2015 Ford Flex

I TOOK IT TO RUSSELL AND SMITH FORD IN HOUSTON, TX. THEY SAID THE BATTERY WAS THE ISSUE. A WEEK LATER SAME PROBLEM, IT CRANKS BUT WONT TURNOVER. IT IS NOW AT STERLING MCCALL FORD IN HOUSTON WITH THE SAME PROBLEM. I WILL ATTACH THEIR DIAGNOSIS. I HAVE 57, 000 MILES ONLY ON THIS VEHICLE. I HOPE THAT THIS WILL ALL GO OUT TO ALL FORD DEALERSHIPS..THANK YOU

ON OCTOBER 18, 2019, WHILE ENTERING A PARKING SPACE AT THE IKEA PARKING LOT, MY CAR EXPERIENCE A LOSS OF POWER, CAUSING THE ENGINE TO STALL. I TRIED TO START IT UP ABOUT 10 TIMES, AND NOTHING HAPPENED - IT FAILED TO START EVERY TIME. AFTER ABOUT 2 HOURS OF TRYING, I FINALLY HAD TO HAVE IT TOWED TO MY HOUSE. WHEN I PERFORMED A OBD-II SYSTEM SCAN, WITH MY SCANNER, I GOT A FAULT CODE OF P0627 (FUEL PUMP A CONTROL CIRCUIT) I TOOK THE CAR TO THE FORD DEALER, AND EXPLAINED THE PROBLEM. AFTER TWO HOURS, THEY CALLED ME AND SAID THEIR TESTS REVEALED NO FAULT CODES. BASED ON THE ISSUE I DESCRIBED, THEY SAID THAT IF I WANTED, THEY CAN CHANGE THE FUEL PUMP, BUT I WOULD HAVE TO PAY $100 DEDUCTIBLE UNDER THE EXTENDED WARRANTY PLAN. THE THINK THAT MAY FIX THE ISSUE OF STALLING, OR NOT STARTING. MY ISSUE IS THAT IF THE PROBLEM IS NOT FIXED, IT MAY INCREASE THE RISK OF A CRASH, AT ANY GIVEN TIME, AND WITHOUT NOTICE. GIVEN THE FACT THAT THERE ARE OTHER COMPLAINTS ABOUT THIS SAME ISSUE, I THINK THAT A GENERAL RECALL FOR THIS MAKE/MODE/YEAR CAR SHOULD BE INITIATED, BEFORE SOMEONE LOSES THEIR LIFE OVER IT.

MY 2015 FORD FLEX WAS EXHIBITING SYMPTOMS DESCRIBED IN THE FORD SAFETY RECALL 16S31. THE ENGINE STALLED WHILE DRIVING WITH NO WARNING 5 TIMES OVER THE PAST TWO YEARS OF OWNERSHIP WITH THE MOST RECENT OCCURRING ON 6/20/2019 AT 8:15 AM. EACH INCIDENT WAS AT DIFFERENT SPEEDS (30 - 70MPH) BUT NO WARNING PREFACED THE STALL AND YOU HAD TO CUT THE POWER OFF AND TURN IT BACK ON FOR THE CAR TO START AGAIN. TWO OF THE STALLS WERE DURING TURNING OPERATIONS WHILE OTHERS WERE WHILE DRIVING STRAIGHT. ON OTHER OCCASIONS THE ENGINE DID NOT START VIA REMOTE START, HOWEVER NO DATES RECORDED. THIS RECALL, THAT DESCRIBES THE EXACT SYMPTOMS, STATES THAT IT DOES NOT COVER MY VEHICLE BECAUSE I HAVE A DIFFERENT ENGINE. HOWEVER, THE PART IN THE RECALL IS THE FUEL PUMP CONTROL MODULE. MY 2015 FORD FLEX HAD THE FUEL PUMP CONTROL MODULE AA8A-9D412-CA WITH THE SUPPLIER PART NUMBER 2177806-5E. AS PER THE RECALL, THIS IS A PART THAT NEEDS TO BE REPLACED. I JUST HAD THE DEALER REPLACE IT WITH THE NEW PART AA8Z-9D370-B, SERVICE HISTORY BELOW: WE HAVE TAKEN THE VEHICLE TO TWO SEPARATE FORD DEALERSHIPS OVER THE PAST YEAR DUE TO THIS ISSUE. NEITHER DEALERSHIP RECOGNIZED THIS ISSUE BECAUSE OUR VIN NUMBER WASN'T ON THE LIST OF VINS PROVIDED BY FORD. I PAID FOR THE REPAIR RECOMMEND IN SAFETY RECALL 16S31 OUT OF POCKET SO THAT MY VEHICLE WILL BE SAFE TO DRIVE AGAIN. THE FIRST DEALERSHIP REPLACED THE THROTTLE BODY AND CHARGED US FOR IT. AFTER THE ISSUE OCCURRED AGAIN, THE SECOND DEALERSHIP AGAIN REPLACED THE THROTTLE BODY SINCE THE THROTTLE BODY WAS STILL UNDER WARRANTY FROM THE FIRST REPAIR. IT APPEARS THE RECALL DOES NOT COVER ALL OF THE AFFECTED VEHICLES. THERE ARE OTHER FORD FLEX THAT HAVE THESE FAULTY PARTS.

IN OCTOBER 2018, OUR FORD FLEX WAS PARKED IN THE DRIVEWAY WHEN WE TRIED TO START IT AND IT DID A MINOR CRANK AND THEN NOTHING. IT WOULDN'T START OR DO ANYTHING. WORKED FINE THE NIGHT BEFORE. HAD TO HAVE THE CAR TOWED AND TURNS OUT THE FUEL PUMP CONTROL MODULE FAILED ON IT COSTING $650 TO REPLACE THE PART. SEEMS LIKE THIS IS A MAJOR ISSUE WITH THESE CARS AND I DON'T UNDERSTAND WHY THERE ISN'T A RECALL OR REFUND ON THE REPAIRS AS THERE WAS ON THE TURBOCHARGED ONES. I HAVE HAD ONE PROBLEM AFTER ANOTHER WITH THIS VEHICLE AND TOLD THAT EACH PART "SOMEHOW FAILED" BEFORE IT'S TIME WITH NO OTHER EXPLANATION THAN BAD PARTS. THE WHEEL BEARING FAILED, THE TOUCH ON THE TOUCH SCREEN HAS FAILED, THE ELECTRIC SEAT FAILED AND NOW THE A/C COMPRESSOR HAS FAILED AS WELL. I AM READY TO GET RID OF THIS MONEY PIT CAR.

WRENCH LIGHT APPEARS ON DASH AND THE CAR LOSES ALL POWER - KNOWN AS "LIMP HOME" MODE. CODES CLEAR UPON RESTART. TOOK IT TO DEALER AFTER FREEWAY INCIDENT ON 2/17/19, DEALER FOUND NO CODES, STATED IT WAS MOTOR MOUNT. GOT THE CAR BACK ON 2/25/17, AND IT HAPPENED AGAIN WITHIN 30 MILES. WAS ABLE TO PULL CODE WITH MY OWN SCAN TOOL - P2111. KNOWN ERROR IN THROTTLE. THIS HAPPENED WHILE TRAVELING APPROXIMATELY 40 MPH, AND ONCE ON EXPRESSWAY, TWO ADDITIONAL TIMES AT AROUND 20 MPH

OUR 2015 FORD FLEX RECENTLY DIED WHEN WE WERE DRIVING IN TRAFFIC, WITH NO WARNING WHEN WE WERE DRIVING WITH OUR 2 YOUNG CHILDREN. THE FORD FLEX ONLY HAS ~45K MILES ON IT AND HAS BEEN SERVICED REGULARLY. TURNS OUT IT IS BAD PART (FUEL PUMP ELECTRIC MODULE (PEM)) THAT IS RECALLED BY FORD IN THE 2015 FLEX. THE RECALL WAS STARTED IN 2016 AND OUR FLEX DIED IN 2018. I WAS TOLD BY THE DEALER AND LATER BY FORD SERVICE THAT OUR CAR IS NOT COVERED BECAUSE THE VIN IS NOT INCLUDED IN THE RECALL. SO WHILE SOME 2015 FORD FLEXS' HAD THIS EXACT PART COVERED UNDER WARRANTY OURS WAS NOT. WE HAD TO HAVE IT TOWED INTO THE DEALER, SAN TAN FORD IN GILBERT AZ, AND THEN PAY THEM ABOUT $400 FOR THE REPAIR. THE DEALER WAS GREAT BUT IT IS NOT RIGHT FORD DOES NOT COVER THIS PART ON OUR PARTICULAR CAR SINCE IT IS EXACTLY THE MAKE, MODEL, YEAR AND PART THAT IS COVERED UNDER THE WARRANTY. BELOW IS A COPY OF THE RECALL FROM THE NHTSA.GOV WEBSITE. SUMMARY: FORD MOTOR COMPANY (FORD) IS RECALLING CERTAIN MODEL YEAR 2013-2015 FORD TAURUS, FORD FLEX, LINCOLN MKS AND LINCOLN MKT VEHICLES EQUIPPED WITH 3.5L GTDI ECOBOOST ENGINES AND 2013-2015 FORD TAURUS POLICE INTERCEPTOR VEHICLES. A COMPONENT WITHIN THE FUEL PUMP ELECTRIC MODULE (PEM) MAY OVERHEAT CAUSING A LOSS OF ELECTRICAL POWER TO THE FUEL PUMP. CONSEQUENCE: A LOSS OF POWER TO THE FUEL PUMP WILL CAUSE THE ENGINE TO STALL OR PREVENT THE VEHICLE FROM STARTING, INCREASING THE RISK OF A CRASH.