IllustrationEXCESSIVE WEAR ON THE FRONT BRAKE PADS AND ROTORS,ONLY 16,900 MILES ON CAR
2001 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2001 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1350–25K
25825–50K
20050–75K
14775–100K
157100–150K
56150K+
953 reports with mileage · 808 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 496 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 243 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
172 crash reports47 fire reports110 injury reports
What owners actually said
1,761 reportsMY 2001 FORD FOCUS EXHIBITS ALL THE SYMPTOMS OF THE FAULTY FUEL MODULE. HOWEVER, WHEN I CONTACTED FORD, THEY SAID THAT MY VIN WAS NOT ONE OF THE VEHICLES AFFECTED. I'D LIKE THE FUEL MODULE REPLACED, AS IT IS FAULTY. CAN YOU PLEASE HELP ME?*AK
I JUST BOUGHT A USED 2001 FORD FOCUS AND HAD TO PAY TO REPLACE THE IGNITION CYLINDER. THE CAR ONLY HAS 40,000 MILES AND I THINK THAT A PART THIS EXPENSIVE SHOULD LAST LONGER. I SEARCHED FOR OTHER PEOPLE WITH THE SAME PROBLEM AND FOUND MANY FRUSTRATED FOCUS OWNERS WHO ARE HAVING THE SAME PROBLEM. I THINK THIS PART SHOULD HAVE A L…
Read full complaint
I JUST BOUGHT A USED 2001 FORD FOCUS AND HAD TO PAY TO REPLACE THE IGNITION CYLINDER. THE CAR ONLY HAS 40,000 MILES AND I THINK THAT A PART THIS EXPENSIVE SHOULD LAST LONGER. I SEARCHED FOR OTHER PEOPLE WITH THE SAME PROBLEM AND FOUND MANY FRUSTRATED FOCUS OWNERS WHO ARE HAVING THE SAME PROBLEM. I THINK THIS PART SHOULD HAVE A LONGER WARRANTY. *AK
MY 2001 FORD FOCUS STARTED HAVING PROBLEMS WHEN I WOULD PUT MY KEY IN THE IGNITION AND IT WOULDN'T TURN , IT WOULD TAKE SEVERAL MINUTES FOR MY CAR TO TURN ON. EVENTUALLY AFTER SEVERAL ATTEMPTS TO TURN THE KEY IT NEVER DID, AND I WAS FORCED TO TOW MY CAR HOME. I WILL HAVE TO PAY OUT OF MY OWN POCKET TO TOW IT TO THE DEALERS AND…
Read full complaint
MY 2001 FORD FOCUS STARTED HAVING PROBLEMS WHEN I WOULD PUT MY KEY IN THE IGNITION AND IT WOULDN'T TURN , IT WOULD TAKE SEVERAL MINUTES FOR MY CAR TO TURN ON. EVENTUALLY AFTER SEVERAL ATTEMPTS TO TURN THE KEY IT NEVER DID, AND I WAS FORCED TO TOW MY CAR HOME. I WILL HAVE TO PAY OUT OF MY OWN POCKET TO TOW IT TO THE DEALERS AND THEY SAID THAT THE COST TO FIX WILL RANGE FROM $350-600. I AM A SINGLE MOTHER WITH TWO KIDS ON A LIMITED INCOME, THERE IS NO WAY I WILL BE ABLE TO AFFORD THIS.*AK
MY REAR WHEEL BEARINGS FAILED TWICE. THE FIRST TIME THEY FAILED AT 8,000 MILES AND WERE REPALCED BY THE DEALER UNDER A RECALL PRGRAM. THE SECOND TIME, WHICH IS THE BASIS FOR THIS COMPLAINT, THEY FAILED AT 43,000 MILES (THIS IS ONLY 35,000 MILES LATER). THE DEALER CHARGED ME TO HAVE THEM REPLACED DESPITE THE FACT THAT HE CONCE…
Read full complaint
MY REAR WHEEL BEARINGS FAILED TWICE. THE FIRST TIME THEY FAILED AT 8,000 MILES AND WERE REPALCED BY THE DEALER UNDER A RECALL PRGRAM. THE SECOND TIME, WHICH IS THE BASIS FOR THIS COMPLAINT, THEY FAILED AT 43,000 MILES (THIS IS ONLY 35,000 MILES LATER). THE DEALER CHARGED ME TO HAVE THEM REPLACED DESPITE THE FACT THAT HE CONCEDED THAT IT WAS PREMATURE BEARING WEAR. BOTH TIMES I HEARD A LOUD GRINDING NOISE COMEING FROM MY REAR WHEELS.
WHILE DRIVING AT ANY SPEED, THE VEHICLE INTERMITTENTLY STALLED. THE DEALER INFORMED THE CONSUMER THAT THE FUEL PUMP MODULE WAS DEFECTIVE. ALSO THE BRAKE ROTORS PADS, AND CALIPERS NEEDED TO BE REPLACED. *AK THE ENGINE LIGHT HAD COME ON DUE TO THE FUEL PUMP BEING INOPERATIVE. FORD MADE THE REPAIRS BUT FAILED TO REPLACE THE O…
Read full complaint
WHILE DRIVING AT ANY SPEED, THE VEHICLE INTERMITTENTLY STALLED. THE DEALER INFORMED THE CONSUMER THAT THE FUEL PUMP MODULE WAS DEFECTIVE. ALSO THE BRAKE ROTORS PADS, AND CALIPERS NEEDED TO BE REPLACED. *AK THE ENGINE LIGHT HAD COME ON DUE TO THE FUEL PUMP BEING INOPERATIVE. FORD MADE THE REPAIRS BUT FAILED TO REPLACE THE O RINGS WHICH CAUSED THE PUMP TO FAIL AGAIN. FORD HAD FUEL PUMP RECALL #03NO1 BUT THE SAME EXACT PART WENT BAD. THE ROTORS WERE WARPED DUE TO THE CALIPERS SEEPING FLUID, BINDING THE PISTONS. *SC *JB
FRONT BRAKES AND ROTORS; I HAD 21K+ MILES ON MY 2001 FORD FOCUS, THE CAR WOULD VIBRATE WHEN BRAKING, AND SPECIALLY DOWNHILL. I WAS INFORMED BY THE DEALER THAT I NEEDED NEW BRAKE PADS, AND "MOST LIKELY ROTORS". THAT'S RIDICULOUS FOR SUCH LOW MILES. FEARING FOR MY FAMILY SAFETY I DID REPLACE THE PADS AND ROTORS, BUT NOT WITH THE …
Read full complaint
FRONT BRAKES AND ROTORS; I HAD 21K+ MILES ON MY 2001 FORD FOCUS, THE CAR WOULD VIBRATE WHEN BRAKING, AND SPECIALLY DOWNHILL. I WAS INFORMED BY THE DEALER THAT I NEEDED NEW BRAKE PADS, AND "MOST LIKELY ROTORS". THAT'S RIDICULOUS FOR SUCH LOW MILES. FEARING FOR MY FAMILY SAFETY I DID REPLACE THE PADS AND ROTORS, BUT NOT WITH THE DEALER.*AK
KEY WILL NOT TURN. CALLED DEALER AND IT APPEARS THIS IS A WIDESPREAD PROBLEM AFFECTING MANY FORD FOCUS'. AFTER SEARCHING THE WEB I SEE THAT IS TRUE. DEALER WANTED $325 + TOW TO REPLACE IGNITION. NOT SURE IF THAT INCLUDED REKEYING. IN ANY EVENT, I FOUND A LOCKSMITH WHO WILL COME TO MY RESIDENCE AND REPLACE THE IGNITION WITH A BET…
Read full complaint
KEY WILL NOT TURN. CALLED DEALER AND IT APPEARS THIS IS A WIDESPREAD PROBLEM AFFECTING MANY FORD FOCUS'. AFTER SEARCHING THE WEB I SEE THAT IS TRUE. DEALER WANTED $325 + TOW TO REPLACE IGNITION. NOT SURE IF THAT INCLUDED REKEYING. IN ANY EVENT, I FOUND A LOCKSMITH WHO WILL COME TO MY RESIDENCE AND REPLACE THE IGNITION WITH A BETTER ONE THAN FORD IS OFFERING FOR SUBSTANTIALLY LESS MONEY.*AK
WHILE DRIVING MY 2001 FORD FOCUS OVER A 6 LANE SUSPENSION BRIDGE FROM PA TO NJ, MY CAR STARTED TO ACT AS IF IT WAS RUNNING OUT OF GAS. CAR SLOWED WITHOUT WARNING THEN DIED,THIS HAPPENED AS A 18 WHEEL TRUCK WAS BARING DOWN ON ME AT A HIGH RATE OF SPEED. SITTING AS A DEAD DUCK THE TRUCK BARELY MADE IT AROUND ME NEARLY CAUSING A MU…
Read full complaint
WHILE DRIVING MY 2001 FORD FOCUS OVER A 6 LANE SUSPENSION BRIDGE FROM PA TO NJ, MY CAR STARTED TO ACT AS IF IT WAS RUNNING OUT OF GAS. CAR SLOWED WITHOUT WARNING THEN DIED,THIS HAPPENED AS A 18 WHEEL TRUCK WAS BARING DOWN ON ME AT A HIGH RATE OF SPEED. SITTING AS A DEAD DUCK THE TRUCK BARELY MADE IT AROUND ME NEARLY CAUSING A MULTI CAR ACCIDENT. AFTER RESTARTING THE CAR (BARELY KEEPING IT RUNNING) I SLOWLY MADE IT TO THE TOP AS IT DIED AGAIN , I GLIDED DOWN THE BRIDGE IN NEUTRAL, I PULLED OVER AT THE END OF THE BRIDGE AND RESTARTED THE CAR AGAIN, THIS HAPPENED 3 TIMES ON THE HIGHWAY, EACH TIME HAVING TO PULL OVER AND RESTART THE CAR.. I HAVE HAD THIS PROBLEM ABOUT A YEAR AGO AND HAD TO FIGHT FORD TO REPLACE THE FUEL PUMP, WHICH SEEMED TO SOLVE THE PROBLEM UNTIL NOW.. THIS TIME I ALMOST GOT KILLED.. THERE IS NO WARNING WHEN THIS HAPPENS! PLEASE DO SOMETHING ABOUT THIS BEFORE SOMEONE DIES. *JB
AS I WAS DRIVING MY 2001 FORD FOCUS ZX3, MY TAIL END STARTED TO SWAY OUT FROM UNDERNEATH ME. THEN I NOTICED A LOUD NOISE FROM THE REAR OF MY VEHICLE. I THEN PULLED OVER TO INSPECT THE SITUATION AND NOTICED MY WHEEL BEARING WAS NOT SECURED PROPERLY. THEN I WENT ONLINE AND RESEARCHED FORD FOCUS RECALLS AND DISCOVERED THERE TO BE O…
Read full complaint
AS I WAS DRIVING MY 2001 FORD FOCUS ZX3, MY TAIL END STARTED TO SWAY OUT FROM UNDERNEATH ME. THEN I NOTICED A LOUD NOISE FROM THE REAR OF MY VEHICLE. I THEN PULLED OVER TO INSPECT THE SITUATION AND NOTICED MY WHEEL BEARING WAS NOT SECURED PROPERLY. THEN I WENT ONLINE AND RESEARCHED FORD FOCUS RECALLS AND DISCOVERED THERE TO BE ONE ON THIS ISSUE. I ATTEMPTED TO CONTACT PAT & DAN'S DELBALSO FORD DEALERSHIP IN KINGSTON, PA. THEY REFERRED ME TO FORD'S SERVICE DEPARTMENT. AFTER SPEAKING TO FORD, I MADE A RETURN CALL TO DELBALSO FORD AND THEY SCHEDULED AN APPOINTMENT FOR ME. THEY MADE ME WAIT ABOUT A WEEK FOR THE APPOINTMENT AND THEY MORNING OF, I MADE A CALL FOR THEM TO GET MY CAR WHEN THE SERVICE MANAGER TOLD ME THAT THEY WOULD NOT HELP ME. AS A RESULT I HAVE BEEN UNABLE TO GET TO COLLEGE WHICH IS ABOUT 20 TO 30 MILES AWAY FROM MY HOME. ADDITIONALLY, I HAVE MISSED WORK BECAUSE OF THIS AS WELL. I MADE MULTIPLE ATTEMPTS TO HAVE MY PROBLEM RESOLVED BY CONTACTING THE FORD MANUFACTURERS' SERVICE DEPARTMENT. THEY TOLD ME THAT THEIR RECALL HAD BEEN CANCELLED. THEY WENT ON TO SAY THAT THEY WERE JUST BEING "NICE" AND ASSISTING THEIR CUSTOMERS BY PERFORMING THE "WARRANTY PROGRAM" AND THAT THE ORIGINAL OWNER OF THE CAR RECIEVED ACKNOWLEDGEMENT OF THE PROGRAM. I WAS UNDER THE IMPRESSION THAT WHEN OWNERSHIP CHANGES AND ALL WARRANTY INFORMATION IS SENT TO THE MANUFACTURER, THE MANUFACTURER WAS LIABLE FOR ALL RECALL INFORMATION TO BE SENT OUT. I WAS NEVER MAILED NOR BEEN CONTACTED ABOUT THIS WARRANTY PROGRAM SINCE I HAVE OWNED MY VEHICLE. I FEEL THAT I HAVE BEEN WRONGED AND SHOULD NOT HAVE TO SUFFER BECAUSE OF IT. THE PEOPLE AT FORD MOTOR CO. HAVE BEEN VERY RUDE AND OBNOXIOUS OVER THE FACT THAT THEY ARE "EXEMPT" FROM ASSISTING ME WITH MY PROBLEMS. I FEEL SINCE I WAS NEVER INFORMED OF THE PROGRAM THAT THEY SHOULD BE MANDATED TO HELP ME. WHEN I WAS DRIVING I COULD HAVE BEEN SEVERLY INJURED BECAUSE OF THEIR PRODUCT FAILURE THAT THEY KNEW OF AND COULD HAVE PREVENTED.*AK
Official recalls
705V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
03V482000 · Fuel System, Gasoline
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
02V289000 · Steering:linkages
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V108000 · Seats:front Assembly:recliner
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V418000 · Seats:front Assembly:recliner
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.