NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
277 reportsClear category filter96,500 miles · Dec 29, 2010
Fuel System, Gasoline
I AM THE ORIGINAL OWNER OF A 2001 FORD FOCUS PURCHASED IN MOORESVILLE NC THE VIN IS #[XXX]. THE FUEL PUMP HAD TO BE REPLACED. THE PUMP IS THE SAME ONE DESCRIBED IN THE FORD EXTENDED COVERAGE PROGRAM03N01 DATED 2003 AND SUPPLEMENTS 1 & 2 DATED JANUARY 2004. FORD SAID MY WAS NOT COVERED UNDER THE PROGRAM BECAUSE IT WAS BUILT IN A…
Read full complaint
I AM THE ORIGINAL OWNER OF A 2001 FORD FOCUS PURCHASED IN MOORESVILLE NC THE VIN IS #[XXX]. THE FUEL PUMP HAD TO BE REPLACED. THE PUMP IS THE SAME ONE DESCRIBED IN THE FORD EXTENDED COVERAGE PROGRAM03N01 DATED 2003 AND SUPPLEMENTS 1 & 2 DATED JANUARY 2004. FORD SAID MY WAS NOT COVERED UNDER THE PROGRAM BECAUSE IT WAS BUILT IN AUG. 2001 AFTER JUNE 13, 2001 CUT OFF. THE CAR WAS BUILT IN THE WAYNE ASSEMBLY PLANT, THE LOCATION OF THE FUEL PUMPS THAT FAIL. AFTER MORE SEARCH ON THE INTERNET , MY HUSBAND FOUND A TECHNICAL SERVICE BULLETIN ARTICLE #04-5-6 DESCRIBING THE PROCEDURE FOR INSTALLING A NEW DESIGN FUEL DELIVERY MODULE IN THE 2001-2002 FORD FOCUS. UNDER THE ISSUE IT STATES: THERE IS A NEW DESIGN FUELED DELIVERY MODULE AVAILABLE FOR SERVICE ON 2000-2002 FOCUS BUILT BEFORE 12/31/2001 AT WAYNE ASSEMBLY PLANT AND BUILT BEFORE 2/13/2001 AT HERMOSILLO PLANT. THE FORD MOTOR COMPANY SAID THAT MY DOES NOT QUALIFY FOR THE EXTENDED COVERAGE PROGRAM AS IT WAS BUILT IN AUG. 2001. WE THINK THAT BECAUSE THE CAR THIS THE PUMP DESCRIBED IN THE BULLETIN, WAS BUILT AT THE WAYNE ASSEMBLY PLANT WITHIN 2 MOS. OF THE JUNE 13, 2001 THAT FORD COULD HAVE COVE THE REPAIR BUT THE COMPANY WILL NOT. THIS IS AN $800 REPAIR. THE STEERING COLUMN LOCKING KEY CYLINDER IS ALSO IN NEED OF REPLACEMENT AGAIN. I NEED TO TURN THE KEY MANUALLY BACK TO A NEUTRAL POSITION FOR THE ENGINE TO RUN AFTER STARTING THE CAR. THIS IS THE THIRD LOCKING CYLINDER THAT I HAVE HAD INSTALLED IN MY CAR. I THINK FOUR CYLINDER IS A LITTLE MUCH FOR A 9 YEAR OLD CAR! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10373291
Mileage unknown · Dec 29, 2010
Fuel System, Gasoline
2001 FORD FOCUS. CONSUMER STATES FAULTY FUEL PUMP *TGW THE CONSUMER STATED AS SHE WAS DRIVING, THE VEHICLE BEGAN TO LOOSE POWER. THE VEHICLE BEGAN SURGING TO THE POINT WHERE SHE HAD TO PRESS THE ACCELERATOR ALL THE WAY DOWN TO THE FLOORBOARD AND THE VEHICLE WAS STILL BARELY MAINTAINING POWER TO GET OUT OF THE WAY OF TRAFFIC. TH…
Read full complaint
2001 FORD FOCUS. CONSUMER STATES FAULTY FUEL PUMP *TGW THE CONSUMER STATED AS SHE WAS DRIVING, THE VEHICLE BEGAN TO LOOSE POWER. THE VEHICLE BEGAN SURGING TO THE POINT WHERE SHE HAD TO PRESS THE ACCELERATOR ALL THE WAY DOWN TO THE FLOORBOARD AND THE VEHICLE WAS STILL BARELY MAINTAINING POWER TO GET OUT OF THE WAY OF TRAFFIC. THE FUEL FILTER WAS REPLACED AND SHE WAS ABLE TO GET THE VEHICLE BACK ONTO THE HIGHWAY. AS SHE BEGAN TO DRIVE, THE VEHICLE BEGAN TO SURGE AGAIN AND FINALLY THE VEHICLE SHUT OFF. AFTER DOING SOME RESEARCH, THE CONSUMER DISCOVERED THE VEHICLE WAS BUILT USING A FAULTY FUEL PUMP WHICH WAS FOUND TO BE A SAFETY ISSUE. NHTSA REQUIRED FORD TO ISSUE A CSP 03N01 WHICH REPLACED THE FUEL DELIVERY MODULE. THE CONSUMER STATED HER VEHICLE SHOULD HAVE BEEN INCLUDED, BUT BECAUSE THE VEHICLE WAS BUILT TWO MONTHS AFTER THE END OF THE CSP PRODUCTION DATE RANGE FORD WOULD NOT REPLACE THE FUEL PUMP FREE OF CHARGE. *JB
NHTSA ODI #10373129
145,000 miles · Jul 22, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT FUEL WAS NOT FLOWING INTO THE ENGINE PROPERLY. WHEN HE FIRST STARTED THE VEHICLE IT BEGAN TO FUNCTION PROPERLY, HOWEVER WITHIN A FEW MINUTES THE VEHICLE WOULD HESITATE. THE CONTACT CHANGED THE FUEL FILTER AND THE VEHICLE FUNCTIONED NORMALLY FOR A FEW DAYS. THE CONTAC…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT FUEL WAS NOT FLOWING INTO THE ENGINE PROPERLY. WHEN HE FIRST STARTED THE VEHICLE IT BEGAN TO FUNCTION PROPERLY, HOWEVER WITHIN A FEW MINUTES THE VEHICLE WOULD HESITATE. THE CONTACT CHANGED THE FUEL FILTER AND THE VEHICLE FUNCTIONED NORMALLY FOR A FEW DAYS. THE CONTACT NOTICED THAT THE VEHICLE WOULD HESITATE, LOSE POWER AND STALL WHENEVER IT WAS DRIVEN FOR MORE THAN AN HOUR AT 40 MPH. HE HAD TO SHIFT INTO NEUTRAL GEAR AND THEN BACK INTO DRIVE GEAR IN ORDER TO TEMPORARILY FIX THE FAILURE. WHEN THE CONTACT CALLED THE MANUFACTURER ABOUT RECALL 03V482000 (FUEL SYSTEM, GASOLINE), HE WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 150,000. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.
NHTSA ODI #10344660
80,000 miles · Jul 5, 2010
EquipmentFuel System, Gasoline
2001 FORD FOCUS HAS FAILED TWICE DURING LONG TRIPS. VEHICLE STUTTERS, STRUGGLES AND WILL MAINTAIN A SPEED OF ONLY 35-40 MPH DURING THESE EPISODES. STOPPING, RESTARTING WILL RESET AND ALLOW ANOTHER 5-10 MILES OF PROPER OPERATION AND THEN IN HAPPENS AGAIN. DURING BOTH INSTANCES IT WAS HOT AND HUMID. WAS ABLE TO CONTINUE TRIP BOTH …
Read full complaint
2001 FORD FOCUS HAS FAILED TWICE DURING LONG TRIPS. VEHICLE STUTTERS, STRUGGLES AND WILL MAINTAIN A SPEED OF ONLY 35-40 MPH DURING THESE EPISODES. STOPPING, RESTARTING WILL RESET AND ALLOW ANOTHER 5-10 MILES OF PROPER OPERATION AND THEN IN HAPPENS AGAIN. DURING BOTH INSTANCES IT WAS HOT AND HUMID. WAS ABLE TO CONTINUE TRIP BOTH TIMES, BUT THIS IS A SCARY SITUATION ON THE INTERSTATE!!!!! SUSPECTING FUEL CONTROL MODULE, BUT EVERYTHING TESTS FINE AT THE SHOP AND UNABLE TO RECREATE SYMPTOMS FOR MECHANIC. ONLINE FORD DATABASE SAYS THIS VEHICLE IS NOT INCLUDED ON THE RECALL FOR FUEL SYSTEM MALFUNCTION, BUT THE SYSMPTOMS ARE EXACTLY AS DESCRIBED IN THE COMPLAINT.
NHTSA ODI #10341478
123,150 miles · Jun 26, 2010
Fuel System, GasolineVehicle Speed Control
STICKING ACCELERATOR PEDAL 2001 FORD FOCUS SE. 2.0L L4 DOHC DRIVING DOWN THE INTERSTATE HEADING TO WORK AND WAS GOING TO SET THE CRUISE. I COULDN'T GET IT TO ACTIVATE TRIED SPEEDING UP AND SLOWING DOWN AND SETTING - DIDN'T OPERATE. A FEW MOMENTS LATER A CAR MERGED IN FRONT OF ME FROM THE ON RAMP. I SLOWED DOWN LET TR…
Read full complaint
STICKING ACCELERATOR PEDAL 2001 FORD FOCUS SE. 2.0L L4 DOHC DRIVING DOWN THE INTERSTATE HEADING TO WORK AND WAS GOING TO SET THE CRUISE. I COULDN'T GET IT TO ACTIVATE TRIED SPEEDING UP AND SLOWING DOWN AND SETTING - DIDN'T OPERATE. A FEW MOMENTS LATER A CAR MERGED IN FRONT OF ME FROM THE ON RAMP. I SLOWED DOWN LET TRAFFIC ON THE LEFT GO BY. I THEN MERGED TO LEFT LANE AND DEPRESSED THE ACCELERATOR AND IT STUCK AT/NEAR FULL THROTTLE. I TAPPED THE BRAKES TO SEE IF THE CRUISE HAD ENGAGED - NO CHANGE, LOOKED TO SEE IF THERE WAS AN OBSTRUCTION BY THE PEDAL - NONE FOUND, TRIED PULLING PEDAL BACK WITH MY FOOT - NO EFFECT, TRIED STOMPING ON ACCELERATOR TO SEE IF IT WOULD UNSTICK - NO CHANGE. I WAS NOW GOING OVER 80 MPH AND CLOSE TO REAR ENDING A CAR IN FRONT OF ME I STEPPED ON THE BRAKES HARD, IT DIDN'T SLOW DOWN. AT THIS POINT I TURNED THE IGNITION OFF AND MERGED TO THE RIGHT AND OFF TO THE EMERGENCY LANE. I OPENED THE HOOD AND INSPECTED THE ACCELERATOR LINKAGE AT THE THROTTLE PLATE. FOUND THE CRUISE CONTROL CABLE HAD DISCONNECTED AND GOT LODGED BETWEEN THE CRUISE CONTROL CABLE MOUNTING BRACKET AND THE THROTTLE PLATE ACTUATOR KEEPING THE THROTTLE PLATE AT OR NEAR FULL THROTTLE. I RECONNECTED THE CRUISE CABLE WENT TO WORK RETURNED HOME AND HAVE SET THE CAR ASIDE FOR FURTHER INSPECTION. *TR
NHTSA ODI #10340186
110,000 miles · Apr 20, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHEN SITTING STATIONARY WITH THE ENGINE RUNNING, THE VEHICLE WOULD STALL. THE CONTACT WAS ABLE TO PREVENT THE STALLING IF KEEPING SLIGHT PRESSURE ON THE ACCELERATOR BUT ONCE THE PRESSURE WAS RELEASED, THE ENGINE WOULD IDLE AND THEN STALL. THE CONTACT BELIEVED THE F…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHEN SITTING STATIONARY WITH THE ENGINE RUNNING, THE VEHICLE WOULD STALL. THE CONTACT WAS ABLE TO PREVENT THE STALLING IF KEEPING SLIGHT PRESSURE ON THE ACCELERATOR BUT ONCE THE PRESSURE WAS RELEASED, THE ENGINE WOULD IDLE AND THEN STALL. THE CONTACT BELIEVED THE FAILURE WAS DIRECTLY RELATED TO NHTSA RECALL CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE) BUT HAD NOT CONFIRMED IF HIS VEHICLE WAS INCLUDED IN THE RECALL AS OF YET. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 129,000.
NHTSA ODI #10326570
100,000 miles · Apr 7, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE ENGINE HESITATED AND THE SPEED DECREASED TO 30 MPH. SUDDENLY, THE VEHICLE STALLED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND AFTER WAITING FIFTEEN TO TWENTY MINUTES THE VEHICLE RESUMED TO NORMAL OPERATION. THE FAILURE OCCURRED …
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE ENGINE HESITATED AND THE SPEED DECREASED TO 30 MPH. SUDDENLY, THE VEHICLE STALLED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND AFTER WAITING FIFTEEN TO TWENTY MINUTES THE VEHICLE RESUMED TO NORMAL OPERATION. THE FAILURE OCCURRED APPROXIMATELY BETWEEN EVERY 10 TO 40 MILES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE SENSOR AND FUEL FILTER WERE REPLACED. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS 100,000. THE CURRENT MILEAGE WAS 130,000.
NHTSA ODI #10324152
30,000 miles · Mar 14, 2010
Electrical SystemFuel System, Gasoline
MY2001 FORD FOCUS ZX3( MANUAL TRANSMISSION )WITH OVER 105,000 MILES ON IT HAS HAD A ELECTRONIC THROTTLE PROBLEM SINCE IT HAD 30,000 MILES ON IT. INTERMITTENTLY THE ENGINE SPEED WOULD NOT DECREASE WHEN YOUR FOOT IS TAKEN OFF THE ACCELERATOR PEDAL. THE CAR WOULD ACT LIKE THE CRUISE CONTROL WAS ENGAGED. THE CAR COULD BE CONTROLLED …
Read full complaint
MY2001 FORD FOCUS ZX3( MANUAL TRANSMISSION )WITH OVER 105,000 MILES ON IT HAS HAD A ELECTRONIC THROTTLE PROBLEM SINCE IT HAD 30,000 MILES ON IT. INTERMITTENTLY THE ENGINE SPEED WOULD NOT DECREASE WHEN YOUR FOOT IS TAKEN OFF THE ACCELERATOR PEDAL. THE CAR WOULD ACT LIKE THE CRUISE CONTROL WAS ENGAGED. THE CAR COULD BE CONTROLLED BY HEAVY BRAKING OR DEPRESSING THE CLUTCH. IT WAS TAKEN INTO THREE DIFFERENT FORD DEALER AT LEAST SEVEN DIFFERENT TIMES ONLY ONCE DID THEY CLAIM TO SEE THE PROBLEM. THAT TIME THE MECHANIC SHOW ME DISCONNECTING A ELECTRICAL PLUG UNDER THE HOOD CAUSED THE THROTTLE CONTROLS TO GO TO A FAIL SAFE MODE MAKING THE PROBLEM DISAPPEAR FOR PERIOD OF TIME(DAYS).I WAS TOLD TO BRING IT BACK IN WHEN IT HAPPENED AGAIN. I DID THAT, MECHANIC WAS KNOW LONGER WITH THE DEALERSHIP. SEVERAL PARTS WERE CHANGED SEVERAL DIFFERENT TIMES BUT DID NOTHING TO CORRECT THE PROBLEM. WHEN THE PROBLEM IS PRESENT THE ENGINE SPEED WILL DECREASE TO A FAST IDLE ONCE THE CAR COMES TO A COMPLETE STOP. THE PROBLEM WILL GO AWAY SOMETIMES AFTER SHUTTING OFF THE ENGINE AND RESTARTING BUT NOT ALWAYS. *TR
NHTSA ODI #10319550
Mileage unknown · Mar 3, 2010
Electrical SystemFuel System, Gasoline
I HAVE HAD NUMEROUS STALLING CONDITION WHILE DRIVING THAT HAVE BEEN FRIGHTENING. SEVERAL FUEL MODULES HAVE BEEN REPLACED AS WELL AS HARNESS REPAIRS. THE DEALER HAS FINALLY REPLACED THE HARNESS GOING TO THE FUEL PUMP STATING IT HAD BEEN RUBBING AGAINST THE BODY AND GROUNDING OUT. I AM NOT SURE THIS WILL FIX THE PROBLEM SINCE I…
Read full complaint
I HAVE HAD NUMEROUS STALLING CONDITION WHILE DRIVING THAT HAVE BEEN FRIGHTENING. SEVERAL FUEL MODULES HAVE BEEN REPLACED AS WELL AS HARNESS REPAIRS. THE DEALER HAS FINALLY REPLACED THE HARNESS GOING TO THE FUEL PUMP STATING IT HAD BEEN RUBBING AGAINST THE BODY AND GROUNDING OUT. I AM NOT SURE THIS WILL FIX THE PROBLEM SINCE IT IS INTERMITTENT. IT APPEARS THE DEALER HAS DONE SEVERAL WIRING HARNESS REPAIRS LEADING TO THE FUEL PUMP.
NHTSA ODI #10316491
120,000 miles · Mar 3, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH. THE ENGINE LOSS POWER WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE OCCURRED WHENEVER TRAVELING AT THE SPEED RATE OF 65 MPH. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE VEHICLE HAS NOT…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH. THE ENGINE LOSS POWER WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE OCCURRED WHENEVER TRAVELING AT THE SPEED RATE OF 65 MPH. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 120,000. THE CURRENT MILEAGE WAS 128,000.
NHTSA ODI #10316129
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration