NHTSA owner reports · September 18, 2026 snapshot.
Wheels complaints
28 reportsClear category filter78,000 miles · Oct 8, 2004
Wheels
WHILE DRIVING, THE CONSUMER HEARD A HIGH SCREECHING NOISE FROM THE REAR OF THE VEHICLE, FOLLOWED BY THE REAR WOBBLING. THE DRIVER PROCEEDED TO PULL OFF THE ROAD. THE VEHICLE WAS TOWED TO A DEALERSHIP BECAUSE IT WAS UNDRIVEABLE. THE REAR WHEEL BEARING BROKE PREMATURELY. THIS OCCURRED DUE TO THE DEFECT DESCRIBED IN THE REAR WHEEL…
Read full complaint
WHILE DRIVING, THE CONSUMER HEARD A HIGH SCREECHING NOISE FROM THE REAR OF THE VEHICLE, FOLLOWED BY THE REAR WOBBLING. THE DRIVER PROCEEDED TO PULL OFF THE ROAD. THE VEHICLE WAS TOWED TO A DEALERSHIP BECAUSE IT WAS UNDRIVEABLE. THE REAR WHEEL BEARING BROKE PREMATURELY. THIS OCCURRED DUE TO THE DEFECT DESCRIBED IN THE REAR WHEEL BEARING RECALL 01I01700 BUT THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED. *JB
NHTSA ODI #10095521
696 miles · Sep 17, 2004
Electrical SystemService Brakes, HydraulicWheels
WHILE DRIVING AND UPON STEPPING ON THE BRAKES FRONT WHEELS MOVED BACK THREE TO FOUR INCHES. THE BUSHINGS WERE TOO SMALL. UPON TURNING THE STEERING WHEEL LEFT ONE COULD SEE THE FRONT WHEELS MOVING BACK. CONSUMER STATED VEHICLE HAD BEEN TO THE DEALER FIFTEEN TIMES. DEALER PUT REPLACEMENT PARTS FIVE TIMES. TIRES HAD TO BE CHA…
Read full complaint
WHILE DRIVING AND UPON STEPPING ON THE BRAKES FRONT WHEELS MOVED BACK THREE TO FOUR INCHES. THE BUSHINGS WERE TOO SMALL. UPON TURNING THE STEERING WHEEL LEFT ONE COULD SEE THE FRONT WHEELS MOVING BACK. CONSUMER STATED VEHICLE HAD BEEN TO THE DEALER FIFTEEN TIMES. DEALER PUT REPLACEMENT PARTS FIVE TIMES. TIRES HAD TO BE CHANGED BETWEEN TEN TO THIRTEEN THOUSAND MILES, AND TIRES WERE UNDER WARRANTY FOR 30000 MILES. ALSO, IGNITION SWITCH HAD BEEN CHANGED TWICE, BUT PROBLEM RECURRED. *AK
NHTSA ODI #10092586
50,043 miles · Jun 29, 2004
Wheels
FAULTY WHEEL BEARING SEALS ON 2001 FORD FOCUS.*MR THE SEALS FAILED WHICH RESULTED IN THE WHEEL BEARINGS ON BOTH WHEELS TO FAIL COMPLETELY. THERE WAS A RECALL REGARDING THE ISSUE, HOWEVER THE CONSUMERS VEHICLE WAS NOT INCLUDED IN THE RECALL. *JB
NHTSA ODI #10081840
Mileage unknown · Jan 15, 2004
Electrical SystemEngine And Engine CoolingEquipment
I HAVE HAD NUMEROUS PROBLEMS WITH MY FOCUS. ABOUT 3MO AFTER I BOUGHT IT, THE TRANSMISSION BEGAN TO FEEL LIKE IT WAS SLIPPING, AND MAKING A NOISE. I TOOK IT TO THE PURCHASING DEALERSHIP, AND A MECHANIC TOLD ME IT WAS THE TORQUE CONVERTER. THEY DIDN'T HAVE A LOANER CAR FOR ME, SO I MADE AN AN APPOINTMENT FOR THE FOLLOWING WEEK. TH…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH MY FOCUS. ABOUT 3MO AFTER I BOUGHT IT, THE TRANSMISSION BEGAN TO FEEL LIKE IT WAS SLIPPING, AND MAKING A NOISE. I TOOK IT TO THE PURCHASING DEALERSHIP, AND A MECHANIC TOLD ME IT WAS THE TORQUE CONVERTER. THEY DIDN'T HAVE A LOANER CAR FOR ME, SO I MADE AN AN APPOINTMENT FOR THE FOLLOWING WEEK. THE NEXT DAY ON MY WAY HOME FROM WORK, THE CAR SHUT DOWN. I CALLED A TOW TRUCK, THEY TOOK IT TO THE CLOSEST DEALERSHIP. WHEN I CALLED THE DEALERSHIP THE NEXT DAY, THEY SAID THE FUEL PUMP WENT OUT. THEY TOLD ME THAT THE STUTTER I WAS FEELING IN MY CAR WAS PROBABLY THAT. A FEW DAYS LATER, THE SAME PROBLEM. TOOK IT BACK TO THE SELLING DEALERSHIP, AND THE SHOP SUPERVISOR WENT OUT WITH ME. HE SAID I WAS DRIVING THE CAR OUT OF CONTEXT. WHAT HE MEANT BY THAT, HE WOULDN'T ELABORATE, BUT SAID THERE IS NOTHING WRONG WITH MY CAR. I HAVE BEEN DRIVING IT SINCE, AND THE COMPUTER WILL FADE IN AND OUT, BUT I WON'T LOSE ENGINE POWER. MY CAR HAS TO HAVE NEW BRAKE PADS EVERY COUPLE OF MONTHS, NEW TIRES, AND OTHER MAINTENANCE THINGS. AT LESS THAN 40000 MILES, IT NEEDED NEW SPARK PLUGS, AND WIRES, WHICH I HAPPILY BOUGHT. THE DEALERSHIP WANTED $300, BECAUSE THE PLUGS WERE IN THE BACK OF THE MOTOR. I WENT TO MY CAR, POPPED THE HOOD, FOUR SPARK PLUGS LINED THE TOP OF THE HEAD COVER. THERE WAS NO FURTHER EXPLANATION OF THE ATTEMPTED OVER CHARGE. MY CAR HAS SEVERAL OTHER PROBLEMS. THE POSITIVE CABLE ON THE BATTERY, HAS MELTED BACK, THERE IS A LOUD ROAR IN THE CAB OF THE CAR, AND THREE OF THE FOUR LUG NUTS ON THE RIGHT REAR TIRE HAS SNAPPED OFF. THE EXPLANATION FOR THE LUG NUTS, WAS THAT THE TIRE WAS LOOSE, NOT FASTENED PROPERLY. BUT THIS PROBLEM OCCURRED 3-4 MO AFTER I BOUGHT IT. THE TIRES HAD NOT BEEN TAKEN OFF. I AM TO THE POINT WHERE I HATE FORD FOR SELLING ME THIS CAR. I WILL EVER BUY FORD AGAIN, BUT I LOVE THE CONCEPT OF THE CAR
NHTSA ODI #10070089
21,000 miles · Jan 15, 2004
Service Brakes, HydraulicSteeringSuspensionCrash
I HAVE HAD SEVERAL REPAIRS FOR THIS CAR. IN REGARDS TO STEERING, WHEEL, TIRE AS WELL THE SUSPENSION. AS THE CAR WAS UNDER 18000 MILE I HAD SO MUCH PROBLEM WITH MENTIONED ABOVE PROBLEMS. I COULD NOT CONTROL MY CAR WHEN IT RAINED OR WHEN EVER THE ROAD WAS NOT IN PERFECT SHAPE.
NHTSA ODI #10070037
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingEquipmentFuel System, Gasoline
THERE IS JUST TO MUCH PAPERWORK TO COPY OUT, BUT WOULD LIKE TO MAIL COPIES. I AM GOING TO PICK UP CAR THIS AFTERNOON JUST HAD SECOND FUEL PUMP FITTED AND NEW GAS TANK. TO DATE NO RECALL INFO RECEIVED BY POST. HOWEVER I HAVE BEEN DRENCHED WITH GAS ON MORE THAN ONE OCCASSION WHILE FILLING CAR. I HAVE NEARLY BEEN KILLED WHEN CAR CU…
Read full complaint
THERE IS JUST TO MUCH PAPERWORK TO COPY OUT, BUT WOULD LIKE TO MAIL COPIES. I AM GOING TO PICK UP CAR THIS AFTERNOON JUST HAD SECOND FUEL PUMP FITTED AND NEW GAS TANK. TO DATE NO RECALL INFO RECEIVED BY POST. HOWEVER I HAVE BEEN DRENCHED WITH GAS ON MORE THAN ONE OCCASSION WHILE FILLING CAR. I HAVE NEARLY BEEN KILLED WHEN CAR CUT OUT AT 55MPH ON HIGHWAY NARROWLY MISSED BY TWO OTHER MOTORISTS. VEHICLE HAS 38,000 MILES & HAS HAD THE FOLLOWING REPAIRS. 1/COUNTLESS ENGINE SENSORS 2/FOUR NEW TYRES 3/NEW FRONT BRAKE PADS 4/NEW FRONT BRAKE ROTAS 5/NEW FRONT WHEEL BEARINGS 6/TWO FUEL PUMPS 7/ONE FUEL TANK 8/WAITING FOR THIRD SET OF A FRAME PLASTIC COVERS 9/THREE STEREO PLAYERS 10/TRACKLINK RESET THREE TIMES 11/STILL HAVE REALY NOISY BRAKES 12/ENGINE SOUNDS LIKE 10 YEAR OLD CAR 13/REAR PASSENGER WINDOW WORKS WHEN FEELS LIKE IT 14/RIGHT HAND DOOR SPEAKER SOUNDS AS IF BROKEN 15/NEW TIRES FITTED SHOWING SIGNS OF ODD WEAR 16/TAIL GATE LEAKES WATER 17/ THOUGHT LINCOLN/MERCURY DEALER MIGHT GIVE BETTER RESULTS NO JUST LONGER WAIT.
NHTSA ODI #10069809
Mileage unknown · Jan 15, 2004
Service Brakes, HydraulicSuspensionUnknown Or OtherCrash
MY DAUGHTER SLAMMED ON THE BRAKES AT 40MPH AND THE VEHICLE STEERING WHEEL JERKED TO THE RIGHT AND SHE FELT A DROP IN THE LEFT FRONT SIDE OF THE CAR, THE CAR STARTED SLIDING AND HIT A CURB. WHEN THE CAR CAME TO A STOP THE FRONT LEFT WHEEL WAS BROKE OFF. A TOW TRUCK TOOK IT TO THE FORD DEALERSHIP. THEY SAID IT NEEDED A CONTROL …
Read full complaint
MY DAUGHTER SLAMMED ON THE BRAKES AT 40MPH AND THE VEHICLE STEERING WHEEL JERKED TO THE RIGHT AND SHE FELT A DROP IN THE LEFT FRONT SIDE OF THE CAR, THE CAR STARTED SLIDING AND HIT A CURB. WHEN THE CAR CAME TO A STOP THE FRONT LEFT WHEEL WAS BROKE OFF. A TOW TRUCK TOOK IT TO THE FORD DEALERSHIP. THEY SAID IT NEEDED A CONTROL ARM; HUB ASSEMBLY; TIE ROD END; TIRE & WHEEL; AXLE; BRAKE LINE; BRAKE PADS & ROTOR; TRANS PAN AND INNER TIE ROD. THEY CONCLUDED IT WAS IN AN ACCIDENT AND IT WAS HER FAULT AND THE COST WOULD BE $2,387.77 JUST FOR THE MECHANICAL ONLY. SHE PURCHASED THE CAR SEPTEMBER OF 2002, PUTTING OVER $8,000.00 DOWN ON THE DAY OF PURCHASE WITH A REMAINING BALANCE OF $6,000.00. AT THE TIME OF THE ACCIDENT SHE HAD NO INSURANCE. I BELEIVE THERE WAS A PROBLEM WITH CAR TO CAUSE IT TO GO OUT OF CONTROL, AND FEEL FORD NEEDS TO ADDRESS IT.
NHTSA ODI #10069792
51,756 miles · Jan 15, 2004
Fuel System, GasolineVisibilityWheels
ALSO NOV/20/01 MY ELECTRIC WINDOWS STOPPED WORKING ONCE AGAIN.....WARRENTY COVERED THAT.
NHTSA ODI #10069255
65,000 miles · Jan 15, 2004
Air BagsEngine And Engine CoolingService Brakes, HydraulicCrash
THE TIRE AND THE BRAKES WENT OUT AND THE CAR STATED SLIDING. AFTER THE CRASH THERE WERE BOLTS THAT WERE FOUND ON THE GRASS WHERE THE CRASH HAPPENED
NHTSA ODI #10069222
Mileage unknown · Sep 15, 2003
Engine And Engine CoolingWheels
FIRST TIME DEALER REPLACED THE SERPENTINE BELT, AND SECOND TIME DEALER REPLACED NUTS AND BOLTS AND SERPENTINE BELTS. BUT SQUEAKING NOISE STILL OCCURRING. *AK
NHTSA ODI #10039963
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration