NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reports42,000 miles · Sep 27, 2005
Fuel System, GasolinePower Train
WHEN ACCELERATING IN VARIOUS INCLINES OR DECLINE MY CAR CHOKES AND HESITATES AS IF IT HAS WATER IN THE GAS LINE OR THE FUEL FILTER IS CLOGGED. IT STARTS TO JERK AND SPUTTER AND REFUSES TO ACCELERATE IF I PUSH ON THE PEDAL INSTEAD IT CHOKES OUT. EITHER THE CAR DIES RIGHT THERE OR I MANAGE TO PULL IT OVER AND LET IT DIE ON ITS O…
Read full complaint
WHEN ACCELERATING IN VARIOUS INCLINES OR DECLINE MY CAR CHOKES AND HESITATES AS IF IT HAS WATER IN THE GAS LINE OR THE FUEL FILTER IS CLOGGED. IT STARTS TO JERK AND SPUTTER AND REFUSES TO ACCELERATE IF I PUSH ON THE PEDAL INSTEAD IT CHOKES OUT. EITHER THE CAR DIES RIGHT THERE OR I MANAGE TO PULL IT OVER AND LET IT DIE ON ITS OWN AS SOON AS I COME TO A STOP. TROUBLE RESTARTING THE CAR AS IF TO MUCH AIR INTAKE TO CHOKE IT OUT. FINALLY IT STARTS AND IT RUNS AFTER BLOWING THE LINES BEFORE PUTTING IT INTO DRIVE IT'S GOOD FRO MAYBE ANOTHER 10 15 MILES AND THE AGAIN IT STARTS PUTTERING AND WANTED TO DIE NO CHOICE BUT TO LET IT DIE TO RESTART. CAR HAS BEEN IN THE SHOP NUMEROUS TIMES HAVE HAD A COLLAPSED FUEL LINE AND HAS BEEN REPLACE BUT STILL THE PROBLEM PERSISTS AGAIN WHEN IT'S IN THE SHOP IT DOES NOT HAPPEN AND YET THEY DO NOT DRIVE IT AT THE TIME ITS NORMALLY DRIVEN OR AT THE EXTREMES OF THE TRAFFIC WHILE IT HAPPENS SO AS TO SEE WHAT IT DOES. A BEST EXPLANATION YOU CAN FIND FROM A MECHANIC IS NO PROBLEM SEEABLE. AND YET THERE IS ONE FROM US THE PURCHASER. *JB
NHTSA ODI #10137918
47,100 miles · Sep 22, 2005
Power Train
CLUTCH PEDAL FAILED DUE TO FAILED/DEFECTIVE WELD, LEADING TO DAMAGE TO CLUTCH MASTER CYLINDER. WELD SHOWED INDICATION OF INSUFFICIENT HEAT PENETRATION. DEFECTIVE PART SHOULD HAVE NOT PASSED QUALITY INSPECTION. DEFECTIVE PART AVAILABLE. CAR STRANDED IN GEAR. *NM
NHTSA ODI #10137354
60,000 miles · Sep 22, 2005
Engine And Engine Cooling
I HAVE A 2001 FORD FOCUS AND THERE IS AN EXHAUST TUBE THAT RUNS OFF THE RIGHT SIDE (LOOKING FROM THE FRONT) OF THE MANIFOLD WHICH BROKE FROM RUSTING. I SEARCHED SOME FORUMS ONLINE AND FOUND THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM. MY CAR ONLY HAS 60000 MILES ON IT SO I DON'T BELIEVE IT SHOULD OF RUSTED AND CRACKED LIK…
Read full complaint
I HAVE A 2001 FORD FOCUS AND THERE IS AN EXHAUST TUBE THAT RUNS OFF THE RIGHT SIDE (LOOKING FROM THE FRONT) OF THE MANIFOLD WHICH BROKE FROM RUSTING. I SEARCHED SOME FORUMS ONLINE AND FOUND THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM. MY CAR ONLY HAS 60000 MILES ON IT SO I DON'T BELIEVE IT SHOULD OF RUSTED AND CRACKED LIKE IT DID. *NM
NHTSA ODI #10137349
64,000 miles · Sep 22, 2005
Engine And Engine Cooling
DT: WHILE DRIVING VEHICLE STALLED AND OPERATED AT A REDUCED SPEED. WENT BACK AND FORTH EVENTUALLY ALLOWING THE ENGINE TO DIE. THIS HAPPENED AT ALL SPEEDS. THERE WAS LOSS OF POWER. THE VEHICLE COULD NOT RESTART EASILY. IT MAY TAKE 20-30 MINUTES TO RESTART THE ENGINE. THE VEHICLE HAS NOT BEEN TO A DEALER. NO REPAIRS WERE…
Read full complaint
DT: WHILE DRIVING VEHICLE STALLED AND OPERATED AT A REDUCED SPEED. WENT BACK AND FORTH EVENTUALLY ALLOWING THE ENGINE TO DIE. THIS HAPPENED AT ALL SPEEDS. THERE WAS LOSS OF POWER. THE VEHICLE COULD NOT RESTART EASILY. IT MAY TAKE 20-30 MINUTES TO RESTART THE ENGINE. THE VEHICLE HAS NOT BEEN TO A DEALER. NO REPAIRS WERE MADE. THE CONSUMER HAS NO IDEA WHY THIS HAPPENED. THE CONSUMER BELIEVED THIS VEHICLE WAS INCLUDED IN NHTSA RECALL, NHTSA 03V482000 CONCERNING THE FUEL SYSTEM. THE CONSUMER CONTACTED FORD, AND FORD STATED THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10137275
41,407 miles · Sep 20, 2005
Electrical System
THE IGNITION SWITCH DOES NOT PERMIT THE CAR TO START. THE SWITCH (XS4Z-11582-AC CVR ASY AUX FL) HAS BEEN REPLACED TWICE, ONCE AT 41,407 MILES AND AGAIN AT 57,834 MILES. THE DEALER AND AAA PROVIDED A TEMPORARY REMEDY TO THE STRANDED DRIVER, WHICH IS "WITH THE KEY IN THE IGNITION, HIT IT HARD WITH A HAMMER TO ENGAGE THE IGNITION…
Read full complaint
THE IGNITION SWITCH DOES NOT PERMIT THE CAR TO START. THE SWITCH (XS4Z-11582-AC CVR ASY AUX FL) HAS BEEN REPLACED TWICE, ONCE AT 41,407 MILES AND AGAIN AT 57,834 MILES. THE DEALER AND AAA PROVIDED A TEMPORARY REMEDY TO THE STRANDED DRIVER, WHICH IS "WITH THE KEY IN THE IGNITION, HIT IT HARD WITH A HAMMER TO ENGAGE THE IGNITION ASSEMBLY." AAA KEEPS SPARE FORD FOCUS IGNITION SWITCHES IN ITS EMERGENCY SERVICE SUPPORT TRUCKS. *JB
NHTSA ODI #10137070
Mileage unknown · Sep 20, 2005
Electrical System
LAST 2 YEARS HAVE HAD PROBLEMS PUTTING KEY IN IGNITION AND TURNING IT. I HAVE HAD TO JIGGLE IT AND PUSH IT IN. I GOT STRANDED AT WORK BECAUSE THE KEY WOULD NOT GO IN THE IGNITION AND TURN. I BROUGHT THE CAR TO DEALER AND THEY SAID IGNITION CYLINDER HAD TO BE REPLACED COSTING ME $392.00 FOR THE PART!!!!!! THEY SAID THAT MY STEE…
Read full complaint
LAST 2 YEARS HAVE HAD PROBLEMS PUTTING KEY IN IGNITION AND TURNING IT. I HAVE HAD TO JIGGLE IT AND PUSH IT IN. I GOT STRANDED AT WORK BECAUSE THE KEY WOULD NOT GO IN THE IGNITION AND TURN. I BROUGHT THE CAR TO DEALER AND THEY SAID IGNITION CYLINDER HAD TO BE REPLACED COSTING ME $392.00 FOR THE PART!!!!!! THEY SAID THAT MY STEERING COLUMN COULD POSSIBLY BREAK DURING INSTALLATION! *JB
NHTSA ODI #10137066
Mileage unknown · Sep 16, 2005
Fuel System, Gasoline
2001 FORD FOCUS DEVELOPED PROBLEMS WITH THE FUEL PUMP.*MR THE CONSUMER SON RECEIVED RECALL 03N01 ON THE FUEL PUMP AND HAD IT REPLACED AT THE DEALER. SEVERAL MONTHS LATER THE PROBLEM RECURRED. ON SEPTEMBER 6TH THE VEHICLE WAS TAKEN TO NAPLES FORD AND THE CONSUEMR'S SON WAS TOLD THAT THE FUEL PUMP HAD INDREED FAILED AGAIN. THE…
Read full complaint
2001 FORD FOCUS DEVELOPED PROBLEMS WITH THE FUEL PUMP.*MR THE CONSUMER SON RECEIVED RECALL 03N01 ON THE FUEL PUMP AND HAD IT REPLACED AT THE DEALER. SEVERAL MONTHS LATER THE PROBLEM RECURRED. ON SEPTEMBER 6TH THE VEHICLE WAS TAKEN TO NAPLES FORD AND THE CONSUEMR'S SON WAS TOLD THAT THE FUEL PUMP HAD INDREED FAILED AGAIN. THE DEALER WAS INFORMED THE CONSUMER THAT THEY COULD NOT REPLACED THE FUEL PUMP AGAIN FREE OF CHARGE. *NM
NHTSA ODI #10137753
47,000 miles · Sep 16, 2005
Electrical System
DT:THE CONTACT OWNS A 2001 FORD FOCUS LX. THE IGNITION KEY WOULD NOT TURN IN THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALERSHIP , AND WHEN THE CONTACT GOT THE BILL IT WAS $500, INCLUDING TOWING. THIS INCIDENT HAPPENED TWICE IN NOVEMBER 2003. IGNITION SWITCH WAS REPLACED UNDER WARRANTY, AND AGAIN ON AUGUST 8, 2005 IGNITIO…
Read full complaint
DT:THE CONTACT OWNS A 2001 FORD FOCUS LX. THE IGNITION KEY WOULD NOT TURN IN THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALERSHIP , AND WHEN THE CONTACT GOT THE BILL IT WAS $500, INCLUDING TOWING. THIS INCIDENT HAPPENED TWICE IN NOVEMBER 2003. IGNITION SWITCH WAS REPLACED UNDER WARRANTY, AND AGAIN ON AUGUST 8, 2005 IGNITION SWITCH FAILED. THE REPAIR INVOICE FOR AUGUST 8, 2005 STATED DIAGNOSTIC KEY WILL NOT TURN IN IGNITION, NECESSARY TO REMOVE STEERING BEZELS, REMOVE IGNITION SWITC TO DRILL LOCK CYLINDER, REMOVE GUTS AND HOUSING. ALSO, IT WAS NECESSARY TO CODE NEW LOCK CYLINDER AND INSTALL IT. THIS COST $257.00. THE FIRST TIME IT WAS TTHE DEALERSHIP THEY REPLACED THE IGNITION SWITCH CYLINDER. THE COST $103.66 AND THE TOWING WAS $85.00 . THE SECOND TIME ALL THIS WAS OUT OF POCKET, BUT THE FIRST TIME IT WAS REPLACED UNDER WARRANTY. *AK THE CONSUMER WAS REIMBURSED $195, 50% OF THE PARTS AND LABOR. *NM
NHTSA ODI #10132634
56,000 miles · Sep 12, 2005
Air BagsCrashInjury
THE AIRBAG DEPLOYED AND BURNED THE DRIVER. THE CAR FILLED WITH SMOKE IMMEDIATELY. *JB
NHTSA ODI #10136157
29,500 miles · Sep 8, 2005
Electrical System
THE IGNITION LOCKS UP DUE TO A DEFECTIVE CYLINDER. I HAVE HAD THE CAR FOR ALMOST FOUR YEARS AND I WAS QUITE SURPRISED BY THIS. I LOOKED ON THE WEB AND IT LOOKS LIKE AN EXTREMELY COMMON PROBLEM THAT EVEN THE SERVICE AT FORD ADMITTED TO. I WAS PARTICULARLY SURPRISED WHEN THEY SAID FORD HASN'T ISSUED A RECALL FOR THIS PROBLEM. …
Read full complaint
THE IGNITION LOCKS UP DUE TO A DEFECTIVE CYLINDER. I HAVE HAD THE CAR FOR ALMOST FOUR YEARS AND I WAS QUITE SURPRISED BY THIS. I LOOKED ON THE WEB AND IT LOOKS LIKE AN EXTREMELY COMMON PROBLEM THAT EVEN THE SERVICE AT FORD ADMITTED TO. I WAS PARTICULARLY SURPRISED WHEN THEY SAID FORD HASN'T ISSUED A RECALL FOR THIS PROBLEM. PEOPLE HAVE SAID THAT THEY HAVE HAD THE IGNITION CYLINDER REPLACED 2 AND 3 TIMES IN SHORT PERIODS OF TIME. I AM AFRAID THAT I WILL SUFFER THE SAME FATE. I WOULD LIKE IT IF I DIDN'T HAVE TO PAY HUNDREDS IF NOT THOUSANDS OF DOLLARS FOR SOMETHING FORD KNOWS IS DEFECTIVE AND STILL MAKES THE CUSTOMER PAY FOR THE REPAIR AND MULTIPLE TIMES AS WELL. *NM
NHTSA ODI #10135896
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration