IllustrationTHE FRONT TIRES WORE OUT. CONSUMER HEARD A LOUD NOISE COMING FROM THE FRONT TIRES. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. FIRESTONE, P205/50R16. *AK
2002 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
13425–50K
13950–75K
8375–100K
74100–150K
26150K+
604 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
82 crash reports20 fire reports60 injury reports
Tires complaints
62 reportsBOTH FRONT TIRES AND RIMS BLEW OUT WHEN THE VEHICLE WENT OVER A SMALL POT HOLE. THIS OCCURRED WHILE DRIVING IN COLD WEATHER. THE TIRES WRE LOW PROFILE TIRES. THE TIRES WERE REPLACED. THE PROBLEM RECURRED ON THE PASSENGER SIDE FRONT TIRE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
REAR TIRES TRACTION FAILED. AS A RESULT, VEHICLE BECAME UNCONTROLLABLE. *AK THE CONSUMER STATED WHEN THE ROADS WERE WET, THE VEHICLE WAS HARD TO CONTROL. THE VEHICLE WAS TAKEN TO THE DEALER AT LEAST 6 TIMES FOR THE SAME PROBLEM, THREE OF THE SIX TIMES THE DEALER REPLACED THE TIRES, HOWEVER THAT DID NOT RESOLVE THE PROBLEM. *JB
THE FIRESTONE FIREHAWK GTA-02 ORIGINAL TIRES THAT CAME WITH MY 2002 FORD FOCUS ZX3 APPEAR TO HAVE A FLAW. SHORTLY AFTER PURCHASING MY FOCUS, I NOTICED A "BUBBLE" ON THE RIGHT FRONT TIRE'S SIDEWALL. THE OTHER THREE TIRES HAVE BEEN FINE OVER THE PAST ENSUING 21 MONTHS SO I HAVE TO BE BELIEVE THAT THIS ONE TIRE WAS FLAWED COMING …
Read full complaint
THE FIRESTONE FIREHAWK GTA-02 ORIGINAL TIRES THAT CAME WITH MY 2002 FORD FOCUS ZX3 APPEAR TO HAVE A FLAW. SHORTLY AFTER PURCHASING MY FOCUS, I NOTICED A "BUBBLE" ON THE RIGHT FRONT TIRE'S SIDEWALL. THE OTHER THREE TIRES HAVE BEEN FINE OVER THE PAST ENSUING 21 MONTHS SO I HAVE TO BE BELIEVE THAT THIS ONE TIRE WAS FLAWED COMING OUT OF THE FACTORY. MY FORD DEALER WILL NOT REPLACE IT WITHOUT CHARGING A FULL PRICE SINCE THERE IS NO KNOWN RECALL ON THIS PARTICULAR TIRE. YET, I SEE NOW THROUGH THE NHTSA THAT THERE ARE SEVERAL "SIDEWALL BUBBLE" COMPLAINTS AGAINST THIS TIRE MODEL. PLEASE ADD MY COMPLAINT TO THE LIST, SINCE I HAVE DRIVEN A LOT OF CARS OVER THE YEARS, AND NEVER SAW A "BUBBLE" POP UP LIKE THIS ....SEEMINGLY OUT OF NOWHERE! TOM. *AK
EXCESSIVE BRAKE DUST 2002 FORD FOCUS (VIN#: FAFP383X2W110369). HAVE REPLACED 3 TIRES ALL UNDER 20,000MI. (FIRESTONE). ONE REPLACEMENT TIRE (FIRESTONE) FAILED AFTER ROUGHLY 5000MI. FAILINGS HAPPEN ON FLAT SMOOTH HIGHWAY. EXTREMELY DANGEROUS SITUATION WHEN FRONT TIRES FAIL (TREAD IS GOOD, NO WEAR, NO PUNCTURES, PRESSURE GOOD).…
Read full complaint
EXCESSIVE BRAKE DUST 2002 FORD FOCUS (VIN#: FAFP383X2W110369). HAVE REPLACED 3 TIRES ALL UNDER 20,000MI. (FIRESTONE). ONE REPLACEMENT TIRE (FIRESTONE) FAILED AFTER ROUGHLY 5000MI. FAILINGS HAPPEN ON FLAT SMOOTH HIGHWAY. EXTREMELY DANGEROUS SITUATION WHEN FRONT TIRES FAIL (TREAD IS GOOD, NO WEAR, NO PUNCTURES, PRESSURE GOOD). POSSIBLY TIRE IS SEPARATED FROM RIM??? VEHICLE BOUGHT FROM LITHIA FORD (OMAHA, NE). *JB
WHILE DRIVING 65 MPH REAR PASSENGER'S SIDE TIRE EXPLODED, CAUSING THE DRIVER TO LOSE CONTROL. NO IMPACT REPORTED. *AK
I HAVE A 2002 FORD FOCUS STATION WAGON AND THE TIRES WEAR OUT TOO FAST I HAVE 45000 MILES AND TWO SETS OF TIRES. THEY SHIMMY BAD. ITS A VEHICLE PROBLEM WITH THE REAR WHEELS. FORD WON,T FIX THE PROBLEM VIN [XXX]. *AK *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ALL FOUR STUDS ON THE RIGHT FRONT BROKE OFF AND CAUSED DAMAGE TO THE BRAKES, FRONT BUMPER, ALONG WITH A FEW OTHER THINGS. THE DEALER SAID IT WAS MY FAULT BECAUSE I HAD A MECHANIC BESIDES THEM CHANGE THE BRAKES ON IT. I HAD MY 2 MONTH BABY NIECE IN THE BACK ALONG WITH 3 OTHER PEOPLE. THE OTHER PROBLEM I HAVE IS THE SEAL ON THE WI…
Read full complaint
ALL FOUR STUDS ON THE RIGHT FRONT BROKE OFF AND CAUSED DAMAGE TO THE BRAKES, FRONT BUMPER, ALONG WITH A FEW OTHER THINGS. THE DEALER SAID IT WAS MY FAULT BECAUSE I HAD A MECHANIC BESIDES THEM CHANGE THE BRAKES ON IT. I HAD MY 2 MONTH BABY NIECE IN THE BACK ALONG WITH 3 OTHER PEOPLE. THE OTHER PROBLEM I HAVE IS THE SEAL ON THE WINDSHIELD IS COMING OUT NEAR THE ROOF.
THERE IS A LINE THAT WENT STRAIGHT INTO THE ENGINE'S INTAKE THAT HAS BEEN LEAKING FLUID SINCE 2,000 MILES AND WAS INSPECTED BY DELER WHO TOLD TO ME THAT IT WAS NOTHING. BUT THE ENGINE CASE SHOULD NOT HAVE A LARGE LEAK OF FLUID THAT SOON. FINALLY NOW, THEY HAVE DONE SOMETHING ON THIS AND REPLACED THE HOSE, AS IT WAS SEEN ONCE MOR…
Read full complaint
THERE IS A LINE THAT WENT STRAIGHT INTO THE ENGINE'S INTAKE THAT HAS BEEN LEAKING FLUID SINCE 2,000 MILES AND WAS INSPECTED BY DELER WHO TOLD TO ME THAT IT WAS NOTHING. BUT THE ENGINE CASE SHOULD NOT HAVE A LARGE LEAK OF FLUID THAT SOON. FINALLY NOW, THEY HAVE DONE SOMETHING ON THIS AND REPLACED THE HOSE, AS IT WAS SEEN ONCE MORE AND KNOWS OF ALL THE TIMES REPORTED. I HOPE THIS IS JUST NOT A EASY FIX OR THIS NOW HASN'T CAUSED ANY DAMANGE TO THE INSIDE OF THE ENGINE ITSELF, AS THE ENGINE HAS BEEN IN THE SHOP FOR RIDING ROUGH. THEY TOLD ME LAST TIME THAT THE PART OF THE TRANSMISSION THAT WAS FIXED WOULD FIX THIS. I THINK IT IS DUE TO THE OIL LEAK ON THE TOP OF THE ENGINE CASE SINCE IT WAS NEW. A NEW CAR SHOULD NEVER HAVE A OIL LEAK ON A ENGINE CASE.
FORD FOCUS 2002 ZX5 WITH 16" ALLOY WHEELS AND FIRESTONE TIRES SEEMS TO BE SUSCEPTIBLE TO ROAD HAZARD DAMAGE MORE THAN OTHER CARS I HAVE HAD. ONE BUBBLED TIRE, AND ANOTHER PUNCTURED TIRE WITHIN WEEKS OF EACH OTHER. THE FOCUS ALLOY WHEELS ARE THE WORSE PROBLEMS. AT LEAST TWO HAVE BEEN BENT TO THE POINT OF CAUSING STEERING AN…
Read full complaint
FORD FOCUS 2002 ZX5 WITH 16" ALLOY WHEELS AND FIRESTONE TIRES SEEMS TO BE SUSCEPTIBLE TO ROAD HAZARD DAMAGE MORE THAN OTHER CARS I HAVE HAD. ONE BUBBLED TIRE, AND ANOTHER PUNCTURED TIRE WITHIN WEEKS OF EACH OTHER. THE FOCUS ALLOY WHEELS ARE THE WORSE PROBLEMS. AT LEAST TWO HAVE BEEN BENT TO THE POINT OF CAUSING STEERING AND VIBRATION PROBLEMS ON CAR. ONE WHEEL HAS TWO VISIBLE BUMPS, AND ONE WHEEL HAS A MASSIVE BUMP FROM SOME SURPRISE ROAD HOLES. I HAVE NEVER HAD A CAR THAT HAD SUCH WEAK RIMS. I AM NOT REPLACING THE WHEELS UNTIL I TALK TO EITHER FORD OR A LAWYER.
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available