NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reports52,700 miles · Aug 26, 2004
Latches/locks/linkages
AFTER OPENING THE RIGHT REAR DOOR AT A STORE I DROVE OUT OF THE PARKING LOT BEFORE THE DOOR CAME OPEN AND THE DOOR LIGHT CAME ON. AFTER PARKING AGAIN I WAS NOT ABLE TO CLOSE THE DOOR, THE LATCH SEEMED TO BE STUCK IN THE OPEN POSITION. OPENING THE HANDLE, MOVING THE LATCH FORK BACK AND FORTH DID NOT ALLOW THE DOOR TO CLOSE. AF…
Read full complaint
AFTER OPENING THE RIGHT REAR DOOR AT A STORE I DROVE OUT OF THE PARKING LOT BEFORE THE DOOR CAME OPEN AND THE DOOR LIGHT CAME ON. AFTER PARKING AGAIN I WAS NOT ABLE TO CLOSE THE DOOR, THE LATCH SEEMED TO BE STUCK IN THE OPEN POSITION. OPENING THE HANDLE, MOVING THE LATCH FORK BACK AND FORTH DID NOT ALLOW THE DOOR TO CLOSE. AFTER USING A SCREW DRIVER TO PRY THE LATCH STAMPING IT RETURNED AND LATCHED THE DOOR CLOSED. I HAVE NOT OPENED THE DOOR SINCE.*AK
NHTSA ODI #10088605
70,000 miles · Aug 25, 2004
Latches/locks/linkages
WHILE DRIVING RIGHT REAR PASSENGER DOOR OPENED. THE LATCH RUSTED FROM RAIN COMING IN. *AK
NHTSA ODI #10089692
65,000 miles · Aug 25, 2004
Electrical System
I BOUGHT THE CAR USED THE PREVIOUS OWNER TOLD ME HE HAD THE IGNITION CYLINDER REPLACED. WELL ITS A COUPLE YEARS LATER NOW AND MY IGNITIONS CYLINDER IS BAD TOO. MY KEY BARELY GOES IN AND IT DOES NOT TURN THE LOCK, AND WILL NOT START MY CAR. THIS IS A KNOWN PROBLEM WITH FORD AND THEY REFUSE TO ISSUE A RECALL OR EVEN AN EXTENDED W…
Read full complaint
I BOUGHT THE CAR USED THE PREVIOUS OWNER TOLD ME HE HAD THE IGNITION CYLINDER REPLACED. WELL ITS A COUPLE YEARS LATER NOW AND MY IGNITIONS CYLINDER IS BAD TOO. MY KEY BARELY GOES IN AND IT DOES NOT TURN THE LOCK, AND WILL NOT START MY CAR. THIS IS A KNOWN PROBLEM WITH FORD AND THEY REFUSE TO ISSUE A RECALL OR EVEN AN EXTENDED WARRANTEE ON IT. I HAVE RESEARCHED AND IT SEEMS THAT EVERY FOCUS 2000-2002 THAT IS AROUND 3 YEARS OLD HAS THIS PROBLEM. MY CAR IS CURRNTLY PARKED IN A WENDYS PARKING LOT WHERE IT HAPPENED. I DONT HAVE A LOT OF MONEY AND CANNOT AFFORD THE ASSININE AMOUNT OF MONEY FORD WANTS TO FIX THIS PROBLEM (ABOUT 300$) AND IT SEEMS THEY DONT WANT ANYONE FIXING IT THEMSELVES EITHER, THE IGNITION CLYINDERS DO NOT COME WITH KEYS AND YOU HAVE TO BUT THE KEYS AND HAVE THEM CUT TO YOUR KEY AND THEN HAVE THE IGNITION CYLINDER BORED OUT TO THE SHAPE OF THE KEY (THIS IS AS BACKWARDS AS IVE EVER SEEN) SO NO ONE IS CAPABLE OF JUST BUYING A NEW CYLINDER AND FIXING IT THEMSELVES!! SO BASICALLY THERE ARE ALOT OF PO'D PEOPLE THAT FORD IS REFUSING TO HELP, AND IM ADDING MY NAME TO THE LIST THANK YOU. *AK
NHTSA ODI #10088559
Mileage unknown · Aug 24, 2004
Visibility
WHILE DRIVING IN INCLEMENT WEATHER WINDSHIELD WIPERS FAILED TO COME ON. DEALER WAS AWARE OF THIS PROBLEM WHICH WAS INTERMITTENT. *AK
NHTSA ODI #10089648
Mileage unknown · Aug 24, 2004
Engine And Engine Cooling
CONSUMER STATED THAT VEHICLE SURGED/HESITATED AND STALLED. SHE TOOK THE VEHICLE TO THE DEALER, AND THEY DID NOT SEE ANY PROBLEM. CONSUMER RECEIVED A RECALL NOTICE, AND TRIED TO GET AN APPOINTMENT TO GET THE VEHICLE REPAIRED, BUT WAS PUT OFF. DEALER STATED THAT THE RECALL HAD NOTHING TO DO WITH THE PROBLEM SHE WAS HAVING. CON…
Read full complaint
CONSUMER STATED THAT VEHICLE SURGED/HESITATED AND STALLED. SHE TOOK THE VEHICLE TO THE DEALER, AND THEY DID NOT SEE ANY PROBLEM. CONSUMER RECEIVED A RECALL NOTICE, AND TRIED TO GET AN APPOINTMENT TO GET THE VEHICLE REPAIRED, BUT WAS PUT OFF. DEALER STATED THAT THE RECALL HAD NOTHING TO DO WITH THE PROBLEM SHE WAS HAVING. CONSUMER LATER TOOK THE VEHICLE TO A LOCAL MECHANIC BECAUSE ENGINE" CHECK LIGHT CAME ON, AND SHE WAS TOLD THAT THE EGR SENSOR NEEDED TO BE REPLACED. *AK
NHTSA ODI #10089641
111,500 miles · Aug 24, 2004
Fuel System, Gasoline
1. WITHOUT CRASH OR OTHER DAMAGE, FUEL BEGAN TO LEAK OUT OF THE TOP OF THE GAS TANK AND DOWN THE TANK ONTO THE UNDERCARRIAGE. OCCURS ONLY WHEN IGNITION IS ON AND VEHICLE IS DRIVEN. 2. FAILURE APPEARS TO BE A SEAL ON SIPHON/FUEL LINE GOING INTO TOP OF TANK. CONSEQUENCES ARE POTENTIAL SERIOUS FIRE/EXPLOSION HAZARD, UNPREDICTABLE …
Read full complaint
1. WITHOUT CRASH OR OTHER DAMAGE, FUEL BEGAN TO LEAK OUT OF THE TOP OF THE GAS TANK AND DOWN THE TANK ONTO THE UNDERCARRIAGE. OCCURS ONLY WHEN IGNITION IS ON AND VEHICLE IS DRIVEN. 2. FAILURE APPEARS TO BE A SEAL ON SIPHON/FUEL LINE GOING INTO TOP OF TANK. CONSEQUENCES ARE POTENTIAL SERIOUS FIRE/EXPLOSION HAZARD, UNPREDICTABLE LOSS OF POWER WHEN DRIVING. AWAITING SERVICE ON THE VEHICLE.*AK
NHTSA ODI #10088490
Mileage unknown · Aug 19, 2004
Power Train
WHILE DRIVING, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART IT, BUT WAS UNABLE TO DO SO. THE CHECK ENGINE LIGHT APPEARED ON THE VEHICLE AND REMAINED ON. THE CONSUMER ALSO NOTICED A LOUD CLICKING AND BANGING NOISE WAS HEARD COMING FROM THE FRONT. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHA…
Read full complaint
WHILE DRIVING, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART IT, BUT WAS UNABLE TO DO SO. THE CHECK ENGINE LIGHT APPEARED ON THE VEHICLE AND REMAINED ON. THE CONSUMER ALSO NOTICED A LOUD CLICKING AND BANGING NOISE WAS HEARD COMING FROM THE FRONT. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE SHIFT SOLENOID SWITCH NEEDED TO BE REPLACED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10089322
37,700 miles · Aug 11, 2004
Service Brakes, Hydraulic
FRONT BRAKE PADS AND ROTORS FOR MY 2001 FORD FOCUS WAGON NEED TO BE REPLACED AFTER JUST 37,700 MILES. THE BRAKES ON THE CAR HAVE SQUEALED ALMOST SINCE DAY ONE (WE PURCHASED IT NEW IN AUGUST 2001), HAVE HAD IT IN TO THE DEALER FOR CHECKING AND REPAIRS NUMEROUS TIMES (MCMAHON FORD, NORWALK, CT) AND THEY SAID IT'S NORMAL FOR BRAKES…
Read full complaint
FRONT BRAKE PADS AND ROTORS FOR MY 2001 FORD FOCUS WAGON NEED TO BE REPLACED AFTER JUST 37,700 MILES. THE BRAKES ON THE CAR HAVE SQUEALED ALMOST SINCE DAY ONE (WE PURCHASED IT NEW IN AUGUST 2001), HAVE HAD IT IN TO THE DEALER FOR CHECKING AND REPAIRS NUMEROUS TIMES (MCMAHON FORD, NORWALK, CT) AND THEY SAID IT'S NORMAL FOR BRAKES TO SQUEAL, OR THAT THEY CAN'T REPLICATE THE PROBLEM, OR THAT IT'S DUE TO DUST, OR DENIED THAT THEY SQUEALED AT ALL. THE REPAIR PLACE SAYS THE ROTORS CANNOT BE TURNED AND THAT THE BRAKES WERE MADE TO BARELY MINIMUM STANDARDS. THEY ARE RETURNING THE WORN PARTS. THERE WAS NEVER ANY INDICATION THAT THE BRAKES WERE FAILING (FOR ONE THING, BECAUSE OF THE PERMANENT SQUEAL) AND THE DEALERSHIP DID NOT FIND THIS PROBLEM THE LAST TIME WE HAD IT IN FOR A CHECKUP BEFORE IT WENT OUT OF WARRANTY, WHICH IS OF THE MOST CONCERN TO ME. *JB
NHTSA ODI #10086626
Mileage unknown · Aug 10, 2004
Electrical System
CONSUMER PLACED THE KEY IN THE IGNITION AND IT WAS LOCKED. IGNITION WOULD NOT ACCEPT THE KEY. SHE CALLED THE LOCK SMITH, AND WAS TOLD THAT THEY HAVE AT LEAST ONE OF THIS TYPE OF PROBLEM WITH THE FOCUS A WEEK. LOCK SMITH COULD NOT MAKE THE IGNITION ACCEPT THE KEY. HAD TOWED VEHICLE TO THE DEALERSHIP. *AK
NHTSA ODI #10087630
24,000 miles · Aug 9, 2004
Service Brakes, Hydraulic
AT A ROUTINE OIL CHANGE/ALIGNMENT I WAS INFORMED THAT MY FRONT BRAKES WERE 95% WORN AND THAT THEY AND THE ROTORS NEEDED REPLACING. AT FIRST I THOUGHT I WAS BEING HAD -- I'VE ONLY PUT 24,000 MILES ON MY CAR, ALL VERY GENTLE DRIVING. THEN I DISCOVERED THAT I'M ONE OF THE MORE FORTUNATE -- MANY FORD FOCUS OWNERS ARE REPLACING BRA…
Read full complaint
AT A ROUTINE OIL CHANGE/ALIGNMENT I WAS INFORMED THAT MY FRONT BRAKES WERE 95% WORN AND THAT THEY AND THE ROTORS NEEDED REPLACING. AT FIRST I THOUGHT I WAS BEING HAD -- I'VE ONLY PUT 24,000 MILES ON MY CAR, ALL VERY GENTLE DRIVING. THEN I DISCOVERED THAT I'M ONE OF THE MORE FORTUNATE -- MANY FORD FOCUS OWNERS ARE REPLACING BRAKES AND ROTORS AT 15,000 MILES! THERE WASN'T AN ACCIDENT, BUT THERE CERTAINLY COULD HAVE BEEN A BRAKE FAILURE IF MY MECHANICS HAD NOT ALERTED ME TO THE PROBLEM. *AK
NHTSA ODI #10086466
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration