2009 Ford Flex

CAR SAID '15 MILES TO EMPTY' AND GAUGE NEEDLE WAS JUST BELOW A QUARTER, THEN NEEDLE DROPPED TO EMPTY AND COMPUTER ESTIMATE WENT DOWN TO '3 MILES TO EMPTY' WITHIN A MILE..THEN SHUT DOWN AND LIMPED OFF ROAD. LEFT ME STRANDED ON THE SIDE OF A BUSY CITY FREEWAY IN A VERY DANGEROUS LOCATION, UNTIL I COULD GET SOMEONE TO BRING GAS TO REFUEL. REPEATED THIS THE NEXT TIME THE GAS WAS DOWN TO A QUARTER TANK. I WATCHED IT CAREFULLY AND SAW IT RECALCULATE FROM APPROX 15 TO EMPTY, TO 0 IN LESS THAN 4 MILES. GOT TO A GAS STATION IN TIME BEFORE THE CAR SHUT OFF. NOW I FILL IT UP AT 50 MILES UNTIL EMPTY TO AVOID RUNNING INTO THIS ISSUE. JUST TO ILLUSTRATE, ANOTHER OWNER MADE A VIDEO OF THE SAME SITUATION HAPPENING TO THEM: HTTPS://WWW.YOUTUBE.COM/WATCH?V=XWAMOBVHGUQ

ENGINE STUMBLED AND THEN LOST POWER. IT RE-STARTED BUT IDLED AT 750RPM. CAR WOULD NOT ACCELERATE. PLACING THE CAR INTO NEUTRAL AND DEPRESSING THE ACCELERATOR DID NOT INCREASE THE ENGINE SPEED. THIS PERSISTED ABOUT 3-4 MINUTES. AFTERWARDS, THE ENGINE SPEED RESPONDED TO THE ACCELERATOR, AND WHEN PLACED IN GEAR, ACCELERATED NORMALLY. THIS HAS HAPPENED THREE TIMES IN THE PAST YEAR. *TR

OUR 2009 FORD FLEX HAS SHUT OFF ON 4 OCCASIONS WHILE WE WERE DRIVING SINCE NOV. 2013 (11/29/2013, 12/18/2013, 12/28/2013, 4/15/2014). ON 3 OF THE 4 OCCASIONS WE WERE ON INTERSTATE HIGHWAYS (495 IN MA, 95 IN CT, 81 IN PA) WHICH WAS SCARY AND COULD HAVE BEEN DEADLY. ON 2 OF THE 4 SHUT DOWNS THE CAR WOULD NOT RESTART SO WE HAD TO BE TOWED. WE NOTICED THAT ONCE THE CAR WAS TAKEN OFF THE FLATBED, IT STARTED RIGHT UP. THAT TELLS ME THAT THE GAS MUST HAVE MOVED TO WHERE IT WAS NEEDED. ON EACH OCCURRENCE THE GAS GAUGE READ HALF A TANK OR JUST SLIGHTLY BELOW. THE CAR JUST SHUT OFF WHICH MADE IT DIFFICULT TO STEER. LUCKILY WE WERE ABLE TO COAST TO THE BREAKDOWN LANE AND WEREN'T IN SPEEDING, HEAVY TRAFFIC. ON 12/21/13 THE DEALERSHIP REPLACED THE THROTTLE BODY. ON 12/28/13 THE CAR SHUT DOWN AGAIN AND WAS TOWED TO THE DEALERSHIP. THE FUEL SENDER CONCERN WAS VERIFIED, FUEL LEVEL WAS INACCURATE, THE LEFT HAND FUEL SENDER WAS ERRATIC. THEY REMOVED THE FUEL TANK, REPLACED THE LEFT FUEL SENDER. ON 4/15/14 THE CAR SHUT DOWN AGAIN. THE DEALERSHIP FOUND THAT THE RIGHT SIDE OF THE GAS TANK WAS EMPTY WHILE THE LEFT SIDE WAS FULL. THE FUEL SENDER ASSEMBLIES WERE REMOVED AND THE RIGHT ONE WAS NOT READING PROPERLY. THE FUEL PUMP MODULE WAS ALSO REPLACED. WE DO NOT TRUST THIS CAR AND ARE AFRAID FOR THE NEXT OWNER WHEN WE TRADE IT IN OR SELL IT. IS THIS A DESIGN FLAW? *TR

THE FORD PANEL NEAR THE DRIVER AND PASSENGER WINDOW CONTINUES TO COME APART. AS FAR AS THE VEHICLE'S FUEL. THE FIRST TIME I WAS AT A GAS STATION. I PUT GAS IN MY CAR. I GOT BACK IN THE VEHICLE AND MY GAUGE WAS STILL ON EMPTY. SO I GOT WORRIED. THEN I WENT TO A DIFFERENT GAS PUMP AND PUT MORE GAS IN THERE. I STARTED MY CAR AND IT WAS STILL ON EMPTY. I DROVE AROUND THE PARKING LOT TO SEE WHAT WOULD HAPPEN AND ABOUT 2 MINUTES LATER MY GAS GAUGE WAS 3/4 FULL. THIS WAS IN NOVEMBER. THEN ABOUT 5 TIMES AFTER THAT. I WILL BE ON THE LAST MARK BEFORE EMPTY AND NOT ONLY DOES IT GO FROM 80-70 MILES TO E TO COMPLETE 0 MILES, BUT MY GAUGE GOES FROM THAT MARK TO PASS THE E. I WAS DRIVING MY VEHICLE AND IT WENT FROM THAT SAME MARK ( THE MARK RIGHT BEFORE THE E) AND JUST RAN OUT OF GAS. I HAVE TOOK IT TO THE SHOP TWICE AND THAT CAN'T FIND A CODE. THEY SAID IF IT HAPPENS AGAIN THEN BRING IT BACK IN. BUT THE INCONVENIENCE I HAVE TO WAIT UNTIL I HAVE TIME. IT HAPPENED TODAY FEB 10 2014 AND I RACED TO A GAS STATION. I DON'T WANT IT TO HAPPEN AND I'M DRIVING IN TRAFFIC AND HAVE AN ACCIDENT BECAUSE MY GAS GAUGE IS WRONG AND I STOP IN THE MIDDLE OF TRAFFIC. I DON'T WANT TO GET STRANDED SOMEWHERE EITHER BECAUSE I HAVE A KID. I HAVE SEEN SAME COMPLAINTS ABOUT THIS VEHICLE. SO I'M VERY CONCERNED. *TR

CHECK ENGINE LIGHT WENT ON AND WHEN DIAGNOSED IT WAS ONE OF THE OXYGEN SENSORS. IT HAD TO BE REPLACED IN ORDER FOR THE REST OF THE SAFETIES TO OPERATE PROPERLY. IT WAS A DEFECTIVE PART THAT COST OVER $400 TO REPLACE. WARRANTY WAS DECLINED, HOWEVER, THE DESIGN LIFE OF THE PART MUST BE IN EXCESS OF 150000 MILES. IF THIS PART WERE FAILING ALL THE TIME, THERE WOULD BE A RECALL. MY DEFECTIVE PART WAS NOT REPLACED BY FORD AS IT SHOULD HAVE BEEN. THERE ARE NO MOVING PARTS, IT SHOULD NOT WEAR OUT. *TR