IllustrationSLOW ACCELERATION, LOSS OF POWER, SURGING, HESITATION, STALLING. *JS
2001 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2001 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1350–25K
25825–50K
20050–75K
14775–100K
157100–150K
56150K+
953 reports with mileage · 808 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 496 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 243 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
172 crash reports47 fire reports110 injury reports
What owners actually said
1,761 reportsWAS DRIVING MY CAR AT 55 MPH AT 11:20 PM ON WAY HOME FROM WORK CAR MADE JERK LOST ALL POWER NO BRAKES NO STEERING BLACK SMOKE COMING THROUGH VENTS TO INSIDE OF CAR AND FLAMES COMING FROM UNDER HOOD CAR FULLY ENGULFED IN FLAMES BLEW UP. *TR
RIGHT FRONT COIL SPRING BROKE WHILE DRIVING ON THE ROAD. THE BROKEN SPRING PENETRATED THE RIGHT FRONT TIRE AND IMMEDIATELY DISABLED THE VEHICLE. IT HAS BEEN DOCUMENTED THAT THIS IS A COMMON PROBLEM FOR THIS VEHICLE, AND IT WAS DETERMINED THAT THE SPRINGS WERE MANUFACTURED IMPROPERLY AND DO NOT RESIST CORROSION. FORD HAS RECOGNIZ…
Read full complaint
RIGHT FRONT COIL SPRING BROKE WHILE DRIVING ON THE ROAD. THE BROKEN SPRING PENETRATED THE RIGHT FRONT TIRE AND IMMEDIATELY DISABLED THE VEHICLE. IT HAS BEEN DOCUMENTED THAT THIS IS A COMMON PROBLEM FOR THIS VEHICLE, AND IT WAS DETERMINED THAT THE SPRINGS WERE MANUFACTURED IMPROPERLY AND DO NOT RESIST CORROSION. FORD HAS RECOGNIZED THE PROBELM THROUGH SEVERAL TSBS AND EVEN HAD A CUSTOMER SATISFACTION PROGRAM 03M02 WITH AT LEAST 2 SUPPLEMENTS CONCERNING THE ISSUE AND REPLACEMENT OF THE FAULTY PARTS. I SPOKE WITH A LOCAL FORD DEALER (HONDRU) AND THEY TOLD ME THE PROGRAM EXPIRED AND THE CAR IS NO LONGER COVERED. I THEN SPOKE WITH A FORD REPRESENTATIVE THROUGH DIRECT CUSTOMER SERVICE AND THEY CONFIRMED THIS WAS THE CASE. THEY CONFIRMED THE CONVERSATION WITH NUMBER CAS4271469-Z6W0F2. THE REPRESENTATIVE'S NAME WAS KENDRA. I AM DEEPLY CONCERNED ABOUT THIS BECAUSE IT IS A SIGNIFICANT SAFETY RISK TO ME AN MY FAMILY. THE COIL SPRING IS A SIGNIFICANT COMPONENT OF THE SUSPENSION, AND WHEN IT BRAKES THE DRIVER'S ABILITY TO CONTROL THE CAR IS EXTREMELY COMPROMISED. TO MAKE THINGS WORSE, THE BROKEN SPRING DESTROYS THE TIRE IMMEDIATELY, FURTHER REDUCING THE ABILITY TO CONTROL THE CAR. SINCE IT WAS DOCUMENTED THAT THERE WAS A FAULT IN THE MANUFACTURING PROCESS, AND FORD AND NHTSA KNEW ABOUT THE PROBLEM, THESE PARTS SHOULD HAVE BEEN REPLACED UNDER A RECALL DUE TO THE SAFETY CONCERNS. *TT
BOUGHT VEHICLE 2ND HAND, CASH, EVERYTHING WORKED FINE. NOW, I HAVE NO BRAKE LIGHTS, & MY DOOR LOCKS NO LONGER WORK ON THE REMOTE, OR THE "ALL LOCK/UNLOCK" BUTTON, & NOW MY TRUNK LATCH IS NOT WORKING CORRECTLY. THE DOOR LOCKS ARE SELF LOCKING (MEANING THAT THEY LOCK AT ANY GIVEN TIME WHENEVER THEY PLEASE.) THE BRAKE SWITCH HAS BE…
Read full complaint
BOUGHT VEHICLE 2ND HAND, CASH, EVERYTHING WORKED FINE. NOW, I HAVE NO BRAKE LIGHTS, & MY DOOR LOCKS NO LONGER WORK ON THE REMOTE, OR THE "ALL LOCK/UNLOCK" BUTTON, & NOW MY TRUNK LATCH IS NOT WORKING CORRECTLY. THE DOOR LOCKS ARE SELF LOCKING (MEANING THAT THEY LOCK AT ANY GIVEN TIME WHENEVER THEY PLEASE.) THE BRAKE SWITCH HAS BEEN REPLACED, ALL BULBS HAVE BEEN CHECKED & REPLACED, FUSES KEEP GETTING BLOWN. CANNOT LOCATE FUSE FOR THE DOOR LOCKS. FORD HAS A CAMPAIGN FOR THE YEAR 2000 FOR A DOOR LATCH ISSUE, CAMPAIGN #05S27 NHTSA ID# 05V-030. ALSO, CAMPAIGN #05S50 NHTSA ID #00V-411 FOR A TAIL LAMP ISSUE. THERE ARE NO RECALLS ON THIS YET AFTER DOING WEEKS OF RESEARCH I AM FINDING THAT IT IS AN ISSUE WITH THE FORD FOCUS FROM 2000 TO CURRENT. AFTER CALLING SEVERAL DEALERS, NONE OF THEM WOULD TELL ME ANYTHING, & THAT "THEY DIDN'T RECALL ANY PROBLEMS BEFORE FROM ANYONE ELSE". HOW IS IT THAT I CAN FIND THIS ISSUE ON THE INTERNET BUT THE DEALERS "NEVER HEARD OF IT"? WHY IS THERE NO CHANGE IN THE INDICATED ISSUE OF THE WIRING HARNESS TO THE REAR TAIL LIGHT ASSEMBLY? WOULDN'T THIS BE A HAZARD? I DIDN'T KNOW THEY WEREN'T WORKING UNTIL I GOT PULLED OVER BY LAW ENFORCEMENT. SO, THIS ISSUE HAPPENS WHILE THE VEHICLE IS BEING DRIVEN!!! THEREFORE, A DILIGENT OWNER WHO CHECKS THEIR LIGHTS REGULARLY WILL NOT KNOW IT HAPPENS UNTIL (A) SAID PERSON GETS HIT FROM BEHIND, OR (B) GETS PULLED OVER BY LAW ENFORCEMENT. HERE ARE A FEW LINKS FOR YOUR REFERENCE: LINK: HTTP://WWW.CARGURUS.COM/CARS/DISCUSSION-T574_DS546293. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?S=2146E9390BE4CC339AE4F6438BAF3812&T=104972. LINK: HTTP://WWW.DIYNOT.COM/FORUMS/VIEWTOPIC.PHP?P=1250643. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=149053. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=268411. LINK: HTTP://WWW.FOCUSFANATICS.COM/FORUM/SHOWTHREAD.PHP?T=206427 *JS
SUBFRAME IS RUSTED THROUGH. *TR
2001 FORD FOCUS. CONSUMER WRITES IN REGARDS TO ELECTRICAL SYSTEM FAILURE. *SMD THE CONSUMER STATED THE VEHICLE WAS A LEMON. OVER THE PAST 2 YEARS ALONE, HE HAS SPENT $2,000 IN NON-ROUTINE REPAIRS. EVERY TIME THERE WAS AN ISSUE, THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR THE PROBLEM, BUT WAS NEVER FULLY FIXED. ON ONE OCCASIO…
Read full complaint
2001 FORD FOCUS. CONSUMER WRITES IN REGARDS TO ELECTRICAL SYSTEM FAILURE. *SMD THE CONSUMER STATED THE VEHICLE WAS A LEMON. OVER THE PAST 2 YEARS ALONE, HE HAS SPENT $2,000 IN NON-ROUTINE REPAIRS. EVERY TIME THERE WAS AN ISSUE, THE VEHICLE WAS TAKEN TO THE REPAIR SHOP FOR THE PROBLEM, BUT WAS NEVER FULLY FIXED. ON ONE OCCASION, THE VEHICLE STARTED SMOKING AND THE WIRING CAUGHT ON FIRE.. THE CONSUMER WAS INFORMED, THE VEHICLE NEEDED ALL NEW WIRING, AFTER THE DASH LIGHTS AND TAIL LIGHTS WENT OUT 3 TIMES. ALSO, THE CRUISE CONTROL AND ALL THE LIGHTS INSIDE THE VEHICLE STOPPED WORKING. *JB
ON OUR FORD FOCUS, THE EXTERIOR DOOR HANDLE, ON THE FRONT DRIVER'S SIDE DOES NOT WORK. YOU CAN REACH IN THE WINDOW (OR LEAN OVER CTR CONSOLE) TO PULL THE HANDLE AND OPEN IT. THE HANDLE ON THE OUTSIDE IS STUCK IN THE FULL PULLED OUT POSITION, AND CANNOT BE FORCED IN EVEN. THE BACK DOOR STARTED NOT WORKING PERIODICALLY. I THOUGHT …
Read full complaint
ON OUR FORD FOCUS, THE EXTERIOR DOOR HANDLE, ON THE FRONT DRIVER'S SIDE DOES NOT WORK. YOU CAN REACH IN THE WINDOW (OR LEAN OVER CTR CONSOLE) TO PULL THE HANDLE AND OPEN IT. THE HANDLE ON THE OUTSIDE IS STUCK IN THE FULL PULLED OUT POSITION, AND CANNOT BE FORCED IN EVEN. THE BACK DOOR STARTED NOT WORKING PERIODICALLY. I THOUGHT THE PROBLEM ON THE BACK DOOR MAY BE THE CHILD SAFETY LOCKS BEING ON. I OPENED THE REAR DOOR, INSERTED THE KEY, AND ROTATED IT. AS FAR AS I COULD TELL, THERE WAS NO CHANGE. YOU COULD PULL ON THE INSIDE, AND OUTSIDE HANDLE, AND THE MECHANISM SEEMED TO BE WORKING, SO I CLOSED THE DOOR ....BEFORE CHANGING THE ROTATION BACK. NOW, THE DOOR WILL NOT OPEN FROM THE INSIDE OR OUTSIDE. THIS CONCERNS ME IF THERE WERE AN ACCIDENT, OR FIRE, THE PERSON IN THE BACK SEAT MAY NOT BE ABLE TO EXIT. I WOULD LIKE TO KNOW IF THERE IS A WAY TO RESET THE CHILD DOOR LOCKS-WITHOUT OPENING THE DOOR (SINCE THE DOOR WILL NOT OPEN)? *TR
ON OUR FORD FOCUS, THE EXTERIOR DOOR HANDLE, ON THE FRONT DRIVER'S SIDE DOES NOT WORK. YOU CAN REACH IN THE WINDOW (OR LEAN OVER CTR CONSOLE) TO PULL THE HANDLE AND OPEN IT. THE HANDLE ON THE OUTSIDE IS STUCK IN THE FULL PULLED OUT POSITION, AND CANNOT BE PUSHED IN. THE BACK DRIVER'S SIDE DOOR STARTED PERIODICALLY STARTED HAVING…
Read full complaint
ON OUR FORD FOCUS, THE EXTERIOR DOOR HANDLE, ON THE FRONT DRIVER'S SIDE DOES NOT WORK. YOU CAN REACH IN THE WINDOW (OR LEAN OVER CTR CONSOLE) TO PULL THE HANDLE AND OPEN IT. THE HANDLE ON THE OUTSIDE IS STUCK IN THE FULL PULLED OUT POSITION, AND CANNOT BE PUSHED IN. THE BACK DRIVER'S SIDE DOOR STARTED PERIODICALLY STARTED HAVING PROBLEMS OPENING. I THOUGHT THE PROBLEM WITH THE BACK DOOR MAY BE DUE TO THE CHILD SAFETY LOCKS BEING ENGAGED. I OPENED THE REAR DOOR, INSERTED, AND ROTATED THE KEY. AS FAR AS I COULD TELL, THERE WAS NO CHANGE. YOU COULD PULL THE HANDLE ON THE INSIDE, AND OUTSIDE, AND THE MECHANISM SEEMED TO BE WORKING, SO I CLOSED THE DOOR ....BEFORE CHANGING THE ROTATION BACK. NOW, THE DOOR WILL NOT OPEN ANY, FROM THE INSIDE, OR OUTSIDE. THIS IS A GREAT CONCERN BECAUSE IF THERE WAS AN ACCIDENT, OR FIRE, THE PERSON IN THE BACK SEAT MAY NOT BE ABLE TO EXIT THIS VEHICLE. I WOULD LIKE TO KNOW: IS THERE A WAY TO RESET THE CHILD SAFETY LOCKS, WITHOUT OPENING THE DOOR (SINCE THIS DOOR WILL NOT OPEN)? *TR
TL * THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, SHE ATTEMPTED TO MAKE A RIGHT TURN WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT AFTER DRIVING FOR A SEVERAL MINUTES THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE HAD BEEN REPAIRED UNDER …
Read full complaint
TL * THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, SHE ATTEMPTED TO MAKE A RIGHT TURN WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT AFTER DRIVING FOR A SEVERAL MINUTES THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE HAD BEEN REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 03V482000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 162,000.
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH AND CHANGING GEARS FROM SECOND TO THIRD, THE VEHICLE BEGAN SHAKING UNCONTROLLABLY. THE VEHICLE WAS NOT BEEN TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VIN WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH AND CHANGING GEARS FROM SECOND TO THIRD, THE VEHICLE BEGAN SHAKING UNCONTROLLABLY. THE VEHICLE WAS NOT BEEN TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.
Official recalls
705V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
03V482000 · Fuel System, Gasoline
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
02V289000 · Steering:linkages
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V108000 · Seats:front Assembly:recliner
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V418000 · Seats:front Assembly:recliner
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.