IllustrationWHILE DRIVING MY FORD FOCUS, THE RIGHT FRONT COIL SPRING PUSHED ITSELF PAST THE LOWER STOP ABOVE THE STRUT AND RESTED THERE. HAD IT GONE FURTHER, THE FRONT END WOULD HAVE COLLAPSED.*AK
2001 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2001 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1350–25K
25825–50K
20050–75K
14775–100K
157100–150K
56150K+
953 reports with mileage · 808 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 496 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 243 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
172 crash reports47 fire reports110 injury reports
What owners actually said
1,761 reportsELECTRICAL SYSTEM FAILURE. PROBLEMS INCLUDE DASH BOARD GAUGES AND LIGHTS 'RESETING' THEMSELVES AND LIGHTS FLICKERING ON AND OFF. VEHICLE NOW WILL NOT START, POWER TO THE ACCERSSORIES AND RADIO IS FINE, FUSES HAVE BEEN TESTED AND NONE ARE BLOWN. CAR EXPERIENCES SOME TYPE OF ELECTRICAL SYSTEM STUTER WHEN AN ATTEMPT TO START THE E…
Read full complaint
ELECTRICAL SYSTEM FAILURE. PROBLEMS INCLUDE DASH BOARD GAUGES AND LIGHTS 'RESETING' THEMSELVES AND LIGHTS FLICKERING ON AND OFF. VEHICLE NOW WILL NOT START, POWER TO THE ACCERSSORIES AND RADIO IS FINE, FUSES HAVE BEEN TESTED AND NONE ARE BLOWN. CAR EXPERIENCES SOME TYPE OF ELECTRICAL SYSTEM STUTER WHEN AN ATTEMPT TO START THE ENGINE IS MADE.
GAUGES IN DASH ALONG WITH THE REST OF THE ELECTRICAL SYSTEM CUTS IN & OUT WHILE DRIVING. NOW, CAR WILL NOT START BUT DISPLAYS SAME PROBLEMS WHILE ATTEMPTING TO START VEHICLE.*AK
I OWN A 2001 FORD FOCUS W/ 45,000 MILES. I WAS LEFT STRANDED MEMORIAL DAY WEEKEND 2004 WHEN THE IGNITION IN MY AUTOMOBILE LOCKED UP. I PLACE THE KEY IN THE IGNITION (WITH SOME DIFFICULTY) AND I AM UNABLE TO TURN THE KEY. I HAVE RESEARCHED THIS PROBLEM AND IT APPEARS THAT MANY OTHER PEOPLE HAVE HAD THIS EXPERIENCE W/ 2000/2001 FO…
Read full complaint
I OWN A 2001 FORD FOCUS W/ 45,000 MILES. I WAS LEFT STRANDED MEMORIAL DAY WEEKEND 2004 WHEN THE IGNITION IN MY AUTOMOBILE LOCKED UP. I PLACE THE KEY IN THE IGNITION (WITH SOME DIFFICULTY) AND I AM UNABLE TO TURN THE KEY. I HAVE RESEARCHED THIS PROBLEM AND IT APPEARS THAT MANY OTHER PEOPLE HAVE HAD THIS EXPERIENCE W/ 2000/2001 FORD FOCUS. MY CAR REMAINS IMMOBILE AND I AM UNABLE TO ADDRESS THE PROBLEM UNTIL AFTER THE HOLIDAY WEEKEND. FROM WHAT I HAVE READ, I CAN ANTICIPATE $350-500 TO REPLACE IGNITION. *LA
SINCE AUGUST 2003, I HAVE EXPERIENCED IGNITION LOCK FIVE (5) TIMES WITH MY 2001 FORD FOCUS. FIRST TWO "REPAIRS" (8/03 AND 12/03) WERE COVERED UNDER WARRANTY, AND SUPPOSEDLY REPLACED THE IGNITION CYLINDER. I NEVER SAW THE OLD PART. HOWEVER, WHEN VEHICLE WAS TAKEN IN FOR SUBSEQUENT REPAIR TO THE SAME PROBLEM (2/04), I WAS TOLD …
Read full complaint
SINCE AUGUST 2003, I HAVE EXPERIENCED IGNITION LOCK FIVE (5) TIMES WITH MY 2001 FORD FOCUS. FIRST TWO "REPAIRS" (8/03 AND 12/03) WERE COVERED UNDER WARRANTY, AND SUPPOSEDLY REPLACED THE IGNITION CYLINDER. I NEVER SAW THE OLD PART. HOWEVER, WHEN VEHICLE WAS TAKEN IN FOR SUBSEQUENT REPAIR TO THE SAME PROBLEM (2/04), I WAS TOLD THAT A PERMANENT REPAIR WOULD REQUIRE REPLACEMENT OF THE STEERING COLUMN AND WOULD COST ME $500+, BUT THAT THE IGNITION CYLINDER COULD BE REPLACED UNDER WARRANTY. I GOT NO RESPONSE TO MY INQUIRY ABOUT WHY NO PERMANENT FIX HAD BEEN MADE WHILE THE VEHICLE WAS UNDER WARRANTY. I DIRECTED THEM TO PERFORM THE REPAIR I COULD AFFORD - THE CYLINDER. I NEVER SAW THE OLD PART THAT TIME EITHER. THE CAR WAS RE-KEYED AS WELL. THE IGNITION LOCKED AGAIN ON 5/20/04, AND AFTER I CONTACTED FORD MOTOR COMPANY, THE SERVICE DEPARTMENT NOTIFIED ME THAT THEY HAD REPLACED THE TUMBLERS AND RE-KEYED THE VEHICLE AT NO CHARGE. THEY ALSO INFORMED ME THAT ANY SUBSEQUENT REPAIRS WOULD BE AT MY EXPENSE, AS THEY WOULD NOT BE COVERED BY WARRANTY. THE IGNITION LOCKED AGAIN ON 5/25/04. *LA THE INITIAL REPAIR TO THIS PROBLEM WAS MADE UNDER WARRANTY. IT WAS NOT A PERMANENT REPAIR, ALTHOUGH THERE WERE SERVICE BULLETINS AND A SIGNIFICANT RECORD OF COMPLAINTS ISSUED ON THIS SAME PROBLEM FROM EARLY 2001. AT NO POINT HAVE I RECEIVED A SATISFACTORY ANSWER, FROM THE DEALER OR FROM FORD CUSTOMER RELATIONS, TO WHY THE PERMANENT REPAIR WAS NOT PERFORMED IN AUGUST 2003. I FEEL THAT THE DEALER MADE NO ATTEMPT TO EFFECT A REPAIR ON THIS PROBLEM WHILE IT WAS WARRANTED, BUT STALLED WITH TEMPORARY FIXES UNTIL THE MILEAGE/AGE OF THE VEHICLE WOULD REQUIRE ME TO PAY, BOTH FOR PARTS AND LABOR. AS IT NOW STANDS, I WILL BE TAKING MY VEHICLE TO ANOTHER DEALER FOR THE REPAIR AND A SECOND OPINION, AND HOPE I CAN GET MY MONEY BACK. I REFUSE TO PAY EVEN TEN CENTS FOR A REPAIR BY A SERVICE DEPARTMENT THAT HAS ALREADY FAILED TO MAKE THE SAME REPAIR FOUR TIMES!
I PURCHASED MY 2001 FORD FOCUS IN OCTOBER 2001. IN APRIL 2003, I HAD TO GET THE FRONT BRAKES, PADS, SHOES AND ROTORS REPLACED. THIS IS AFTER I HAD ALWAYS TAKEN MY CAR IN FOR SCHEDULED MAINTENANCE. I WAS TOLD THAT NONE OF THIS WAS COVERED. I WAS OUT OF OVER $400. THE SAME THING HAS HAPPENED AGAIN 13 MONTHS LATER. EVERYTHING …
Read full complaint
I PURCHASED MY 2001 FORD FOCUS IN OCTOBER 2001. IN APRIL 2003, I HAD TO GET THE FRONT BRAKES, PADS, SHOES AND ROTORS REPLACED. THIS IS AFTER I HAD ALWAYS TAKEN MY CAR IN FOR SCHEDULED MAINTENANCE. I WAS TOLD THAT NONE OF THIS WAS COVERED. I WAS OUT OF OVER $400. THE SAME THING HAS HAPPENED AGAIN 13 MONTHS LATER. EVERYTHING NEEDS TO BE REPLACED. THE MAJORITY OF MY DRIVING IS HIGHWAY AND I CAN'T GET AN EXPLANATION FROM FORD. I PURCHASED A LEMON. THE SWITCH ALSO BROKE ON MY TURN SIGNALS. IT WOULD NOT AUTOMATICALLY TURN OFF. THIS HAPPEN IN FEB. 2003. AGAIN, A YEAR LATER, THE SAME THING HAS HAPPENED. SOMEONE NEEDS TO LOOK INTO THIS. *MR
WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING IN THE MIDDLE OF A BUSY INTERSECTION. THE DEALER STATED THE FUEL PUMP MALFUNCTIONED AND WAS NOT SENDING FUEL TO THE ENGINE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
VEHICLE SHAKES AND DIES ERRATICALLY. TOOK TO DEALER FOR FUEL PUMP ASSEMBLY RECALL. REPAIR HAS NOT FIXED. DRIVING ON HIGHWAY, STEP ON GAS ALL THE WAY AND CAR DECELERATES AND LOSES SPEED. INTERMITTENTLY DIES WHEN THIS HAPPENS. ALSO SHAKES VIOLENTLY WHILE STOPPED LEADING TO STALLING. ALL OF THE ABOVE HAVE HAPPENED ON SEVERAL OCCASI…
Read full complaint
VEHICLE SHAKES AND DIES ERRATICALLY. TOOK TO DEALER FOR FUEL PUMP ASSEMBLY RECALL. REPAIR HAS NOT FIXED. DRIVING ON HIGHWAY, STEP ON GAS ALL THE WAY AND CAR DECELERATES AND LOSES SPEED. INTERMITTENTLY DIES WHEN THIS HAPPENS. ALSO SHAKES VIOLENTLY WHILE STOPPED LEADING TO STALLING. ALL OF THE ABOVE HAVE HAPPENED ON SEVERAL OCCASIONS IN THE PAST COUPLE OF MONTHS. I THOUGHT THE RECALL FOR FUEL PUMP ASSEMBLY WOULD FIX IT, BUT IT HAS NOT. GETTING PROGRESSIVELY WORSE. *NM
WHEN THE VEHICLE WAS PARKED AND RUNNING, THE REAR WINDOW FELL THROUGH THE VEHICLE. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
CONSUMER COMPLAINED ABOUT STEERING PROBLEMS. WHEN HE TOOK VEHICLE TO THE DEALER FOR REPAIRS CONSUMER WAS TOLD THAT IT WAS IGNITION CYLINDER. CONSUMER COULD NOT MAKE ANY TURNS, STEERING LOCKED, AND COULD NOT GET KEY OUT OF IGNITION CYLINDER. CONSUMER TOOK VEHICLE TO THE DEALER TWICE IN 8 MONTHS, BUT PROBLEM RECURRED. *…
Read full complaint
CONSUMER COMPLAINED ABOUT STEERING PROBLEMS. WHEN HE TOOK VEHICLE TO THE DEALER FOR REPAIRS CONSUMER WAS TOLD THAT IT WAS IGNITION CYLINDER. CONSUMER COULD NOT MAKE ANY TURNS, STEERING LOCKED, AND COULD NOT GET KEY OUT OF IGNITION CYLINDER. CONSUMER TOOK VEHICLE TO THE DEALER TWICE IN 8 MONTHS, BUT PROBLEM RECURRED. *AK
Official recalls
705V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
03V482000 · Fuel System, Gasoline
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
02V289000 · Steering:linkages
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V108000 · Seats:front Assembly:recliner
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V418000 · Seats:front Assembly:recliner
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.