NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
34 reportsClear category filter89,000 miles · May 15, 2007
Electrical System
TL*THE CONTACT OWNS A 1990 FORD F150. WHEN THE ENGINE SHUT OFF, THE VEHICLE CONTINUED TO RUN. THE DEALER INFORMED THE CONTACT THAT HIS VEHICLE WAS NOT A PART OF RECALL NUMBER 96V071000 (FOR THE IGNITION) AND HE WOULD NOT INSPECT THE VEHICLE. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 90,000. THE PURCHASE DAT…
Read full complaint
TL*THE CONTACT OWNS A 1990 FORD F150. WHEN THE ENGINE SHUT OFF, THE VEHICLE CONTINUED TO RUN. THE DEALER INFORMED THE CONTACT THAT HIS VEHICLE WAS NOT A PART OF RECALL NUMBER 96V071000 (FOR THE IGNITION) AND HE WOULD NOT INSPECT THE VEHICLE. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 90,000. THE PURCHASE DATE OF THE VEHICLE WAS UNKNOWN.
NHTSA ODI #10190774
Mileage unknown · Nov 18, 2002
Electrical System
BROUGHT THIS TRUCK USED WAS ADVISED OF RECALL, NEED TO GET COPY OF TSB TO TAKE TO DEALER TO GET FIXED. DT
NHTSA ODI #769835
Mileage unknown · Jul 14, 2002
Electrical SystemFireInjury
VEHICLE DRIVEN APPROXIMATELY 10 MILES AND PARKED AT WHICH TIME SMOKE WAS OBSERVED FROM ENGINE COMPARTMENT. WHEN HOOD WAS OPENED, ALTERNATOR AND ASSOCIATED WIRING BURST INTO FLAMES. OPERATOR SUSTAINED MINOR BURNS ON HAND.*AKI
NHTSA ODI #764203
Mileage unknown · Apr 23, 2002
Electrical SystemFuel System, Gasoline
HAVE BEEN TO FORD DEALER FOR TWO RECALLS, IGNITION AND FUEL REGULATOR. NO CHARGE TO ME. GAS IS STILL COMING OUT OF THE FILLER NECK OF THE TANK "I AM NOT USING, I SWITCH TO THAT TANK AND GAS COMES OUT OF THE OTHER TANK--THAT I AM NOT USING. THE DEALER SAYS THIS IS NOT A RECALL AND I NEED TO PAY FOR NEW FUEL PUMPS IN EACH TANK. I …
Read full complaint
HAVE BEEN TO FORD DEALER FOR TWO RECALLS, IGNITION AND FUEL REGULATOR. NO CHARGE TO ME. GAS IS STILL COMING OUT OF THE FILLER NECK OF THE TANK "I AM NOT USING, I SWITCH TO THAT TANK AND GAS COMES OUT OF THE OTHER TANK--THAT I AM NOT USING. THE DEALER SAYS THIS IS NOT A RECALL AND I NEED TO PAY FOR NEW FUEL PUMPS IN EACH TANK. I DON'T UNDERSTAND THAT SINCE THE TRUCK IS GETTING GAS FINE, JUST TO MUCH AND BEING RETURNED TO THE WRONG TANK. NOT BEING RETURNED TO THE TANK THAT IS BEING USED. I FEEL THAT THIS SHOULD BE A RECALL AND SHOULD NOT COST ME $1000.00. HOPE SOMEONE CAN HELP ME.
NHTSA ODI #761107
Mileage unknown · Aug 28, 2001
Electrical System
IGNITION SWITCH VERY DIFFICULT TO TURN TO START THE VEHICLE, HAVE TO USE A PAIR OF PLIERS TO TURN IT. *AK
NHTSA ODI #751304
Mileage unknown · Apr 17, 2001
Electrical SystemEngine And Engine Cooling
VEHICLE WAS STALLING AT 45 MPH, NOT ABLE TO START AGAIN UNTIL VEHICLE HAD COOLED DOWN, 35-45 MINUTES. THEN, VEHICLE WOULD RUN FOR 20-25 MINUTES AND STALL AGAIN. DEALER REPLACED IGNITION MODULE AND COIL.*AK *JB
NHTSA ODI #886074
Mileage unknown · Mar 5, 2001
Electrical System
RECALL 96 V 017 000. IGNITION SWITCH WAS REPLACED UNDER RECALL IN 1997. JUST RECENTLY SMOKE STARTED TO COME FROM IGNITION. DEALER REPLACED SOLENOID STARTER, AND IGNITION SWITCH. *AK *SLC
NHTSA ODI #882090
Mileage unknown · Oct 29, 1999
Electrical SystemFire
WHILE VEHICLE WAS PARKED IN THE DRIVEWA, CONSUMER NOTICED SMOKE COMING FROM THE CAB OF THE VEHICLE, VEHICLE CAUGHT ON FIRE AND BURNED DUE TO AN ELECTRICAL SYSTEM SHORT. *AK
NHTSA ODI #852168
Mileage unknown · Mar 10, 1999
Electrical SystemPower Train
DEFECTIVE HEADLIGHT DIMMER SWITCH DRAINED BATTERY (INITIALLY A HIGH RESISTANCE SHORT) WHILE VEHICLE WAS PARKED. TURNED INTO A LOW RESISTANCE SHORT WHEN TROUBLESHOOTING PROBLEM AND GENERATED SMOKE IN INSTRUMENT PANEL BEFORE BLOWING FUSE. SECOND PROBLEM INVOLVING THE GEAR SELECT SENSOR ON THE TRANSMISSION CAUSED THE VEHICLE TO G…
Read full complaint
DEFECTIVE HEADLIGHT DIMMER SWITCH DRAINED BATTERY (INITIALLY A HIGH RESISTANCE SHORT) WHILE VEHICLE WAS PARKED. TURNED INTO A LOW RESISTANCE SHORT WHEN TROUBLESHOOTING PROBLEM AND GENERATED SMOKE IN INSTRUMENT PANEL BEFORE BLOWING FUSE. SECOND PROBLEM INVOLVING THE GEAR SELECT SENSOR ON THE TRANSMISSION CAUSED THE VEHICLE TO GO INTO NEUTRAL UNPREDICTABLY.
NHTSA ODI #704255
Mileage unknown · Sep 16, 1997
Electrical System
TRUCK PARKED, NO LONGER THAN 10 MINUTES, CRANKED BUT DID NOT START DUE TO UNDER DASH WIRING MELTING/OVERHEATING. *AK
NHTSA ODI #523255
NHTSA investigations
10EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
RQ98008 · Ford F-SERIES Dual Fuel Tank Leakage
Opened May 29, 1998 · Closed Nov 4, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL REMEDY MAY BE INADEQUATE.FURTHER INVESTIGATION IS NEEDED.THIS INVESTIGATION IS UPGRADED TO EA99-032.CLICK ON DOCUMENT SEARCH BUTTON FOR ADDITIONAL INFORMATION.
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA92029 · Front Seat Back Failure
Opened Aug 27, 1992 · Closed Oct 29, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
EA91044 · Loss Of Brake Effectivenes
Opened Oct 30, 1991 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
EA91031 · Fuel Expulsion
Opened Jun 26, 1991 · Closed Nov 1, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91077 · Loss Of Brake Effectivenes
Opened May 23, 1991 · Closed Oct 31, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91064 · Transmission Fluid Fires
Opened Apr 9, 1991 · Closed Jul 5, 1991
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE91017 · Ford Truck Inconsistent Vehicle Control.
Opened Nov 27, 1990 · Closed Apr 17, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
SEE CLOSE RESUME
Illustration