2002 Ford Focus

FUEL PUMP IN MY 2002 FORD FOCUS FAILED SUDDENLY AS I WAS MERGING ONTO A 50MPH HIGHWAY IN JANUARY 2010. THE CAR JUST LITERALLY DIED, WITHOUT WARNING. FUEL INTAKE STOPPED AND SO DID THE CAR. I WAS LUCKY IT WAS EARLY ON A SUNDAY MORNING AND TRAFFIC WAS LIGHT. IF I HAD BEEN IN HEAVY TRAFFIC, THIS SUDDEN FAILURE WOULD HAVE POSED A GRAVE SAFETY RISK. THE REPAIR COST $700. FORD REFUSED TO COVER ANY OF IT. IN A SEARCH OF INTERNET ARTICLES AND YOUR WEB SITE, I FOUND THIS FUEL PUMP FAILURE TO BE A WELL-DOCUMENTED PROBLEM IN 2000 - 2002 FORD FOCUS'. I AM CONCERNED THAT THEY REPLACED THE ORIGINAL DEFECTIVE PUMP WITH AN EXACT REPLICA OF THE ORIGINAL PUMP, EXPOSING ME TO CONTINUED DANGER. *TR

2002 FORD FOCUS EXHIBITS ENGINE HESITATION WHEN THE FUEL TANK IS BELOW 1/4 FULL. THERE ARE ACCELERATION PROBLEMS AND THE CAR HAS COMPLETELY LOST POWER ON AT LEAST ONE OCCASION WHILE DRIVING ON THE HIGHWAY. THIS BEGAN TO HAPPEN WITH 80,000KM ON THE CAR AND NOW ALWAYS HAPPENS WHEN DRIVING AT HIGHWAY SPEEDS WITH ONLY 1/4 TANK OF GAS. COMPLAINTS TO FORD ABOUT HOW THIS IS THE EXACT SAME CONDITION THAT CAUSED THEM TO ISSUE A RECALL ON 2000 AND 2001 FOCUSES (03N01) HAVE NOT RESULTED IN ANY OFFER TO REPLACE THE FUEL PUMP FOR FREE. *TR

2002 FORD FOCUS BOUGHT THE END OF MARCH 2009, NOW SITS IN DRIVEWAY, BECAUSE FORD WILL NOT FIX FUEL DELIVERY MODULE FAILURE, BECAUSE OF VIN# NOT ON LIST AS BEING ONE OF THE 671000 UNITS AFFECTED. THE CAR IS DOING THE SAME THING AS ALL THE OTHER 671000 THAT WERE AFFECTED, SURGING, LOSS OF POWER, STALLING, HESITATION. WE WERE GOING DOWN THE ROAD, CHANGED LANES AND IT STARTED DOING THIS, NOW I HAVE HAD 3 MECHANICS WORK ON THIS CAR, NO HELP REPLACED FUEL PUMP, BATTERY, FUEL FILTER ETC, NO LUCK. IT STARTS WHEN IT WANTS WILL RUN THEN IT STARTS LOSING POWER, STALLS. WE DID EXPECT PROBLEMS WITH USED CAR, BUT NOT ONE THAT SHOULD HAVE BEEN INCLUDED IN A RECALL AND FIXED. IF ACCIDENT HAPPENS BECAUSE OF THIS PROBLEM FORD WILL BE AT FAULT. *TR

MY 2002 FORD FOCUS ZTS SUDDENLY STALLED IN HEAVY, FAST MOVING TRAFFIC. I HAD TO WRESTLE THE CAR TO THE CURB WITHOUT POWER STEERING OR POWER BRAKES WHILE AT THE SAME TIME AVOIDING TRAFFIC. I TOOK IT TO THE SHOP AND THEY SAID THE FUEL PUMP HAS FAILED AND NEEDED REPLACEMENT. TOTAL COST ESTIMATE IS NEARLY $800. THIS IS A COMMON PROBLEM IN 2001 AND 2000 MODELS AND THIS PART IS EVEN COVERED IN AN EXTENDED WARRANTY FOR THOSE YEARS. HOWEVER, THE 2002 IS NOT COVERED. I THINK THAT THIS SHOULD BE A SAFELY CONCERN FOR FORD BUT I THINK THEY ARE DOING THE BARE MINIMUM. I WILL NEVER BUY ANOTHER FORD AGAIN. NO WONDER THEY ARE HAVING SUCH DIFFICULT TIMES AT FORD! *TR

I PURCHASED A USED 2002 FORD FOCUS IN FL. WHILE DRIVING IT TO MY HOME IN TN, I EXPERIENCED STALLING AT HWY SPEEDS. I CHANGED THE FUEL FILTER AND CONTINUED ON MY TRIP. IT STALLED AGAIN AND WOULDN'T RESTART. I HAD IT TOWED TO A FORD DEALER THAT DIAGNOSED THE PROBLEM AS THE ALTERNATOR AND BATTERY. I REPLACED THEM BOTH. THE CAR STARTED AND I BEGAN MY TRAVEL BACK HOME. UPON MY RETURN HOME, WHEN I WOULD UTILIZE THE CAR, I WOULD EXPERIENCE STALLING UNDER VARYING CONDITIONS. I TOOK IT TO A MECHANIC WHO COULD NOT FIND THAT PROBLEM, BUT DID REPLACE THE THERMOSTAT. TYPICALLY THE CAR WOULD RUN FOR SEVERAL HOURS BEFORE THE STALLING WOULD BEGIN. I COULD USUALLY ALLOW THE ENGINE TO COOL FOR APPROXIMATELY 20-30 MINUTES AND THE CAR WOULD START. I COULD DRIVE FOR APPROXIMATELY 15 MINUTES BEFORE IT WOULD STALL AGAIN. MY LATEST EXPERIENCE HAPPENED AT HWY SPEEDS. AFTER 30 MINUTES OF TRAVEL THE CAR STALLED AND HAS NOT RESTARTED SINCE. I CONTACTED FORD WHO INFORMED ME THAT MY CAR WAS NOT PART OF THEIR "RECALL (S)" DUE TO WHERE IT WAS ASSEMBLED. I FIND IT VERY "COINCIDENTAL" THAT MY CAR IS EXPERIENCING THE EXACT PROBLEMS THAT THE "RECALLED" CARS EXPERIENCED. IS THERE A COURSE ON ACTION THAT I SHOULD TAKE? *TR

TL*THE CONTACT OWNS A 2002 FORD FOCUS. WHILE DRIVING 30 MPH, THE VEHICLE COMPLETELY FAILED AND SHUT OFF. THE VEHICLE FAILED TO START, BUT THE CONTACT WAS ABLE TO PULL OFF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE SENDER AND FUEL PUMP FAILED, WHICH CAUSED THE VEHICLE TO SHUT OFF. THE VEHICLE WAS REPAIRED AT THE COST OF $540. THE MANUFACTURER STATED THAT THERE WAS NO CURRENT RECALL FOR THE FUEL PUMP; THEREFORE, NO COMPENSATION WOULD BE MADE. UPDATED 01-26-09 *BFTHE FAILURE MILEAGE WAS 22,600 AND CURRENT MILEAGE WAS 22,700. UPDATED 01/26/09. *JB

I DRIVE A 2002 FORD FOCUS WAGON, MILEAGE 85,578. TWO DAYS AGO I HAD TROUBLE STARTING IT. I DID GET IT STARTED BUT EVERYTIME I TOOK MY FOOT OFF THE ACCELERATOR THE ENGINE STALL. THERE WAS NO CHECK ENGINE LIGHT WARNING PRIOR TO THIS OR DURING THE EVENT. I WAS ABLE TO DRIVE MY CAR HOME, BUT HAD TO RESTART IT EACH TIME I HAD TO STOP. THE NEXT MORNING IT DROVE FINE BUT I TOOK IT TO A FORD DEALER FOR DIAGNOSIS AND REPAIR. I WAS TOLD IT WAS A FUEL PUMP FAILURE AND IT COST ME OVER A $1000 FOR REPAIR. (PARTS LISTER WERE SENDER, GASKET, KIT, TUBE, GASKET, FILTER). IN RESEARCHING RECALLS I FOUND THAT MODEL YEARS 2000-2001 WERE HAVING THIS EXACT SAME PROBLEMS AND A RECALL WAS DETERMINED FOR THIS. I DO NORMAL DRIVING - 70% HIGHWAY, 30% IN TOWN. MY CAR IS JUST OVER 5 YEARS OLD, I DON'T BELIEVE THAT NORMAL WEAR AND TEAR SHOULD CAUSE THE FUEL PUMP TO FAIL. IT SEEMS TO ME THAT THIS IS SOME KIND OF DEFECT IN THE ORIGINAL PART OR ASSEMBLY. *TR

APPROXIMATELY 3 WEEKS AGO, WHILE DRIVING ON THE INTERSTATE (~65 MILES PER HOUR), A COOLING SYSTEM LIGHT CAME ON (2002 FORD FOCUS, MANUAL TRANSMISSION, 46,000 MILES), AND INSTANTANEOUSLY, THE CAR STALLED. IT ALMOST THREW ME INTO THE WINDSHIELD. THE CAR RECOVERED AND DID NOT DIE, AND I WAS ABLE TO GET TO WHERE I WAS GOING. IT HAPPENED AGAIN A FEW DAYS LATER WHILE MAKING A RIGHT HAND TURN (~20 MILES PER HOUR). I BROUGHT IT TO PEP BOYS, WHO COULD FIND NOTHING WRONG. IT STALLED AND DIED TWO BLOCKS AWAY FROM PEP BOYS, SO I BROUGHT IT TO THE FORD DEALERSHIP. I ASKED THEM TO CHECK ON ANY RECALLS BECAUSE I HAVE NOTICED THAT MANY FOCUSES HAVE THIS PROBLEM. THEY CALLED ME TO TELL ME THAT IT WAS DEFINITELY THE THERMOSTAT , THERMOSTAT HOUSING ASSEMBLY AND O RING, AND I NEEDED AN OIL CHANGE (WHICH WAS DONE AT PEP BOYS ONE WEEK EARLIER). THEY WANTED $1100.00 TO FIX IT, SO I TOOK MY CAR HOME. TODAY, I DROVE IT TO A MECHANIC, AND IT KILLED TWICE, AND STALLED THREE TIMES (DRIVING NO MORE THAN 30 MPH). THE HAZARD LIGHT CAME ON BY ITSELF WHILE I WAS DRIVING. THE MECHANIC JUST CALLED TO TELL ME THAT THE FUEL PUMP IS BAD, AND THAT IS WHAT WAS CAUSING THE STALLING. IT IS A SHAME THAT I COULD HAVE BEEN KILLED IN THIS CAR, AND NO RECALLS HAVE BEEN DONE ON THE 2002 FORD FOCUS FOR FAULTY FUEL PUMPS. *TR