NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
939 reportsMileage unknown · Oct 27, 2004
Service Brakes, Hydraulic
YEARLY INSPECTION RESULTED IN A FAILURE DUE TO EXCESSIVE ROTOR WEAR ON BOTH FRON ROTORS. ALTHOUGH I WAS INFORMED THAT THE BRAKE PADS WOULD HAVE LASTED ANOTHER 5 TO 6 THOUSAND MILES. NO FAULTY OR DAMAGE TO THE FRONT END THAT WOULD HAVE CAUSED THIS TYPE OF WEAR. PREVIOUS INSPECTION LAST YEAR AT ANOTHER FORD DEALER SHOWED NO ISS…
Read full complaint
YEARLY INSPECTION RESULTED IN A FAILURE DUE TO EXCESSIVE ROTOR WEAR ON BOTH FRON ROTORS. ALTHOUGH I WAS INFORMED THAT THE BRAKE PADS WOULD HAVE LASTED ANOTHER 5 TO 6 THOUSAND MILES. NO FAULTY OR DAMAGE TO THE FRONT END THAT WOULD HAVE CAUSED THIS TYPE OF WEAR. PREVIOUS INSPECTION LAST YEAR AT ANOTHER FORD DEALER SHOWED NO ISSUES. ALSO INFORMED OF THIS TYPE OF WEAR BEING CONSIDERED NORMAL BY THE DEALERS DUE TO THE MANUFACTURING PROCESS OF THE ORIGINAL ROTORS BEING CHANGED TO INTICE OWNERS TO REPLACE RATHER THAN TURN THE ROTORS WHEN NEEDED. FOUND THAT THERE IS A PENDING CLASS ACTION IN CALIFORNIA OF THE SAME INCIDENT. ALSO LOCATED TWO TECHNICAL BULLITENS FROM FORD SHOWING CONCERN OVER THE ISSUE. CALLED THE FORD CORPORATE AND WAS TOLD THAT THERE WAS NOTHING I COULD DO DUE TO THE FACTORY WARRENT COVERING ONLY 12K MILES AND I WAS AT 34K MILES. CALLED THE DEALER BACK, TOLD THEM OF MY FINDINGS AND MY DISAPPOINTMENT IN DISCOVERING THAT IT WAS A KNOWN ISSUE AFTER ALL. THE SERVICE MANAGER CALLED ME BACK TO INFORM ME THAT IT WOULD BE COVERED UNDER WARRANTY SINCE THEY HAD OVERLOOKED THE ISSUE.*AK
NHTSA ODI #10096515
Mileage unknown · Oct 26, 2004
Steering
MY HUSBAND AND I BOUGHT A 2002 FORD FOCUS. WHEN I TRIED TO START THE CAR TO GO TO WORK THIS MORNING, THE IGNITION WOULD NOT TURN ALL THE WAY TO START THE CAR. THIS HAS BEEN A COMMON PROBLEM FOR THE FOCUS MODEL. I HAVE READ MANY COMPLAINTS ABOUT THE SAME PROBLEM ON THE INTERNET THEREFORE, THIS SHOULD BE A MANUFACTURER DEFAULT A…
Read full complaint
MY HUSBAND AND I BOUGHT A 2002 FORD FOCUS. WHEN I TRIED TO START THE CAR TO GO TO WORK THIS MORNING, THE IGNITION WOULD NOT TURN ALL THE WAY TO START THE CAR. THIS HAS BEEN A COMMON PROBLEM FOR THE FOCUS MODEL. I HAVE READ MANY COMPLAINTS ABOUT THE SAME PROBLEM ON THE INTERNET THEREFORE, THIS SHOULD BE A MANUFACTURER DEFAULT AND SHOULD BE FIXED. THE DEALERS ARE CHARGING $450 TO FIX THE PROBLEM THAT WASN'T OUR FAULT.*AK
NHTSA ODI #10096446
Mileage unknown · Oct 26, 2004
Electrical System
JUST PURCHASED A USED 2002 FORD FOCUS AND EVERYTHING WORKED JUST FINE UNTIL THE KEY WOULD NOT COME OUT OF THE IGNITION. THE LONGEST I HAVE SAT AND TRIED TO GET THE KEY OUT IS HALF AN HOUR AND FINALLY I JUST LEFT THE KEY IN THERE BECAUSE IT WAS RIDICULOUS. I WAS ABLE TO GET IT OUT THE NEXT DAY BUT THIS IS A CONSTANT PROBLEM AND…
Read full complaint
JUST PURCHASED A USED 2002 FORD FOCUS AND EVERYTHING WORKED JUST FINE UNTIL THE KEY WOULD NOT COME OUT OF THE IGNITION. THE LONGEST I HAVE SAT AND TRIED TO GET THE KEY OUT IS HALF AN HOUR AND FINALLY I JUST LEFT THE KEY IN THERE BECAUSE IT WAS RIDICULOUS. I WAS ABLE TO GET IT OUT THE NEXT DAY BUT THIS IS A CONSTANT PROBLEM AND IVE HEARD OTHERS TELL ME THAT THIS HAS HAPPENED IN THEIR FOCUS. THIS NEEDS TO BE ADDRESSED BY FORD, NOT BY THOSE OF US HAVING PROBLEMS WITH THEIR PRODUCT.*AK
NHTSA ODI #10096440
Mileage unknown · Oct 26, 2004
Steering
WHEN I PUT THE KEY IN THE IGNITION, IT WOULD NOT TURN. THE STEERING WHEEL LOCKED AND THE IGNITION SWITCH FROZE. I HAD TO HAVE IT REPAIRED FOR $300. APPARENTLY THE LOCKSMITH IS MAKING A FORTUNE OFF THE FORD FOCUS WITH THIS PROBLEM. *AK
NHTSA ODI #10096426
Mileage unknown · Oct 23, 2004
Electrical System
I WAS SHOPPING WITH MY 16 MON. OLD SONS AND AFTER WE WERE IN THE CAR I TRIED TO TURN THE KEY ON MY 2002 FORD FOCUS, THE IGNITION IS LOCKED. I'M TOLD THAT THIS IS COMMON IN THE FOCUS. I CALLED FORD AND AM TAKING MY CAR IN TO HAVE THE IGNITION REPLACED. IT WILL COST $300- $400.*AK
NHTSA ODI #10096273
Mileage unknown · Oct 19, 2004
Tires
WHILE DRIVING, A LOUD NOISE WAS HEARD COMING FROM THE FRONT OF THE VEHICLE. THE CONSUMER PULLED OVER AND NOTICED THAT THE PASSENGER SIDE TIRE BLEW OUT. THE CONSUMER TOOK THE LUG NUT AND BOLTS OFF. THE VEHICLE WAS TOWED TO THE DEALER. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10097171
31,040 miles · Oct 18, 2004
Service Brakes, Hydraulic
1)NORMAL DRIVING PATTERN; 2)BRAKES STARTED TO CRUNCH AT 31,000, THIS CAR WAS PURCHASED NEW AND STILL UNDER WARRANTY, BUT NOT FOR BRAKES. 3)TOOK TO FORD DEALER ON 10/15 THEY WANTED $550.00 PLUS TO FIX, MY SALESMAN TOLD ME HE HAD NEVER HEARD OF THIS HAPPENING AT SUCH LOW MILEAGE. CALLED FORD CORPORATE, GOT NO HELP WITH SERVICE R…
Read full complaint
1)NORMAL DRIVING PATTERN; 2)BRAKES STARTED TO CRUNCH AT 31,000, THIS CAR WAS PURCHASED NEW AND STILL UNDER WARRANTY, BUT NOT FOR BRAKES. 3)TOOK TO FORD DEALER ON 10/15 THEY WANTED $550.00 PLUS TO FIX, MY SALESMAN TOLD ME HE HAD NEVER HEARD OF THIS HAPPENING AT SUCH LOW MILEAGE. CALLED FORD CORPORATE, GOT NO HELP WITH SERVICE REP, REQUESTED A CALL FROM SUPERVISOR, STILL HAVEN'T RECIEVED A CALL BACK. TOOK TO MIDAS TO FIX, WAS REPAIRED THIS MORNING.*AK
NHTSA ODI #10095969
75,000 miles · Oct 17, 2004
Electrical System
APPROXIMATELY EVERY FIFTH TIME I DRIVE MY 2002 FORD FOCUS, THE KEY GETS STUCK IN THE IGNITION AND CANNOT BE REMOVED. SUBSEQUENTLY, I'M ABLE TO GET THE KEY OUT OF THE IGNITION (AFTER RESTARTING THE CAR AND DRIVING MINDLESSLY FOR A FEW MILES). THE DEALER IS AWARE OF THIS PROBLEM, AND THEY HAVE REPLACED THE LOCK CYLINDER TWICE TO N…
Read full complaint
APPROXIMATELY EVERY FIFTH TIME I DRIVE MY 2002 FORD FOCUS, THE KEY GETS STUCK IN THE IGNITION AND CANNOT BE REMOVED. SUBSEQUENTLY, I'M ABLE TO GET THE KEY OUT OF THE IGNITION (AFTER RESTARTING THE CAR AND DRIVING MINDLESSLY FOR A FEW MILES). THE DEALER IS AWARE OF THIS PROBLEM, AND THEY HAVE REPLACED THE LOCK CYLINDER TWICE TO NO AVAIL. WITHIN DAYS OF GETTING "FIXED", THE PROBLEM SPROUTS UP AGAIN, LEAVING ME WITHOUT KEYS, WITHOUT THE ABILITY TO LOCK THE CAR (THAT WOULD LOCK MY KEYS IN THE CAR), AND FORCING ME TO PLAN AHEAD AND TAKE A SPARE KEY WITH ME WHEREVER I GO (SO I CAN LOCK THE KEYS IN THE CAR, STILL IN THE IGNITION -- A PRIME CANDIDATE FOR VEHICLE THEFT). THIS PROBLEM HAS BEEN REPORTED ON NUMEROUS WEB SITES, AND THERE ARE CLEARLY PROBLEMS WITH THE IGNITION SYSTEM EMPLOYED BY FORD. *JB
NHTSA ODI #10095921
Mileage unknown · Oct 15, 2004
Air BagsInjury
MY WIFE WAS DRIVING OUR 2002 FORD FOCUS ON EXPRESSWAY AT ABOUT 40-45 MPH WHEN THE DRIVER'S SIDE, SIDE IMPACT AIR BAG WENT OFF FOR NO APPARENT REASON. THE VEHICLE WAS FILLED WITH SMOKE, BUT MY WIFE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. MY WIFE SUSTAINED MINOR INJURIES TO HER LEFT ARM AND HAD RINGING IN HER LEFT EAR FOR T…
Read full complaint
MY WIFE WAS DRIVING OUR 2002 FORD FOCUS ON EXPRESSWAY AT ABOUT 40-45 MPH WHEN THE DRIVER'S SIDE, SIDE IMPACT AIR BAG WENT OFF FOR NO APPARENT REASON. THE VEHICLE WAS FILLED WITH SMOKE, BUT MY WIFE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. MY WIFE SUSTAINED MINOR INJURIES TO HER LEFT ARM AND HAD RINGING IN HER LEFT EAR FOR TWO DAYS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND INSPECTED. THE DEALER COULD ONLY FIND A SMALL DENT ON THE UNDER CARRIAGE (LOCATED AT THE REAR OF THE VEHICLE) OF THE VEHICLE. THE DENT APPEARED TO BE OLD DAMAGE. A CHECK OF THE COMPUTER REVEALED THE CODE FOR PROPER AIR BAG DEPLOYMENT. FORD STATED THEY WOULD NOT COVER THE EXPENSE TO FIX THE PROBLEM BECAUSE THE COMPUTER CHIP INDICATING THE CORRECT DEPLOYMENT OF THE AIRBAG. FORD REFUSED TO LISTEN THAT THERE WAS NO DAMAGE TO INDICATE THE PROPER DEPLOYMENT OF THE AIR BAG, NOR WOULD THEY BELIEVE MY WIFES STATEMENTS. PLEASE ADVISE.*AK
NHTSA ODI #10095852
Mileage unknown · Oct 13, 2004
Wheels
WHILE DRIVING, A LOUD NOISE WAS HEARD COMING FROM THE FRONT OF THE VEHICLE. THE CONSUMER PULLED OVER AND DISCOVERED THE LEFT FRONT TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO A MECHANIC WHO INFORMED THE DRIVER THAT THE RIM WAS BENT AND CAUSED THE TIRE TO GO FLAT. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10096782
Official recalls
1Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Illustration