IllustrationRANDOMLY MY STEERING WHEEL WILL GET LOCKED UP WHEN DRIVING. IT MAKES IT HARD TO TURN. THE SAFETY WARNING COMES ON. SOMETIMES I CAN TURN THE VEHICLE OFF AND BACK ON A HALF HOUR LATER AND THE PROBLEM JUST DISAPPEARS. SOMETIMES IT TAKES LONGER.
2012 Ford Fiesta
Owner reports · Recalls · Investigations
More warning signs than most Fiesta years
Owner complaints for the 2012 Ford Fiesta are substantially higher than the model-year median of 74.
About this comparison →How this year compares
Owner complaints by model year
Compare all Fiesta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1160–25K
15125–50K
10550–75K
5775–100K
47100–150K
15150K+
491 reports with mileage · 126 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 274 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports5 fire reports13 injury reports
Steering complaints
13 reportsWE BOUGHT OUR 2012 FORD FIESTA ABOUT A 2 YEARS AGO. SINCE THEN WE HAVE TAKEN IT TO 2 MECHANICS AND THE PROBLEMS PERSIST. THE TRANSMISSION SHUDDERS AND LURCHES FORWARD AT RANDOM. THE CAR HAS MAJOR ISSUES ACCELERATING AND HAS ALMOST GOTTEN US IN MANY ACCIDENTS. THE CAR SEEMS LIKE IT GETS STUCK IN A LOWER GEAR AND WILL NOT MOVE OUT…
Read full complaint
WE BOUGHT OUR 2012 FORD FIESTA ABOUT A 2 YEARS AGO. SINCE THEN WE HAVE TAKEN IT TO 2 MECHANICS AND THE PROBLEMS PERSIST. THE TRANSMISSION SHUDDERS AND LURCHES FORWARD AT RANDOM. THE CAR HAS MAJOR ISSUES ACCELERATING AND HAS ALMOST GOTTEN US IN MANY ACCIDENTS. THE CAR SEEMS LIKE IT GETS STUCK IN A LOWER GEAR AND WILL NOT MOVE OUT OF IT EVEN AS YOUR FOOT IS PRESSED ALL THE WAY DOWN.
MY CAR SHUDDERS A LOT WHEN STOPPING ESPECIALLY ON THE HIGHWAY OR MERGING OFF THE HIGHWAY' ALSO HAPPENS IN CITY OR SUBURBS IF GOING OVER 40 MPH; , GEAR SLIPS WHEN STATIONERY BEFORE HITTING GAS TO MOVE CAR, SPEED SLOWS DOWN OR HESITATES WHEN HITTING GAS PEDAL, TOOK TO DEALERSHIP MANY TIMES AND NOTHING EVER GOT FIXED. FORD SENT A L…
Read full complaint
MY CAR SHUDDERS A LOT WHEN STOPPING ESPECIALLY ON THE HIGHWAY OR MERGING OFF THE HIGHWAY' ALSO HAPPENS IN CITY OR SUBURBS IF GOING OVER 40 MPH; , GEAR SLIPS WHEN STATIONERY BEFORE HITTING GAS TO MOVE CAR, SPEED SLOWS DOWN OR HESITATES WHEN HITTING GAS PEDAL, TOOK TO DEALERSHIP MANY TIMES AND NOTHING EVER GOT FIXED. FORD SENT A LETTER STATING THAT I WOULD GET DOUBLE THE WARRANTY ON THE TRANSMISSION AND I WILL RECEIVE A LETTER STATING THIS, BUT WILL NOT CONFIRM ANYMORE. PROBLEMS OCCURED AFTER I PURCHASED THIS FIESTA IN JUNE 2012 BUT DID NOT KNOW THAT IT WAS NOT WORKING PROPERLY UNTIL THE RECALL CAME OUT AND I TOOK IT IN FOR THE FIRST TIME. I WAS TOLD THAT I WAS "TOO LATE" TO GET ANYTHING TO FIX IT OR HAVE IT TAKEN BACK BY FORD BECAUSE I HAD WAITED A YEAR. I DIDN'T EVEN KNOW THAT THE CAR WAS WORKING POORLY! IT WAS BRAND NEW AND I THOUGHT THIS WAS THE WAY IT WAS OKAY TO DRIVE BECAUSE THE PROBLEMS WERE NOT AS NOTICABLE. IT GOT MUCH WORSE AS TIME PASSED. I HAVE REPAIR INVOICES BUT I NEED TO FINE THEM. I WANT MY COMPLAINT FILED NOW SO THAT I AM NOT FORGOTTEN. I HAD A LEMON LAWYER CONTACT ME NAMED TROTT, WHO TOLD ME THAT IF I ACCEPTED A CLAIM HE WOULD PUT IN FOR ME, IT WOULD BE THE BEST DEAL I WOULD GET IN TERMS OF ATTONEMENT. HE SAID HE GOT $8K AND TOOK $3K FOR HIS WORK. I RECEIVED A CHECK FOR $5K. I ASKED MR.TROTT IF I SHOULD GET THE CAR REPAIR WITH THIS MONEY. HE SAID PEOPLE ARE KEEPING THE MONEY AND GETTING RID OF THEIR CARS. I KEPT MY CAR BECAUSE I CANNOT AFFORD TO BUY ANOTHER ONE REGARDLESS OF THE $5K I RECEIVED. I DO NOT USE MY CAR VERY MUCH NOW BECAUSE I DO NOT LIKE THAT IT SHUDDERS WHEN I USE THE BRAKES AND THAT IT SLOWS DOWN WHEN I HIT THE GAS PEDAL. I WILL UPLOAD THE DOCUMENTATION YOU ASK FOR WHEN I LOCATE IT.
DOOR LATCHES TO NOT WORK WHEN I WAS DRIVIN MY LEFT DOOR IN THE BACK OPEN WIDE HAD ONE ACCIDENT OF IT
AT APPROXIMATELY 6:30 AM ON OCTOBER 2, 2017 I LEFT FOR WORK. ABOUT 1 MILE DOWN THE ROAD I SUDDENLY LOSS POWER STEERING. I WAS TRAVELLING APPROXIMATELY 35 MPH AND WAS NEGOTIATING A CURVE AT THE TIME OF FAILURE. I FAILED TO NEGOTIATE THE CURVE AND VEERED OFF THE ROAD COMING TO A STOP BEFORE HAVING A COLLISION WITH ANY TREES. I LOO…
Read full complaint
AT APPROXIMATELY 6:30 AM ON OCTOBER 2, 2017 I LEFT FOR WORK. ABOUT 1 MILE DOWN THE ROAD I SUDDENLY LOSS POWER STEERING. I WAS TRAVELLING APPROXIMATELY 35 MPH AND WAS NEGOTIATING A CURVE AT THE TIME OF FAILURE. I FAILED TO NEGOTIATE THE CURVE AND VEERED OFF THE ROAD COMING TO A STOP BEFORE HAVING A COLLISION WITH ANY TREES. I LOOKED AT MY DASH AND THERE WAS A DIGITAL MESSAGE THAT READ POWER STEERING FAULT. I SHUT THE CAR OFF AND TURNED IT BACK ON AND THE PROBLEM PERSISTED SO I RETURNED HOME DRIVING APPROXIMATELY 15 MPH. I WAS ABOUT 1.5 MILES FROM A 9% DOWNGRADE WITH SHARP CURVES; HAD THIS FAULT HAPPENED AT THAT POINT I SURELY WOULD HAVE IMPACTED A GUARD RAIL AT BEST OR GONE OFF OVER A CLIFF AT WORST.
TIE RODS AND SWAY BARS WORE OUT AT 32K MILES AND 5 YEARS ,1 MONTH, AS DID ORIGINAL TIRES.. EXPECTED LONGER WEAR THAN THIS ON SUCH A NEW CAR, AS I HAVE GONE > 100K ON MY PREVIOUS SMALL FORD SUSPENSIONS UNTOUCHED. DEALER WANTED >$1100 TO REPAIR., SO I WENT TO NAPA AFTER MARKET PARTS WITH LIFETIME WARRANTEE TO FIX.
MY CAR HAS ATRANSMISSION PROBLEM KNOWN BY FORD. IT SHUTTERS & STALLS & IS SLOW TO CHANGE GEARS TO THE POINT WHERE IT COULD BE DANGEROUS. I AM AFRAID THAT IT WILL STALL TO THE POINT WHERE IT COULD BE REARENDED. IT HAS BEEN FIXED ONCE AND NEEDS TO BE AGAIN. I THINK IT SHOULD BE RECALLED ALONG WITH THOUSANDS OF OTHERS AND THE TRANS…
Read full complaint
MY CAR HAS ATRANSMISSION PROBLEM KNOWN BY FORD. IT SHUTTERS & STALLS & IS SLOW TO CHANGE GEARS TO THE POINT WHERE IT COULD BE DANGEROUS. I AM AFRAID THAT IT WILL STALL TO THE POINT WHERE IT COULD BE REARENDED. IT HAS BEEN FIXED ONCE AND NEEDS TO BE AGAIN. I THINK IT SHOULD BE RECALLED ALONG WITH THOUSANDS OF OTHERS AND THE TRANSMISSION BE REPLACED. THERE IS ALSO A POPPING NOISE IN THE STEERING WHEN I AM TURNING. THE NEXT QUESTION ASKS WHEN IT HAPPENS AND THE ANSWER IS CONSTANTLY.
I HAVE HAD MULTIPLE INCIDENTS WITH THE TRANSMISSION OF MY 2012 FIESTA, BEGINNING ROUGHLY IN NOVEMBER OF 2014. THE FIRST SPECIFIC INCIDENT I CAN RECALL OCCURRED ON DECEMBER 18, 2014. I WAS DRIVING FROM TOLEDO, OHIO TO THE DETROIT, MI AIRPORT AND BACK. I HAD TWO OTHER PASSENGERS IN MY CAR WHO NOTICED THE VIOLENT SHAKING/SHUDDERING…
Read full complaint
I HAVE HAD MULTIPLE INCIDENTS WITH THE TRANSMISSION OF MY 2012 FIESTA, BEGINNING ROUGHLY IN NOVEMBER OF 2014. THE FIRST SPECIFIC INCIDENT I CAN RECALL OCCURRED ON DECEMBER 18, 2014. I WAS DRIVING FROM TOLEDO, OHIO TO THE DETROIT, MI AIRPORT AND BACK. I HAD TWO OTHER PASSENGERS IN MY CAR WHO NOTICED THE VIOLENT SHAKING/SHUDDERING PROBLEMS THAT MY VEHICLE WAS HAVING WHEN TRYING TO ACCELERATE. THE SHUDDERING OCCURS AT BOTH LOW SPEEDS AND HIGH SPEEDS. THE SHUDDERING DOES NOT OCCUR DAILY BUT ROUGHLY 4-5 DAYS A WEEK, CAUSING DIFFICULTIES WITH ACCELERATION, BREAKING, AND CONTROLLING THE VEHICLE. ABOUT TWO MONTHS AGO I WAS STOPPED AT A RED LIGHT AT A BUSY INTERSECTION. WHEN I BEGAN TO ACCELERATE MY CAR STARTED SHAKING SO VIOLENTLY THAT IT COULD NOT MOVE FORWARD ANY MORE. AT THAT TIME A SEMI-TRUCK WAS COMING UP BEHIND ME AND HAD TO SWERVE TO AVOID HITTING ME. THE SPEED LIMIT AT THIS BUSY INTERSECTION IS 40MPH. AT THIS POINT MY CAR IS UNSAFE TO DRIVE, EVEN THOUGH I HAVE TAKEN IT IN TO THE DEALER MULTIPLE TIMES TO FIX THE TRANSMISSION. SO FAR, THE REPAIRS HAVE BEEN UNSUCCESSFUL AND I AM TOLD THE POTENTIAL PARTS TO FIX THE ISSUE (THE CLUTCH) IS ON BACK ORDER FOR A MINUTE OF 6-8 WEEKS. I WAS TOLD TO CONTINUE DRIVING MY CAR IN THE MEAN TIME, AND THAT NO ONE CAN ASSIST ME AT THIS TIME, EVEN THOUGH I HAVE BEEN TRYING TO RECTIFY THIS ISSUE SINCE JANUARY 2015. ALSO, THE CLUTCH IS NOT GUARANTEED TO FIX THE PROBLEM, AS IT IS THE SAME MAKE AS THE ONE CURRENTLY IN MY CAR.
TL* THE CONTACT OWNS A 2012 FORD FIESTA. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT AND THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE TECHNICIAN RESET THE SYSTEM AND THE STEERING RESUMED NORMAL OPERATION.…
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD FIESTA. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT AND THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE TECHNICIAN RESET THE SYSTEM AND THE STEERING RESUMED NORMAL OPERATION. THE FAILURE MILEAGE WAS 100,793.
I HAVE BOUGHT MY CAR IN 2014 JANUARY FOR A GOOD MILEAGE AND STYLISH LOOK.THE VEHICLE PERFORM WELL FOR COUPLE MONTHS. LATER, I HAVE BROUGHT MY CAR TO THE FORD SERVICE IN 2014 JULY WITH A COMPLAIN OF TRANSMISSION AND SAFETY. SINCE THEN I HAVE BEEN IN AND OUT OF THE DEALERSHIP WITH AUTOMATIC TRANSMISSION PROBLEMS. MY FIESTA NOW HAS…
Read full complaint
I HAVE BOUGHT MY CAR IN 2014 JANUARY FOR A GOOD MILEAGE AND STYLISH LOOK.THE VEHICLE PERFORM WELL FOR COUPLE MONTHS. LATER, I HAVE BROUGHT MY CAR TO THE FORD SERVICE IN 2014 JULY WITH A COMPLAIN OF TRANSMISSION AND SAFETY. SINCE THEN I HAVE BEEN IN AND OUT OF THE DEALERSHIP WITH AUTOMATIC TRANSMISSION PROBLEMS. MY FIESTA NOW HAS 43K MILES AND HAS BEEN TO THE DEALER 2 TIMES FOR TRANSMISSION WORK IF I WOULD HAVE TIME I WOULD DEFINITELY BRING MY CAR TO THE SERVICE MORE. IT IS VERY UNSAFE. THE LAST TWO VISITS HAVE RESULTED IN MAJOR REPAIRS IN AN ATTEMPT TO FIX THE PROBLEM AND STILL THE PROBLEM PERSISTS. THE TRANSMISSION SHUDDERS, HESITATES, AND LURCHES IN STOP AND GO TRAFFIC OR WHEN SLOWING THEN STARTING UP AGAIN SUCH AS AT A STOP LIGHT OR STOP SIGN.AGAIN IT IS VERY UNSAFE TO DRIVE THIS CAR I AM GOING TO CLAIM A LAWSUIT AGAINST THEM. *TR
Official recalls
320V331000 · Latches/locks/linkages:doors:latch
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to determine if the latches are correct. Owner notification letters were mailed on July 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S30.
15V246000 · Latches/locks/linkages:doors:latch
Apr 24, 2015
Ford Motor Company (Ford) notified the agency on April 23, 2015, that they are recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured July 1, 2012, to May 31, 2013, and 2012-2014 Fiesta vehicles manufactured February 1, 2012, to May 31, 2013. On April 30, 2015, Ford expanded the recall to cover an additional 119,567 vehicles, including certain model year 2011 Ford Fiestas manufactured from November 11, 2009, to May 31, 2013 and certain model year 2013 Ford Fusion and Lincoln MKZ vehicles manufactured from February 1, 2012, to June 30, 2012. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will replace all four door latches with an improved part, free of charge. Interim notifications were mailed to owners on June 5, 2015. The recall began on December 18, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S16.
12V488000 · Air Bags
Oct 5, 2012
Ford is recalling certain model year 2011-2013 Fiesta vehicles, manufactured from November 3, 2009 through September 21, 2012. The vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection." The passenger side curtain air bag will not deploy in the event of a side impact collision when the front passenger seat is empty. Although the side curtain air bag system was designed to suppress the side curtain air bag under this scenario, that information is not explained in the owner's guide for these vehicles as required by FMVSS No. 208.
Consequence & remedy
Consequence: An occupant in the right rear seating position will not have coverage from the side curtain air bag in a side impact collision when the front passenger seat is empty, increasing the risk of injury to the right rear occupant.
Remedy: Ford will notify owners and dealers will reprogram the vehicle's software free of charge so that it no longer suppresses the passenger side curtain air bag when the front passenger seat is empty, and consistent with the description in the owner's guide. The safety recall began on October 26, 2012. Owner's may contact Ford at 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ19005 · Door Latch Failures
Opened Dec 19, 2019 · Closed Feb 7, 2022
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch; Structure:body; Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Additional source detail variants (8)
Latches/locks/linkages:doors:latch
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages:doors:latch
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
EA15002 · Door Latch Failure
Opened Feb 27, 2015 · Closed Nov 13, 2015
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch; Structure:body:door
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (6)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Structure:body:door
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Structure:body:door
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 1,102 unique reports related to the alleged problem. There were no injury claims but there were two claims of low speed accidents occurring involving the door opening while driving and damaging property. Ford also submitted 10,883 warranty claims related to door latch failures.Many customers indicated that the door would not latch at all and accordingly they decided to restrain the door by other means (looping the seatbelt through the door, or using rope or tape) in order to drive the vehicle.Some customers also reported multiple door latch failures occurring on the same vehicle on different doors occurring months apart.On April 23rd, 2015 Ford notified ODI that it would conduct a safety recall (15V-246) to remedy door latches failures on certain MY 2011-2014 Ford Fiesta and MY 2013-2014 Ford Fusion and Lincoln MKZ vehicles.According to Ford, the pawl spring tab located within the door latch can break off, or separate and result in a ?door will not close condition.The recalled vehicles include Fiesta vehiclesmanufactured from the start of the MY 2011 to May 2013 and Fusion and MKZ vehicles manufactured from the start of the MY 2013 year until May 2013.In May 2013 Ford reports that it made a manufacturing quality control change, specific to the spring tab, to improve the performance of the existing part.The door latch spring tab was redesigned and the new latch was phased into production in December 2014 with a new part number.Ford will replace all four door latches on the affected vehicles with the new latch design currently in production.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
PE14028 · Door Latch Failure
Opened Sep 11, 2014 · Closed Mar 18, 2015
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch
On September 11, 2014 the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE14-028) to investigate claims of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta vehicles. ODI has received 207 unique reports related to the alleged problem, with sixty-five claiming that the door(s) opened inadvertently while the vehicle was in motion. Two injuries were reported, both caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR), Ford Motor Company (Ford) responded with 451 unique reports related to the alleged defect.One claim involved an incident in which property damage incurred after a door opened while driving at low speed and struck another vehicle. Ford also submitted 1,079 warranty claims related to door latch failures. Additionally Ford informed ODI in its IR response that MY 2013 Ford Fusion and Lincoln MKZ vehicles utilize the same door latch as the MY 2011-13 Fiesta. In it's response, Ford stated that it does not believe that a latched door experiencing this condition will inadvertently unlatch and that there are many overt warning associated with a door that does not latch. ODI noted that the rate of occurrence for this failure is comparable to other door latch failure investigations and questions the effectiveness of warning signals given the number of complainants alleging that the door(s) opened while the vehicle was in motion. Therefore, ODI is upgrading this investigation to an Engineering Analysis (EA15-002) in order to further investigate the scope, frequency and consequence of this failure.ODI reports cited above can be reviewed at www-odi.nhtsa.gov/complaints under the identification (ODI) numbers listed in the attached document.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
On September 11, 2014 the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE14-028) to investigate claims of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta vehicles. ODI has received 207 unique reports related to the alleged problem, with sixty-five claiming that the door(s) opened inadvertently while the vehicle was in motion. Two injuries were reported, both caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR), Ford Motor Company (Ford) responded with 451 unique reports related to the alleged defect.One claim involved an incident in which property damage incurred after a door opened while driving at low speed and struck another vehicle. Ford also submitted 1,079 warranty claims related to door latch failures. Additionally Ford informed ODI in its IR response that MY 2013 Ford Fusion and Lincoln MKZ vehicles utilize the same door latch as the MY 2011-13 Fiesta. In it's response, Ford stated that it does not believe that a latched door experiencing this condition will inadvertently unlatch and that there are many overt warning associated with a door that does not latch. ODI noted that the rate of occurrence for this failure is comparable to other door latch failure investigations and questions the effectiveness of warning signals given the number of complainants alleging that the door(s) opened while the vehicle was in motion. Therefore, ODI is upgrading this investigation to an Engineering Analysis (EA15-002) in order to further investigate the scope, frequency and consequence of this failure.ODI reports cited above can be reviewed at www-odi.nhtsa.gov/complaints under the identification (ODI) numbers listed in the attached document.
Latches/locks/linkages
On September 11, 2014 the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE14-028) to investigate claims of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta vehicles. ODI has received 207 unique reports related to the alleged problem, with sixty-five claiming that the door(s) opened inadvertently while the vehicle was in motion. Two injuries were reported, both caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR), Ford Motor Company (Ford) responded with 451 unique reports related to the alleged defect.One claim involved an incident in which property damage incurred after a door opened while driving at low speed and struck another vehicle. Ford also submitted 1,079 warranty claims related to door latch failures. Additionally Ford informed ODI in its IR response that MY 2013 Ford Fusion and Lincoln MKZ vehicles utilize the same door latch as the MY 2011-13 Fiesta. In it's response, Ford stated that it does not believe that a latched door experiencing this condition will inadvertently unlatch and that there are many overt warning associated with a door that does not latch. ODI noted that the rate of occurrence for this failure is comparable to other door latch failure investigations and questions the effectiveness of warning signals given the number of complainants alleging that the door(s) opened while the vehicle was in motion. Therefore, ODI is upgrading this investigation to an Engineering Analysis (EA15-002) in order to further investigate the scope, frequency and consequence of this failure.ODI reports cited above can be reviewed at www-odi.nhtsa.gov/complaints under the identification (ODI) numbers listed in the attached document.