NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
496 reportsClear category filterMileage unknown · May 20, 2013
Electrical SystemEngine And Engine Cooling
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE FLOOR MAT BECAME WET. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CONDENSER BOX TO THE AIR CONDITIONING UNIT WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE FLOOR MAT BECAME WET. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CONDENSER BOX TO THE AIR CONDITIONING UNIT WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS UNKNOWN. *TR
NHTSA ODI #10512897
80,000 miles · May 8, 2013
Electrical System
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT WAS ABLE TO MOVE THE KEY IN THE IGNITION, BUT THERE WAS NO RESPONSE. THE FAILURE RECURRED FREQUENTLY AND WITHOUT WARNING. THE CONTACT STATED THAT THE BATTERY WAS DRAINED AND HE WOULD OFTEN JUMP START THE VEHICLE, WHICH WOULD …
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT WAS ABLE TO MOVE THE KEY IN THE IGNITION, BUT THERE WAS NO RESPONSE. THE FAILURE RECURRED FREQUENTLY AND WITHOUT WARNING. THE CONTACT STATED THAT THE BATTERY WAS DRAINED AND HE WOULD OFTEN JUMP START THE VEHICLE, WHICH WOULD TEMPORARILY RESOLVE THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP FOR DIAGNOSIS BUT WERE THE TECHNICIANS WERE UNABLE TO DUPLICATE THE FAILURE. THE BATTERY WAS REPLACED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 85,000.
NHTSA ODI #10511152
67,014 miles · Mar 9, 2013
Electrical SystemLatches/locks/linkages
THE RIGHT FRONT DOOR LOCK IS JAMMED OR STUCK, I CANNOT OPEN THE DOOR FROM THE INSIDE OR OUTSIDE,THE OTHER 3 DOOR LOCKS WORK FINE. *TR
NHTSA ODI #10502216
65,850 miles · Dec 12, 2012
Electrical SystemExterior Lighting
HEADLIGHT FAILURE. WITH ENGINE RUNNING, WHEN THE HEADLIGHT SWITCH IS TURNED ON, THE HEADLIGHTS (BOTH) DO NOT ALWAYS GO ON. ALSO, AFTER BEING ON FOR A WHILE (OFTEN WITHIN 10 MINUTES, ALMOST ALWAYS WITHIN 20 MINUTES), BOTH HEADLIGHTS WILL SUDDENLY TURN OFF ON THEIR OWN. WHEN HEADLIGHTS GO OFF, DASHBOARD LIGHTS, AND OTHER OUTSID…
Read full complaint
HEADLIGHT FAILURE. WITH ENGINE RUNNING, WHEN THE HEADLIGHT SWITCH IS TURNED ON, THE HEADLIGHTS (BOTH) DO NOT ALWAYS GO ON. ALSO, AFTER BEING ON FOR A WHILE (OFTEN WITHIN 10 MINUTES, ALMOST ALWAYS WITHIN 20 MINUTES), BOTH HEADLIGHTS WILL SUDDENLY TURN OFF ON THEIR OWN. WHEN HEADLIGHTS GO OFF, DASHBOARD LIGHTS, AND OTHER OUTSIDE LIGHTS, REMAIN ON. WHEN THE SWITCH IS ON, BUT HEADLIGHTS HAVE GONE OFF, IF THE HIGH BEAMS ARE TOGGLED ON AND THEN OFF, THE HEADLIGHTS WILL GO ON (FOR A WHILE). THIS SEQUENCE OCCURS REPEATEDLY. UNLESS IT IS DARK (E.G. IF IN TWILIGHT OR IN DAYTIME RAIN), OR UNLESS I CAN SEE THE HEADLIGHT REFLECTIONS, I HAVE NO WAY OF KNOWING THE STATUS OF MY HEADLIGHTS. DEALERSHIP INITIALLY REPLACED A RELAY, WITHOUT SOLVING PROBLEM. DEALERSHIP THEN REPLACED THE "MULTI-FUNCTION SWITCH" CONTROLLING TURN SIGNALS AND HIGH BEAMS, WITH SEEMING SUCCESS. I AM IN POSSESSION OF THE FAILED ORIGINAL-EQUIPMENT "MULTI-FUNCTION SWITCH". DEALERSHIP WAS UNDERSTANDING AND HELPFUL, BUT WOULD NOT TREAT THIS INTERMITTENT, SUDDEN, REPEATED HEADLIGHT FAILURE AS A CRITICAL SAFETY ISSUE UNDER WARRANTY. THIS VEHICLE HAS BEEN SUBJECT TO GAS PUMP FAILURE, AND TO FRONT SUSPENSION SPRING BREAKAGE, WHICH WERE COVERED UNDER WARRANTY. [NOTE ALSO THAT CAR DESIGN DOES NOT ALLOW HEADLIGHTS TO TURN ON OR STAY ON WHEN ENGINE IS OFF - THIS MAY SAVE ACCIDENTAL BATTERY DRAIN, BUT DEPRIVES OPERATOR OF ILLUMINATION OR SIGNALING ABILITY THAT MAY BE NEEDED IN EMERGENCY SITUATIONS.]
NHTSA ODI #10489621
100,000 miles · Dec 3, 2012
Electrical SystemFire
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH AND SMELLED A BURNING ODOR JUST AS ALL OF THE INSTRUMENT PANEL GAUGES REDUCED TO ZERO ABNORMALLY. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 02V288000 (ELECTRICAL SYSTEM:BATTERY:CABLES) BUT WAS ADVISED BY THE MANUFACTURER THAT THE RECALL WA…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH AND SMELLED A BURNING ODOR JUST AS ALL OF THE INSTRUMENT PANEL GAUGES REDUCED TO ZERO ABNORMALLY. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 02V288000 (ELECTRICAL SYSTEM:BATTERY:CABLES) BUT WAS ADVISED BY THE MANUFACTURER THAT THE RECALL WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10487148
128,000 miles · Nov 29, 2012
Electrical System
ATTEMPTED TO START MY CAR. INSERTED KEY INTO THE IGNITION AND A WARNING CHIME BEGAN. STEERING WHEEL WAS LOCKED AND I CANNOT MOVE IT. IGNITION WILL NOT TURN. CANNOT DRIVE AT THIS TIME. *TR
NHTSA ODI #10486503
148,000 miles · Aug 9, 2012
Electrical System
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE IGNITION CYLINDER WOULD NOT RELEASE THE KEY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC TO HAVE THE IGNITION CYLINDER REPAIRED. THE CONTACT STATED THE IGNITION CYLINDER HAD NO PROBLEMS AFTER THE REPAIR. THE FAILURE MILEAGE WAS 148,000.
NHTSA ODI #10470001
130,000 miles · Jul 13, 2012
Electrical System
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE KEYS BECAME STUCK IN THE IGNITION CYLINDER AND COULD NOT BE USED TO START THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A REPAIR SHOP OR TO THE DEALER FOR INSPECTION. THE VEHICLE WAS REPAIRED BY A LOCKSMITH WHO REPLACED THE IGNITION CYLINDER AND ISSUED A NEW KEY. TH…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE KEYS BECAME STUCK IN THE IGNITION CYLINDER AND COULD NOT BE USED TO START THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A REPAIR SHOP OR TO THE DEALER FOR INSPECTION. THE VEHICLE WAS REPAIRED BY A LOCKSMITH WHO REPLACED THE IGNITION CYLINDER AND ISSUED A NEW KEY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE PROBLEM COULD HAVE BEEN RELATED TO A DEFECTIVE SIDE BAR IN THE IGNITION CYLINDER LOCK. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 140,000. THE FAILURE MILEAGE WAS 130,000. ...UPDATED 08-10-12 *BF THE CONSUMER STATED THE COST OF THE REPAIR WAS 177.00. UPDATED 08/13/2012 *JS
NHTSA ODI #10465517
103,000 miles · May 28, 2012
Electrical SystemSteering
THE KEY FOR MY FORD FOCUS WILL GO INTO THE IGNITION BUT NOT TURN. I HAVE TRIED TO TURN THE STEERING WHEEL BUT IT STILL WON'T GET THE KEY TO TURN IN THE IGNITION. AFTER DOING SOME RESEARCH, I AM FINDING THAT THIS IS A MAJOR AND VERY COMMON COMPLAINT WITH FORD FOCUS OWNERS AND FORD WILL NOT ISSUE A RECALL. THE CAR IS NOT DRIVABLE …
Read full complaint
THE KEY FOR MY FORD FOCUS WILL GO INTO THE IGNITION BUT NOT TURN. I HAVE TRIED TO TURN THE STEERING WHEEL BUT IT STILL WON'T GET THE KEY TO TURN IN THE IGNITION. AFTER DOING SOME RESEARCH, I AM FINDING THAT THIS IS A MAJOR AND VERY COMMON COMPLAINT WITH FORD FOCUS OWNERS AND FORD WILL NOT ISSUE A RECALL. THE CAR IS NOT DRIVABLE AND IN ORDER TO GET IT TO A REPAIR SHOP WE WILL HAVE TO TOW IT WHICH WILL BE ANOTHER EXPENSE. IF FORD IS AWARE OF THIS PROBLEM AND WILL NOT DO ANYTHING TO RECALL IT, SOMETHING NEEDS TO BE DONE. *TR
NHTSA ODI #10459827
148,218 miles · Apr 27, 2012
Electrical System
WENT TO START MY CAR THIS MORNING AND THE KEY WOULD NOT TURN IN THE IGNITION. AFTER DOING SOME GOOGLE RESEARCH, FOUND THAT THIS IS A VERY COMMON ISSUE WITH THE FOCUS, AND HAS TO DO WITH PARTS IN THE IGNITION SWITCH BECOMING STUCK. I WAS ABLE TO GET THE KEY TO TURN EVENTUALLY BY BANGING ON IT, AND HAVE NOW LEFT THE KEY IN THE IGN…
Read full complaint
WENT TO START MY CAR THIS MORNING AND THE KEY WOULD NOT TURN IN THE IGNITION. AFTER DOING SOME GOOGLE RESEARCH, FOUND THAT THIS IS A VERY COMMON ISSUE WITH THE FOCUS, AND HAS TO DO WITH PARTS IN THE IGNITION SWITCH BECOMING STUCK. I WAS ABLE TO GET THE KEY TO TURN EVENTUALLY BY BANGING ON IT, AND HAVE NOW LEFT THE KEY IN THE IGNITION TO AVOID THE PROBLEM OCCURRING AGAIN. *TR
NHTSA ODI #10456652
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration