC, UNTIL BOTH LOCKS FAILED TO OPEN WITH KEY. TWICE HAD PUT CHILDREN IN THE CAR, ACCIDENTALLY LOCKED DOORS, THEN UNABLE TO OPEN DOORS WITH KEYS. FORD SAYS IT ISN'T COVERED BY WARRANTY, ALTHOUGHT THE PROBLEMS FIRST STARTED APPEARING WHEN THE CAR WAS ONLY 2 YEARS OLD. FOR THE PAST 2 YEARS, HAD TO LEAVE THE VEHICLE UNLOCKED. EVENTUALLY HAD AN AUTO BODY MAN DISASSMBLE THE DOORS, LUBE THE LATHES, AND THE WORK AGAIN, ALTHOUGHT THEY ARE STARTING TO WORK INTERMITTENTLY AGAIN. NEW LATCHES ARE $120 TO $160 EACH IF YOU CAN FIND THEM. *TR
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE DRIVER AIR BAG MODULE MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Consequence & remedy
Consequence: THIS CONDITION MAY PREVENT THE DRIVER AIR BAG FROM PROPERLY DEPLOYING AND REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE YOUR DRIVER AIR BAG MODULE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2008 Ford Focus Problems, Complaints & Recalls | Skip That Year
Illustration