IllustrationENGINE JUST DIES WITH NO WARNING WHILE ON THE HIGHWAY,AFTER ENGINE DIES I LOSE POWER STEERING, AND WHEEL WILL NOT TURN. I AM ABLE TO RESTART THE CAR WHILE STILL IN MOTION. THIS IS THE THIRD TIME THIS HAS HAPPENED.*AK
2002 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
13425–50K
13950–75K
8375–100K
74100–150K
26150K+
604 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
82 crash reports20 fire reports60 injury reports
Engine And Engine Cooling complaints
103 reportsI WAS DRIVING ON THE ON-RAMP OF THE PA TURNPIKE WHEN SCALDING WATER FROM UP UNDER THE DASH POURED OUT ONTO MY RIGHT FOOT. I WAS BARELY ABLE TO DRIVE THE CAR TO A SAFE STOP. I SUSTAINED SECOND AND THIRD DEGREE BURNS TO MY RIGHT FOOT. THE WRECKER TOOK THE CAR TO A FORD DEALER IN EMMAUS, PA FOR REPAIRS. THE SERVICE DEPARTMENT O…
Read full complaint
I WAS DRIVING ON THE ON-RAMP OF THE PA TURNPIKE WHEN SCALDING WATER FROM UP UNDER THE DASH POURED OUT ONTO MY RIGHT FOOT. I WAS BARELY ABLE TO DRIVE THE CAR TO A SAFE STOP. I SUSTAINED SECOND AND THIRD DEGREE BURNS TO MY RIGHT FOOT. THE WRECKER TOOK THE CAR TO A FORD DEALER IN EMMAUS, PA FOR REPAIRS. THE SERVICE DEPARTMENT ORIGINALLY TOLD ME THAT THE EVAPORATOR LINE WAS PLUGGED, BUT WHEN I PICKED UP MY CAR, THE NARRATIVE ON THE SERVICE FORM SAID THAT THE LINE WAS NOT PLUGGED. THEY REPLACED THE EVAPORATOR WHICH I UNDERSTAND ENTAILED REMOVING THE ENTIRE DASH. I DO NOT KNOW IF THE OLD PART IS AVAILABLE.*AK
CHECK ENGINE LIGHT COMONG ON, HAD IT IN SHOP 5 TO 7 TIMES AND THEY SAY IT IS THE EVAP SYSTEM, SHUT OFF THE LIGHT AND SEND ME OUT THE DOOR!! WHAT IS UP WITH THAT? *AK
HEAT SHIELD DROPPED WHILE DRIVING ON WEST RIDGE ROAD CAUSING SPARKS. IT RUPTURED THE FUEL LINE WHICH CAUSED THE FUEL TO SPEW ALL OVER THE ROAD. 911 CONTACTED, ROAD CLOSED AND TACO BELL WHERE THE VEHICLE WAS MOVED, WAS EVACUATED DUE TO THE MASSIVE FUEL LEAK AND FUMES. DEALERSHIP CONTACTED, TOW TRUCK PICKED UP VEHICLE.*AK
WHILE DRIVING ON THRUWAY ENGINE QUIT, AND CAR WAS ON FIRE. COURTESY FORD CHECKED CAR AND FOUND PISTON WENT THROUGH BLOCK CAUSING OIL TO CATCH FIRE UNDER CAR AND MELTING FUEL LINES. VEHICLE HAS 60K AND HAS BEEN SERVICED REGULARLY. QUOTED OVER $6000.00 AND WAS TOLD WARRANTY ENDED AT 36K. THIS INCIDENT COULD HAVE BEEN VERY SERIOU…
Read full complaint
WHILE DRIVING ON THRUWAY ENGINE QUIT, AND CAR WAS ON FIRE. COURTESY FORD CHECKED CAR AND FOUND PISTON WENT THROUGH BLOCK CAUSING OIL TO CATCH FIRE UNDER CAR AND MELTING FUEL LINES. VEHICLE HAS 60K AND HAS BEEN SERVICED REGULARLY. QUOTED OVER $6000.00 AND WAS TOLD WARRANTY ENDED AT 36K. THIS INCIDENT COULD HAVE BEEN VERY SERIOUS. *NM
WHILE DRIVING AT HIGHWAY SPEEDS ENGINE LOST POWER, NEARLY RESULTING IN A REAR END COLLISION. DEALER WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK THE TACHOMETER WOULD SUDDENLY RACE UP TO 7000 AND THE WHEELS LOST POWER. THE VEHICLE FELT AS IF IT WERE IN NEUTRAL, AFTER 15-30 SECONDS OR DOWNSHIFTED TO 2ND GEAR, THE VEHICLE R…
Read full complaint
WHILE DRIVING AT HIGHWAY SPEEDS ENGINE LOST POWER, NEARLY RESULTING IN A REAR END COLLISION. DEALER WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK THE TACHOMETER WOULD SUDDENLY RACE UP TO 7000 AND THE WHEELS LOST POWER. THE VEHICLE FELT AS IF IT WERE IN NEUTRAL, AFTER 15-30 SECONDS OR DOWNSHIFTED TO 2ND GEAR, THE VEHICLE RE-ENGAGES AND THE WHEEL POWER WAS RESTORED. THIS WAS AN INTERMITTENT PROBLEM. FORD WAS UNABLE TO DIAGNOSE THE PROBLEM. A FLIGHT RECORDER WAS INSTALLED TWICE. THE ENGINEERS REVEALED THAT THE PROBLEM COULD HAVE BEEN RELATED TO THE SPEED SENSORS AND INPUT SHAFT SENSORS. THE CONSUMER'S HUSBAND EXPERIENCED A COMPLETE LOSS OF POWER. THE VEHICLE WAS UNABLE TO BE MOVED BECAUSE THERE WAS NO POWER STEERING. THE LOSS LASTED 10 SECONDS, THE GEAR WAS PLACED INTO 2ND GEAR, THEN BACK TO DRIVE AND THE POWER STEERING WAS BACK ACTIVE. THIS PROBLEM RETURNED TWO MORE TIMES. ON ONE OF THE INCIDENCES, THE TACHOMETER HAD GONE OVER 7 THEN DROPPED. THE TRANSMISSION SLIPPED INTERMITTENTLY. *SC
WHILE DRIVING 35 MPH VEHICLE STALLED. CONSUMER MANAGED TO PULL OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT IT DID NOT RESOLVE THE PROBLEM. *AK
INTERMITTENTLY AT ANY SPEED, THE VEHICLE WILL SHIFT OUT OF DRIVE AND INTO NEUTRAL THEN BACK INTO DRIVE. THE VEHICLE HAS BEEN TO THE DEALER SEVEN TIMES FOR THIS PROBLEM. THE DEALER WILL NOT DO ANYTHING BECAUSE THEY CAN NOT DUPLICATE THE PROBLEM. THE MANUFACTURER IS AWARE OF THE PROBLEM.
WHILE DRIVING AT ANY SPEED VEHICLE HESITATED AND TOOK A DIP FORWARD AND DOWN TO THE GROUND. THEN, IT ACCELERATED AS IF NOTHING HAPPENED. CONSUMER'S DAUGHTER EXPERIENCED THE SAME THING WHILE DRIVING AND LOST CONTROL OF THE VEHICLE WHICH LANDED IN A DITCH. CONSUMER'S DAUGHTER SUSTAINED BACK INJURIES. CONSUMER WORE SEAT BELTS.…
Read full complaint
WHILE DRIVING AT ANY SPEED VEHICLE HESITATED AND TOOK A DIP FORWARD AND DOWN TO THE GROUND. THEN, IT ACCELERATED AS IF NOTHING HAPPENED. CONSUMER'S DAUGHTER EXPERIENCED THE SAME THING WHILE DRIVING AND LOST CONTROL OF THE VEHICLE WHICH LANDED IN A DITCH. CONSUMER'S DAUGHTER SUSTAINED BACK INJURIES. CONSUMER WORE SEAT BELTS. HOWEVER, AIR BAGS FAILED TO DEPLOY. *AK
AT ANY SPEED ENGINE CHECK LIGHT CAME ON , AND THEN, ENGINE RUMBLED AND STALLED.VEHICLE STALLED TEN TIMES. A RECALL WAS ISSUED, BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available