NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reportsMileage unknown · Feb 11, 2006
Electrical System
MY MOTHERS 2001 FORD FOCUS HAD A PROBLEM WITH THE IGNITION SWITCH WITH IT LOCKING UP. AFTER CHECKING THE WEB I FOUND THAT THIS SEEMS TO BE AN ONGOING PROBLEMS WITH THE FORD FOCUS BUT FORD DOESN'T SEEM TO THINK SO. I NOW HAD TO BUY THE PART AND FIND SOMEONE ELSE TO INSTALL BECAUSE IT WOULD BE 3 WEEKS BEFORE THEY COULD FIT ME IN A…
Read full complaint
MY MOTHERS 2001 FORD FOCUS HAD A PROBLEM WITH THE IGNITION SWITCH WITH IT LOCKING UP. AFTER CHECKING THE WEB I FOUND THAT THIS SEEMS TO BE AN ONGOING PROBLEMS WITH THE FORD FOCUS BUT FORD DOESN'T SEEM TO THINK SO. I NOW HAD TO BUY THE PART AND FIND SOMEONE ELSE TO INSTALL BECAUSE IT WOULD BE 3 WEEKS BEFORE THEY COULD FIT ME IN AT A PRICE TAG I WAS TOLD OF $550.00 TO HAVE IT FIXED WHICH IS A RIP OFF ESPECIALLY IF THIS IS HAPPENING TO A NUMBER OF OTHER OWNERS OF FORD FOCUS'. IT SEEMS TO ME FORD DOESN'T WANT TO OWN UP TO THE DEFECT SINCE IT'S NOT A SAFETY CONCERN TO THEM. *JB
NHTSA ODI #10150027
Mileage unknown · Feb 11, 2006
Seat Belts
FRONT PASSENGER SEAT BELT FAILED TO LATCH. BROUGHT TO GARAGE AND HAD TO GET IT REPLACED... AT A COST OF OVER $190.00. NOW, ONLY ABOUT 2 MONTHS LATER, THE REAR PASSENGER AND MIDDLE SEAT BELTS ARE NOT LATCHING AT ALL. MY CHILDREN USE THESE BELTS FOR THEIR BOOSTER SEATS. IT IS EXTREMELY DANGEROUS AND A DEFINITE SAFETY HAZARD. I AM …
Read full complaint
FRONT PASSENGER SEAT BELT FAILED TO LATCH. BROUGHT TO GARAGE AND HAD TO GET IT REPLACED... AT A COST OF OVER $190.00. NOW, ONLY ABOUT 2 MONTHS LATER, THE REAR PASSENGER AND MIDDLE SEAT BELTS ARE NOT LATCHING AT ALL. MY CHILDREN USE THESE BELTS FOR THEIR BOOSTER SEATS. IT IS EXTREMELY DANGEROUS AND A DEFINITE SAFETY HAZARD. I AM NOT WANTING TO HAVE TO PAY ANOTHER $400 OR SO TO GET THESE FIXED AS WELL. *JB
NHTSA ODI #10150026
60,000 miles · Feb 8, 2006
Electrical System
2001 FORD FOCUS. INSERT KEY BUT IGNITION WILL NOT TURN. APPARENTLY A VERY COMMON PROBLEM AND FORD NEEDS TO DO A RECALL!*JB
NHTSA ODI #10149697
64,871 miles · Jan 29, 2006
Engine And Engine Cooling
2001 FORD FOCUS Z3 COOLING LOW SPEED FAN SYSTEM RESISTOR FAILURE, HOT LEAD WIRE IN PLASTIC SHIELDING MELTED , INSULATION MELTED FROM SOCKET TO SOURCE SOCKET. CONTACTS OVERHEATED/MELTED, CIRCUIT'S FUSE DID NOT BLOW. HIGH SPEED FAN CONTINUES TO OPERATE WHEN AIR CONDITIONER IS TURNED ON. CAR OVERHEATS IN TRAFFIC BECAUSE LOW FAN…
Read full complaint
2001 FORD FOCUS Z3 COOLING LOW SPEED FAN SYSTEM RESISTOR FAILURE, HOT LEAD WIRE IN PLASTIC SHIELDING MELTED , INSULATION MELTED FROM SOCKET TO SOURCE SOCKET. CONTACTS OVERHEATED/MELTED, CIRCUIT'S FUSE DID NOT BLOW. HIGH SPEED FAN CONTINUES TO OPERATE WHEN AIR CONDITIONER IS TURNED ON. CAR OVERHEATS IN TRAFFIC BECAUSE LOW FAN MOTORS DO NOT COME ON, NEVER NOTICED PROBLEM AS AIR CONDITIONER USUALLY ON ALL THE TIME. HAS BEEN ONGOING FOR PAST 6 MONTHS. JUST NOW CHECKED RESISTOR AND FOUND BURNED WIRING. NO FIRE, NO INJURIES BUT GIVEN DIFFERENT CIRCUMSTANCES COULD BE A FIRE PROBLEM. THE FUSE SHOULD HAVE PROTECTED THE CIRCUIT BUT HASN'T. *AK
NHTSA ODI #10148923
41,000 miles · Jan 27, 2006
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
BRAKES HAD TO BE REPLACED AT LESS THAN 24,000 MILES; CONTINUES GRINDING AND SQUEAKING CONTINUE EVEN FOLLOWING BRAKE REPLACEMENT AND TURNING OF ROTORS; AT HAVE REPLACED ALL FOUR TIRES TWO TIMES, WITH LESS THAN 20,000 MILES ON EACH SET OF TIRES; IGNITION SWITCH MALFUNCTIONED - I COULD GET THE KEY INTO THE IGNITION, BUT IT WOULD NO…
Read full complaint
BRAKES HAD TO BE REPLACED AT LESS THAN 24,000 MILES; CONTINUES GRINDING AND SQUEAKING CONTINUE EVEN FOLLOWING BRAKE REPLACEMENT AND TURNING OF ROTORS; AT HAVE REPLACED ALL FOUR TIRES TWO TIMES, WITH LESS THAN 20,000 MILES ON EACH SET OF TIRES; IGNITION SWITCH MALFUNCTIONED - I COULD GET THE KEY INTO THE IGNITION, BUT IT WOULD NOT ROTATE; NOW AT ONLY 41,000 MILES, THE ENGINE ATTEMPTS TO STALL IN IDLE - THE WHOLE CAR SHUDDERS - AND HAS STALLED TWICE WHILE I WAS STOPPED AT TRAFFIC LIGHTS. THIS PRESENTS A DANGEROUS SITUATION, NOT ONLY FOR MYSELF, BUT FOR MY TWO CHILDREN AND OTHERS ON THE ROADWAY. IN REVIEWING THIS SITE, I AM OBVIOUSLY NOT THE ONLY ONE EXPERIENCING THESE SAME PROBLEMS. WHY DOESN'T THE NHTSA ISSUE RECALLS ON FORD FOCUS FOR THESE AND OTHER PROBLEMS? FORD SHOULD RECALL THE WHOLE LINE AND ISSUE REFUNDS TO CUSTOMERS OR CANCEL THEIR REMAINING LOAN PAYMENTS. I AM A SINGLE MOTHER WITH TWO CHILDREN, WHO CANNOT AFFORD COSTLY REPAIRS. THE ATTITUDE OF THE SERVICE PERSONNEL AT THE FORD DEALERSHIP HERE IS AWFUL, AND THEY HAVE TREATED ME BADLY EVERY TIME I HAVE GONE IN THERE, SO THAT I DON'T EVEN WANT TO TAKE THE CAR IN WITH THIS LATEST PROBLEM.*AK
NHTSA ODI #10148857
125,000 miles · Jan 25, 2006
Service Brakes, Hydraulic
BRAKE LINE FAILURE, BRACKET FELL OFF AND WORE BRAKE LINE IN TWO NO WARNING. BRAKES FAILED ON FREEWAY AT 70 MPH. NO PREVIOUS INDICATION OF PROBLEM, TOTAL BRAKE LOSS. 2001 FORD FOCUS 120000 MILES. I COULD HAVE BEEN KILLED OR KILLED SOMEONE ELSE DUE TO THIS FAILURE.*AK
NHTSA ODI #10148531
77,000 miles · Jan 20, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THE VEHICLE SHUTS OFF WHILE DRIVING. THERE ARE NO WARNING LIGHTS AND THIS OCCURS AT VARIOUS SPEEDS. AN INDEPENDENT REPAIR SHOP DETERMINED THE FUEL PUMP NEEDS TO BE REPLACED. THE CONTACT RECEIVED A RECALL LETTER, #03V482000, FOR THE FILTER IN THE FUEL DELIVERY MODULE. THE RECALL WORK HAS NOT BEEN PERF…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE SHUTS OFF WHILE DRIVING. THERE ARE NO WARNING LIGHTS AND THIS OCCURS AT VARIOUS SPEEDS. AN INDEPENDENT REPAIR SHOP DETERMINED THE FUEL PUMP NEEDS TO BE REPLACED. THE CONTACT RECEIVED A RECALL LETTER, #03V482000, FOR THE FILTER IN THE FUEL DELIVERY MODULE. THE RECALL WORK HAS NOT BEEN PERFORMED, BECAUSE THE DEALERSHIP INSPECTED THE VEHICLE AND DETERMINED THIS VEHICLE IS NOT HAVING THE PROBLEM ASSOCIATED WITH THE RECALL. *NM
NHTSA ODI #10148206
Mileage unknown · Jan 20, 2006
Electrical System
IGNITION CYLINDER LOCK UP- I DO NOT KNOW WHAT LED TO THE LOCK UP. A FEW DAYS BEFORE THIS HAPPENED MY EMISSION LIGHT CAME ON AND THEN WENT OUT A FEW DAYS LATER. I KNOW SEVERAL PEOPLE HAVE HAD THE SAME PROBLEM WITH THE IGNITION CYLINDER LOCK UP... PLEASE RECALL AND FIX THE PROBLEM. *JB
NHTSA ODI #10148179
38,000 miles · Jan 11, 2006
Suspension
DT*: THE CONTACT STATED AFTER DRIVING ON BUMPY ROAD CONDITIONS T A CLANKING NOISE COMING FROM THE FRONT SUSPENSION. THE VEHICLE WAS TAKEN TO A DEALER, WHO DETERMINED THE STABILIZER BAR NEEDED TO BE REPLACED, AND THE PIVOT JOINT HAD WORN OUT PREMATURELY. THE DEALER REPLACED THE STABILIZER BAR. *AK UPDATED 2/7/2006 - *NM
NHTSA ODI #10147441
Mileage unknown · Jan 10, 2006
Electrical SystemService Brakes, HydraulicTires
WENT SO SEARS AUTO CENTER AT 9570 SOUTH WEST FREEWAY HOUSTON TEXAS 77074. FOR A TIRE CHANGE THEY CHARGE 156.00 AND ALSO TOLD ME THAT MY CAR ROTORS WERE BROKEN AND NEED SHOE/PAD TO BE REPLACED. AND CAR NOT TO BE DRIVEN. TOTAL AMOUNT 571.00. CALLED NEXT MORNING TO CANCEL WORK BECAUSE I DECIDED TO TAKE TO DEALER FORD. BUT THAT T…
Read full complaint
WENT SO SEARS AUTO CENTER AT 9570 SOUTH WEST FREEWAY HOUSTON TEXAS 77074. FOR A TIRE CHANGE THEY CHARGE 156.00 AND ALSO TOLD ME THAT MY CAR ROTORS WERE BROKEN AND NEED SHOE/PAD TO BE REPLACED. AND CAR NOT TO BE DRIVEN. TOTAL AMOUNT 571.00. CALLED NEXT MORNING TO CANCEL WORK BECAUSE I DECIDED TO TAKE TO DEALER FORD. BUT THAT TIME CAR WASN'T FIXED YET CAUSE THEY TOLD ME TO PAY FIRST BUT I DIDN'T HAVE A CREDIT CARD WITH ME THAT NIGHT SO I LEFT IT THERE AND TOOK BUS. THEY CHARGE 271. NEXT MORNING FOR SOME SHOE/PAD WHICH I TOOK MY CAR THE THE REGULAR MECHANIC AND THEY TOLD ME THAT SEARS DID NOT CHANGE ANYTHING ON MY CAR. SO I PAY THAT MANY MY CAR IS STILL NOT FIXED. I HAVE TO DRIVE MY CAR BECAUSE I DON'T HAVE ANOTHER WAY TO MOVE. SO PLEASE HELP ME TO TO GET MY MONEY BACK OR TO GET MY CAR FIXED. *JB
NHTSA ODI #10147389
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration