NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reports63,000 miles · Sep 25, 2003
Fuel System, Other
WHILE DRIVING DOWN A FREEWAY OFF-RAMP, MY 2001 FORD FOCUS ZX3 STARTED TO BUCK AND HESITATE, EVENTUALLY STALLING AND CAUSING A DANGEROUS CONDITION DUE TO SUDDEN DECCELERATION AND LOSS OF POWER STEERING AND BRAKES. LUCKILY THE VEHICLE HAD ENOUGH INERTIA TO COAST DOWN THE RAMP AND EVENTUALLY I WAS ABLE TO PULL IT INTO AN EMERGENCY…
Read full complaint
WHILE DRIVING DOWN A FREEWAY OFF-RAMP, MY 2001 FORD FOCUS ZX3 STARTED TO BUCK AND HESITATE, EVENTUALLY STALLING AND CAUSING A DANGEROUS CONDITION DUE TO SUDDEN DECCELERATION AND LOSS OF POWER STEERING AND BRAKES. LUCKILY THE VEHICLE HAD ENOUGH INERTIA TO COAST DOWN THE RAMP AND EVENTUALLY I WAS ABLE TO PULL IT INTO AN EMERGENCY LANE USING THE REMAINING ASSIST LEFT IN THE BRAKE BOOSTER. THERE, I ATTEMPTED MULTIPLE TIMES TO RESTART THE VEHICLE AND IT FINALLY STARTED. IT HAD A HALF TANK OF FUEL SO LOW FUEL LEVEL WAS NOT THE CAUSE AND I HAD ONLY DRIVEN 163 MILES SINCE THE LAST FILL-UP SO I KNEW THE FUEL GUAGE WAS OPERATIONAL. I ATTEMPTED TO DRIVE TO THE NEAREST GAS STATION TO FILL UP JUST IN CASE AND AS I AS ABOUT TO TURN IN THE CAR DIED AGAIN. IT RESTARTED AFTER MULTIPLE ATTEMPTS AND I WAITED A LONG TIME FOR TRAFFIC TO GET AS CLEAR AS IT WOULD ON THIS BUSY ROAD. THEN, AS I ATTEMPTED TO TURN IN, CREEPING FORWARD AND FEARING THE WORST, THE CAR DIED AGAIN, BUT LUCKILY I HAD NOT YET BEGUN TO IMPEDE ONCOMING TRAFFIC. IF I HAD BEEN, AN ACCIDENT WOULD LIKELY HAVE RESULTED. AFTER MULTIPLE ATTEMPTS, THE VEHICLE DID START AND I PULLED IN, FILLED UP, AND DROVE HOME UNEVENTFULLY TO DO SOME RESEARCH. ON THE MESSAGE BOARD AT FOCALJET.COM I READ ABOUT OTHER FOCUS CONSUMERS ENCOUNTERING A SIMILAR PROBLEM WITH A DEFECTIVE FUEL PUMP AND SOME SORT OF DEGRADATION OF A MATERIAL LINING THE FUEL TANK CAUSING THE CONDITION I EXPERIENCED. I FEEL IT IS A SAFETY CONCERN OF HIGH PRIORITY AND SHOULD BE BROUGHT TO FORD'S ATTENTION IMMEDIATELY. I AM ANGRY THAT MY LIFE WAS PUT IN DANGER RUNNING THE MOST MUNDANE OF ERRANDS AND I WILL LET THEM KNOW ABOUT IT TOMMORROW.
NHTSA ODI #10039549
Mileage unknown · Sep 24, 2003
Steering
VEHICLE WAS TAKEN TO THE DEALER FOR RECALL# 02V289000 REPAIRS CONCERNING STEERING PINCH BOLTS. THE REMEDY FOR THIS RECALL IS INADEQUATE BECAUSE THE CONTROL ARM CONTINUES TO LOOSEN FROM THE STEERING KNUCKLE, CAUSING DIFFICULTY WHEN STEERING THE VEHICLE. *AK
NHTSA ODI #10040486
26,000 miles · Sep 23, 2003
Electrical SystemPower TrainSeats
REAR WHEEL BEARINGS ARE WEARING OUT ON VEHICLE.*MR THE AUTOMATIC TRANSMISSION DOES NOT SHIFT PROPERLY, THE CONSUMER DISCOVERED THE WRONG TRANSMISSION FLUID WAS IN THE VEHICLE. THE FRONT WINDSHIELD CRACKED DUE TO EXCESSIVE HEAT. THE REAR SEAT LATCH, THE SEAT FABRIC AND THE KEY IGNITION FAILED.*TS THE WINDSHIELD WIPERS WORE OUT,…
Read full complaint
REAR WHEEL BEARINGS ARE WEARING OUT ON VEHICLE.*MR THE AUTOMATIC TRANSMISSION DOES NOT SHIFT PROPERLY, THE CONSUMER DISCOVERED THE WRONG TRANSMISSION FLUID WAS IN THE VEHICLE. THE FRONT WINDSHIELD CRACKED DUE TO EXCESSIVE HEAT. THE REAR SEAT LATCH, THE SEAT FABRIC AND THE KEY IGNITION FAILED.*TS THE WINDSHIELD WIPERS WORE OUT, WHICH WERE ONLY USED ABOUT SEVEN TIMES AND THE REAR BRAKES HAD TO BE REPLACED. *JB
NHTSA ODI #10040652
22,000 miles · Sep 23, 2003
Engine And Engine CoolingSuspension
TIRE PROBLEM, POSSIBLE REAR BEARING PROBLEM, POSSIBLE ALIGNMENT PROBLEM, EGR REPLACED- ENGINE MISFIRING IS BEGINNING TO REAPPEAR
NHTSA ODI #10039331
Mileage unknown · Sep 22, 2003
Steering
I HAVE A RECALL ON MY 2001 FORD FOCUS. MY HUSBAND IS IN THE MILITARY AND WE ARE CURRENTLY LIVING IN LONDON, ENGLAND. WE HAVE TRIED NUMEROUS TIMES TO GET THE RECALL TAKEN CARE OF, BUT NO ONE WILL HELP US. WE HAVE TAKEN THE VEHICLE TO A FORD DEALER IN THE UK, AND THEY TOLD US THAT THEY WILL FIX THE RECALL, BUT THEY CANNOT ORDER…
Read full complaint
I HAVE A RECALL ON MY 2001 FORD FOCUS. MY HUSBAND IS IN THE MILITARY AND WE ARE CURRENTLY LIVING IN LONDON, ENGLAND. WE HAVE TRIED NUMEROUS TIMES TO GET THE RECALL TAKEN CARE OF, BUT NO ONE WILL HELP US. WE HAVE TAKEN THE VEHICLE TO A FORD DEALER IN THE UK, AND THEY TOLD US THAT THEY WILL FIX THE RECALL, BUT THEY CANNOT ORDER THE PART BECAUSE IT IS AN AMERICAN CAR. I HAVE CONTACTED FORD ABOUT 15 TIMES, AND EACH TIME HAVE BEEN GIVEN THE RUN AROUND. I HAVE ABOUT 6 DIFFERENT PHONE NUMBERS THAT THEY HAVE GIVEN ME TO TRY AND EACH TIME, THE PERSON THAT I TALK TO SAYS THAT THEY CANNOT HELP ME. THE RECALL IS FOR REAR WHEEL BEARINGS AND PINCH BOLT. I HAVE A 16-MONTH-OLD SON THAT HAS TO RIDE IN THAT CAR, AND I HAVE TRIED TO EXPLAIN TO THEM THAT I AM AFRAID FOR HIS SAFETY, BUT EVEN THAT HAS NOT HELPED TO GET ME ANY SATISFACTION. I WILL APPRECIATE ANY AND ALL HELP THAT CAN BE GIVEN. THANK YOU, HEATHER HUNDLEY. *JB
NHTSA ODI #10039305
Mileage unknown · Sep 16, 2003
Electrical System
WHEN ATTEMPTING TO START VEHICLE IGNITION LOCKED WITHOUT WARNING. *AK
NHTSA ODI #10040019
Mileage unknown · Sep 15, 2003
Engine And Engine CoolingWheels
FIRST TIME DEALER REPLACED THE SERPENTINE BELT, AND SECOND TIME DEALER REPLACED NUTS AND BOLTS AND SERPENTINE BELTS. BUT SQUEAKING NOISE STILL OCCURRING. *AK
NHTSA ODI #10039963
16,500 miles · Sep 15, 2003
Air BagsCrashInjury
AIRBAGS DEPLOYED AT MINOR FENDER-BENDER, SO MINOR THAT THERE WAS NO DAMAGE TO EITHER CAR, THE ONLY DAMAGE WAS FROM THE AIRBAGS-CAUSED THE WINSHIELD TO BREAK AND A SECOND DEGREE BURN ON DRIVER'S RIGHT ARM.
NHTSA ODI #10038902
42,000 miles · Sep 15, 2003
Fuel System, Gasoline
WHEN THE VEHICLE WAS IN REVERSE AND THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE STALLED.*AK THE DEALERSHIP REFUSED TO EVALUATE THE PROBLEM BECAUSE THE VEHICLE STARTED AFTER BEING TOWED. ALL THREE INCIDENTS OCCURRED WHEN THE GAS TANK WAS 1/4 FULL OR LESS. ALL THREE INCIDENTS OCCURRED WHEN THE VEHICLE SAT OVERNIGHT AND WAS START…
Read full complaint
WHEN THE VEHICLE WAS IN REVERSE AND THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE STALLED.*AK THE DEALERSHIP REFUSED TO EVALUATE THE PROBLEM BECAUSE THE VEHICLE STARTED AFTER BEING TOWED. ALL THREE INCIDENTS OCCURRED WHEN THE GAS TANK WAS 1/4 FULL OR LESS. ALL THREE INCIDENTS OCCURRED WHEN THE VEHICLE SAT OVERNIGHT AND WAS STARTED IN THE MORNING. *PH *JB
NHTSA ODI #10034042
21,600 miles · Sep 13, 2003
Service Brakes, Hydraulic
PREMATURE BRAKE PAD AND ROTOR REPLACEMENTS ON FRONT OF FORD FOCUS SEDAN. BRAKES REPLACED AT 21,000 MILES. I HAVE NEVER HAD TO REPLACE ROTORS ON ANY CAR THIS EARLY. FORD OWNERS OF FOCUS HAVE LISTED THIS PROBLEM HUNDREDS OF TIMES. YET I KNOW OF NO RECALL FOR THIS PROBLEM. SOME HAVE HAD IT IN LESS THAN 10,000 MILES. THIS REALLY NEE…
Read full complaint
PREMATURE BRAKE PAD AND ROTOR REPLACEMENTS ON FRONT OF FORD FOCUS SEDAN. BRAKES REPLACED AT 21,000 MILES. I HAVE NEVER HAD TO REPLACE ROTORS ON ANY CAR THIS EARLY. FORD OWNERS OF FOCUS HAVE LISTED THIS PROBLEM HUNDREDS OF TIMES. YET I KNOW OF NO RECALL FOR THIS PROBLEM. SOME HAVE HAD IT IN LESS THAN 10,000 MILES. THIS REALLY NEEDS TO BE LOOKED INTO. *JB
NHTSA ODI #10038822
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration