IllustrationTHE CAR LEAKS UNDER THE DASHBOARD ON THE PASSENGER SIDE UPPER LEFT CORNER. THE CAR HAS BEEN INTO THE DEALER FOUR TIMES IN THREE WEEKS AND IS CURRENTLY THERE NOW. THEY HAVE REPLACED THE CASING AND SEALED IT TWICE. AWAITING NEWS ON WHAT WILL BE DONE THIS TIME. DT
2002 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
13425–50K
13950–75K
8375–100K
74100–150K
26150K+
604 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
82 crash reports20 fire reports60 injury reports
What owners actually said
939 reportsCONSUMER CALLED COMPLAINING ABOUT THE RADIATOR FUN. ALSO STATED THAT THIS HAPPEND WHILE HE WAS DRIVING THE VEHICLE THE FUN ON THE RADIATOR FELL OFF AND CAUSE DAMAGE ON THE BOTTOM OF THE VEHCLE. DEALER WAS CONTACTED AND STATED TO THE CONSUMER TO CONTACT THERE INSURANCE TO FIND OUT IF IT WAS CONSUMER S FALL OR THE MANUFACTURES DIF…
Read full complaint
CONSUMER CALLED COMPLAINING ABOUT THE RADIATOR FUN. ALSO STATED THAT THIS HAPPEND WHILE HE WAS DRIVING THE VEHICLE THE FUN ON THE RADIATOR FELL OFF AND CAUSE DAMAGE ON THE BOTTOM OF THE VEHCLE. DEALER WAS CONTACTED AND STATED TO THE CONSUMER TO CONTACT THERE INSURANCE TO FIND OUT IF IT WAS CONSUMER S FALL OR THE MANUFACTURES DIFFECT. TS
CONSUMER WAS DRIVING APPROXIMATELY 30-35MPH AND RAN OVER A POTHOLE. THERE WAS NO COLLISION. THE LEFT SIDE AIR BAG DEPLOYED WITHOUT WARNING. TS
CONSUMER CALLED COMPLETING ABOUT A REALLY BAD VIBRATION ON THE STEERING WHEEL EVERYTIME HE APPLY'S THE BRAKE PEDAL HE ALSO STATED THAT THE VEHICLE HAS STALL ON DIFFERENT OCCASION WHILE HE WAS DRIVING ON THE STREET. DEALER HAS BEEN CONTACTED AND STATED THAT THE VEHICLE HAD PROBLEMS WITH ROTORS BUT LATER NOTHING WAS FOUND. …
Read full complaint
CONSUMER CALLED COMPLETING ABOUT A REALLY BAD VIBRATION ON THE STEERING WHEEL EVERYTIME HE APPLY'S THE BRAKE PEDAL HE ALSO STATED THAT THE VEHICLE HAS STALL ON DIFFERENT OCCASION WHILE HE WAS DRIVING ON THE STREET. DEALER HAS BEEN CONTACTED AND STATED THAT THE VEHICLE HAD PROBLEMS WITH ROTORS BUT LATER NOTHING WAS FOUND. TS
CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THEY CAN HEAR A LOUD NOISE AND THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER HAS REPAIR VEHICLE ON SEVERAL OCCASIONS. DEALER NOTIFIED TS
THE VEHICLE LOSES CONTROL WHERE IT PULLS TO THE RIGHT SIDE, ESPECIALLY FROM THE REAR WHEN DRIVING OVER A ROUGH ROAD OR ON A SMOOTH ROAD UPON DRIVING OVER A SLIGHTLY RECESSED MANHOLE COVER. VEHICLE HAS BEEN BACK TO THE DEALER 2 TIMES FOR 4 WHEEL ALIGNMENT, WHEEL BALANCE AND REPLACEMENT OF REAR SHOCKS. NO IMPROVEMENTS IN CONDITION…
Read full complaint
THE VEHICLE LOSES CONTROL WHERE IT PULLS TO THE RIGHT SIDE, ESPECIALLY FROM THE REAR WHEN DRIVING OVER A ROUGH ROAD OR ON A SMOOTH ROAD UPON DRIVING OVER A SLIGHTLY RECESSED MANHOLE COVER. VEHICLE HAS BEEN BACK TO THE DEALER 2 TIMES FOR 4 WHEEL ALIGNMENT, WHEEL BALANCE AND REPLACEMENT OF REAR SHOCKS. NO IMPROVEMENTS IN CONDITION AFTER BOTH VISITS. ALIGNMENT DATA SHOWS THE REAR WHEELS ARE AT HIGHER LEVELS OF NEGATIVE CAMBER, WHICH IS NOT ADJUSTABLE, AND TOE. DRIVING VEHICLE IN ICY, RAINY WEATHER IS UNSAFE IF CURRENT HANDLING CHARACTERISTICS ARE NOT, OR CAN NOT BE CORRECTED. DT
WHEN APPLYING THE BRAKES IN A SUDDEN STOP. THE STEERING COLUMN "LOCKED UP" SO NO EVASIVE ACTION TO AVOID THE CAR IN FRONT COULD BE TAKEN. (THE ABILITY TO STEER THE VEHICLE WAS LOST) DT
FINGERS BENT AND TWISTED INDEX AND MIDDLE FINGERS ARE BENT AND TWISTED TOWARDS THE BABY FINGERS OF BOTH HANDS. SHOULDER PAIN IS PRESENT AND WRIST AND ELBOW. THUMBS ARE BENT AWAY FROM THE HANDS. INFORMATION SUBMITTED BY MIKE TOMICH ON BEHALF OF MRS. GREEN 989-665-2311. DT
WHILE STOPPED AT A STOP SIGN THE DRIVERS SIDE AIR BAG DEPLOYED WITHOUT WARNING, AS A RESULT THE DRIVER SUSTAINED BRUISES TO HIS BODY. THE DEALER HAS BEEN CONTACTED. *TS *NLM
CONSUMER STATES THAT WHEN APPLYING THE BRAKES IN A SUDDEN STOP VEHICLE STEERING WHEEL LOCKED UP, WHICH RESULTED IN AN ACCIDENT. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available