PREMATURE REAR TIRE WEAR. 6 TIRES WERE REPLACED BEFORE 27,000 MILES. DEALER SAYS ALIGNMENT IS AT FORD SPECIFICATIONS. DEALER SAID ROTATION AT 3000 MILES IS REQUIRED ON THIS VEHICLE TO PREVENT THIS PROBLEM. OVERHEARD TECH TELLING SERVICE MANAGER THAT THESE CARS DON'T HAVE ENOUGH ADJUSTMENT FOR CAMBER. TIRES CAN NOT BE ROTATED AF…
Read full complaint
PREMATURE REAR TIRE WEAR. 6 TIRES WERE REPLACED BEFORE 27,000 MILES. DEALER SAYS ALIGNMENT IS AT FORD SPECIFICATIONS. DEALER SAID ROTATION AT 3000 MILES IS REQUIRED ON THIS VEHICLE TO PREVENT THIS PROBLEM. OVERHEARD TECH TELLING SERVICE MANAGER THAT THESE CARS DON'T HAVE ENOUGH ADJUSTMENT FOR CAMBER. TIRES CAN NOT BE ROTATED AFTER 5000 MILES BECAUSE THEY CUP OUT AND WHEN MOVED TO THE FRONT CAUSE SEVERE VIBRATION.*AK
NHTSA ODI #10037490
Mileage unknown · Aug 31, 2003
SteeringSuspension
PROBLEMS WITH 2002 FORD FOCUS STEERING AND SUSPENSION.*MR *CB
NHTSA ODI #10033827
9,600 miles · Aug 25, 2003
SteeringSuspensionInjury
STEERING WHEEL LOST CONTROL WHILE DRIVING AT NORMAL SPEED. AS RESULT, LOWER AND UPPER BALL JOINTS AND BRAKE WERE DAMAGED. DEALER NOTIFIED. *AK UPDATED 1/11/2006. THERE WAS POPPING AND CLICKING IN THE STEERING WHEEL WHILE TURNING. THIS CAUSED THE CONSUMER TO LOSE CONTROL AND HIT A CURB. THE IMPACT RESULTED IN A BLOWN TIRE. …
Read full complaint
STEERING WHEEL LOST CONTROL WHILE DRIVING AT NORMAL SPEED. AS RESULT, LOWER AND UPPER BALL JOINTS AND BRAKE WERE DAMAGED. DEALER NOTIFIED. *AK UPDATED 1/11/2006. THERE WAS POPPING AND CLICKING IN THE STEERING WHEEL WHILE TURNING. THIS CAUSED THE CONSUMER TO LOSE CONTROL AND HIT A CURB. THE IMPACT RESULTED IN A BLOWN TIRE. *NM
NHTSA ODI #10034456
3,500 miles · Jul 23, 2003
Suspension
LEFT REAR WHEEL TIPPING IN AT TOP SO MUCH THAT YOU COULD SEE IT BEFORE 3500 MILES. THIS CAUSES THE REAR END TO BE MUCH "LOOSER" THAN IS NORMAL OR ACEPTABLE. FORD PROVIDES NO ADJUSTMENT FOR CAMBER IN REAR AND THIS CAUSED LEFT REAR TIRE TO HAVE A CUPPING PATTERN ON THE INSIDE EDGE. APPARENTLY IF THE CAMBER ISN'T CORRECT TO BEGIN I…
Read full complaint
LEFT REAR WHEEL TIPPING IN AT TOP SO MUCH THAT YOU COULD SEE IT BEFORE 3500 MILES. THIS CAUSES THE REAR END TO BE MUCH "LOOSER" THAN IS NORMAL OR ACEPTABLE. FORD PROVIDES NO ADJUSTMENT FOR CAMBER IN REAR AND THIS CAUSED LEFT REAR TIRE TO HAVE A CUPPING PATTERN ON THE INSIDE EDGE. APPARENTLY IF THE CAMBER ISN'T CORRECT TO BEGIN IT WILL THROW OFF THE WHOLE ALIGNMENT. ONE DEALER CHECKED AND SAID IT WAS IN SPEC. AT 15,000 MI. FOUND DEALER WHO UNDERSTOOD THE PROBLEM AND INSTALLED A JUST RELEASED SHIM KIT. FORD REFUSING TO COVER KIT, ALIGNMENT, OR TIRE UNDER " BUMPER-TO-BUMPER" WARRANTY (TRYING TO CLAIM IT IS A NORMAL WEAR ITEM, OR A TIRE PROBLEM, OTHER TIRES ARE FINE!). HAD TO PAY $142 + TIRE SO THAT THE REAR END DOESN'T COME AROUND CAUSE AN ACCIDENT.*AK
NHTSA ODI #10029020
66,000 miles · Jul 22, 2003
StructureSuspension
I HAVE DRIVEN MY FORD FOCUS SE WAGON NOW FOR ABOUT TWO YEARS. IT IS A COMPANY CAR FOR WHICH I DRIVE APPROXIMATELY 50,000MILES PER YEAR. I HAVE HAD TO REPLACE THE REAR TIRES THREE TIMES SINCE RECEIVING THE VEHICLE DECEMBER 2001. EVERY 20,000 MILES THE REAR ALIGNMENT GETS LOOSE AND ESPECIALLY IN WINTER DRIVING ON WET PAVEMENT, I F…
Read full complaint
I HAVE DRIVEN MY FORD FOCUS SE WAGON NOW FOR ABOUT TWO YEARS. IT IS A COMPANY CAR FOR WHICH I DRIVE APPROXIMATELY 50,000MILES PER YEAR. I HAVE HAD TO REPLACE THE REAR TIRES THREE TIMES SINCE RECEIVING THE VEHICLE DECEMBER 2001. EVERY 20,000 MILES THE REAR ALIGNMENT GETS LOOSE AND ESPECIALLY IN WINTER DRIVING ON WET PAVEMENT, I FEAR FOR MY LIFE BECAUSE WHEN I CANNOT TRAVEL AT THE SPEEDS OF SURROUNDING TRAFFIC FLOW. THERE IS A VIBRATION IN THE REAR TIRES CAUSED POSSIBLY TO A BENT FRAME OR POOR DESIGN. I HAVE NEVER REPLACED THE FRONT TIRES OR EVEN ROTATED THEM SINCE NEW! THEY ARE STILL PLENTY ADEQUATE FOR TRACTION. THE REAR ALIGNMENT PROBLEM SEVERELY HAMPERS THE FUEL ECONOMY OF THE VEHICLE BECAUSE IT FEELS AS THOUGH I AM DRAGGING THE REAR END AROUND EVERYWHERE I GO. I AM TURNING THE VEHICLE IN THIS NEXT MONTH FOR A REPLACEMENT AND I HAVE DECIDED I WILL NEVER PURCHASE A FORD VEHICLE AGAIN DUE TO THE HISTORY OF BAD LUCK I HAVE HAD WITH FORDS IN THE PAST.
NHTSA ODI #10028786
Mileage unknown · Jun 5, 2003
EquipmentSuspension
I HAVE HAD MY A/C WORKED ON AT LEAST 3 TIMES. ALSO HAVE HEAVY VIBRATIONS WHEN I JUST HAD IT ALIGNED 5/04/03. AND STILL HAVING HEAVY VIBRATIONS.AK
NHTSA ODI #10021084
30,000 miles · May 8, 2003
Suspension
THE VEHICLE HAD A NOISE IN THE REAR END, DUE TO TIRE CUPPING. WHICH WAS CAUSED BY THE REAR SUSPENSION NOT SETTLING AND NOT BEING ALIGNED. *JB THE CONSUMER WAS TOLD THAT FORD HAD AN A CAMBER KIT TO INSTALL TO SOLVE THE SETTLING. *SCC
NHTSA ODI #10019456
Mileage unknown · May 7, 2003
Suspension
WHILE DRIVING 50-60 MPH THE VEHICLE VIBRATES VIOLENTLY. *NLM
NHTSA ODI #10019378
Mileage unknown · Mar 10, 2003
Suspension
THE VEHICLE SWAYED FROM LEFT TO RIGHT AND THERE WAS A POPPING NOISE COMING FROM THE REAR ALSO. *JB
NHTSA ODI #10011308
Mileage unknown · Feb 24, 2003
SuspensionCrashInjury
THE VEHICLE VIOLENTLY PULLED TO THE LEFT WHICH CAUSED AN ACCIDENT AND INJURIES. *JB
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Illustration