Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 17 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Diesel. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
17 reports
Mileage unknown · May 9, 2024
StructureSuspensionUnknown Or Other
Ford Motor Company has had a known issue with the truck frames cracking on the F-550 chassis. They acknowledged it by doing a recall, which either replaced or repaired the chassis frame or installed reinforcement braces if no cracks were visible. The recall expired in September of 2023. In October 2023 we noticed a crack on t…
Read full complaint
Ford Motor Company has had a known issue with the truck frames cracking on the F-550 chassis. They acknowledged it by doing a recall, which either replaced or repaired the chassis frame or installed reinforcement braces if no cracks were visible. The recall expired in September of 2023. In October 2023 we noticed a crack on the frame just outside the recall reinforcement brace that Ford-certified technicians installed. We found another in November (reinforcement brace installed) and another in January (with Ford's new and improved frame produced due to a recall issue). Ford has denied making the repairs since the original warranty expired, even though this was the same related issue. We have been dealing with Ford Motor Company since October in hopes of resolving the issue but they continue to give us any resolution. The problem has not only caused a burden on our workforce but also caused great safety concerns. With Ford avoiding responsibility, they are allowing trucks to operate daily on our highway system, which becomes a safety concern for not only the driver but for many other motorists. The problem existed, but the issue was not resolved, all we are asking is that they take responsibility for making the repairs and permanently resolving the issue for the safety of all motorists.
NHTSA ODI #11587794
Mileage unknown · Apr 15, 2024
Structure
See attached document for complaint
NHTSA ODI #11583076
15,000 miles · Aug 10, 2022
Fuel System, Diesel
The contact owns a 2020 Ford F-550. The contact stated while driving approximately 30 MPH, the vehicle emitted a strong odor of fuel into the cabin. The contact stated that other drivers were pointing at the underside of the vehicle. The contact pulled over and observed fuel leaking from a filter, the underside of the hood and e…
Read full complaint
The contact owns a 2020 Ford F-550. The contact stated while driving approximately 30 MPH, the vehicle emitted a strong odor of fuel into the cabin. The contact stated that other drivers were pointing at the underside of the vehicle. The contact pulled over and observed fuel leaking from a filter, the underside of the hood and engine compartment on the driver's side were covered in fuel. The contact stated no warning light was illuminated. The contact called a dealer and was advised to change the filter. The contact stated that the vehicle experienced a failure a second time and had the vehicle towed to the same dealer. The dealer diagnosed that there was rust in the fuel filter which had contaminated the fuel injection system. The vehicle had not been repaired. The contact had contacted a second dealer and was advised that the failure could be related to NHTSA Campaign Number: 22V013000 (Fuel System, Diesel). The manufacturer had been informed of the failure. The failure mileage was approximately 15,000.
NHTSA ODI #11478581
Mileage unknown · Jul 14, 2022
Visibility
The contact owns a 2020 Ford F-550. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. T…
Read full complaint
The contact owns a 2020 Ford F-550. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11473867
2,200 miles · Jun 23, 2022
Suspension
The contact owns a 2021 Forest River Georgetown constructed on a 2020 Ford F53 chassis. The contact stated that the weight of the motorhome was falsely advertised and that the motorhome was over the weight limit for the chassis it was built. The contact stated that the motorhome OCCC (Occupant Carrying Capacity Certificate) adve…
Read full complaint
The contact owns a 2021 Forest River Georgetown constructed on a 2020 Ford F53 chassis. The contact stated that the weight of the motorhome was falsely advertised and that the motorhome was over the weight limit for the chassis it was built. The contact stated that the motorhome OCCC (Occupant Carrying Capacity Certificate) advertised for the motorhome was 19,208; however, the contact weighed the motorhome with the motorhome completely empty and the certified weight was 21,080. The contact stated that while driving the motorhome, an abnormal clanking and popping noise was coming from the vehicle while driving. The contact stated that the vehicle would push its way through corners and turns due to the weight of the motorhome. The dealer was notified of the failure and stated that they were unable to perform the needed repair. Both the motorhome and chassis manufacturer were notified of the failure. The contact stated that the chassis manufacturer claimed that the motorhome was overweight and the cause of the failure. The motorhome manufacturer claimed that the weight was correct and that there was no failure with the vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 2,200.
NHTSA ODI #11470720
80,000 miles · Jun 13, 2022
Power Train
The contact owns a 2020 Ford F-550. The contact stated while driving 45 MPH, the transmission started slipping. The check engine warning light was illuminated. The contact pulled to the side of the roadway. The vehicle was towed to an independent mechanic. The vehicle was taken to an independent mechanic where it was diagnosed t…
Read full complaint
The contact owns a 2020 Ford F-550. The contact stated while driving 45 MPH, the transmission started slipping. The check engine warning light was illuminated. The contact pulled to the side of the roadway. The vehicle was towed to an independent mechanic. The vehicle was taken to an independent mechanic where it was diagnosed that the planetary ring gear needed to be replaced under NHTSA Campaign Number: 22V256000 (Power Train). The VIN was included in the recall. The vehicle was then towed to the local dealer who informed the contact that they could not accommodate the vehicle for the recall repair due to the size of the vehicle. The vehicle was towed to a second dealer, Northside Ford Truck Sales, Inc. (6221 NE Columbia Blvd, Portland, OR 97218) who informed the contact that the vehicle would be repaired at his own expense. The manufacturer was notified of the failure and advised the contact to follow up with the dealer. The vehicle was not repaired. The failure mileage was approximately 80,000.
NHTSA ODI #11469065
2,393 miles · Apr 21, 2021
Service Brakes
ELECTRONIC STABILITY CONTROL (ESC) LIGHT CAME ON AND STAYED ON DURING NORMAL, STRAIGHT AND LEVEL HIGHWAY DRIVING AT 60 MPH, INDICATING AN ESC SYSTEM MALFUNCTION. THE LIGHT CAME ON AFTER ABOUT 20 MILES OF HIGHWAY DRIVING AND REMAINED ON FOR THE REMAINING 12 MILES OF MY JOURNEY. AFTER BEING PARKED OVERNIGHT THE ESC LIGHT OPERATED…
Read full complaint
ELECTRONIC STABILITY CONTROL (ESC) LIGHT CAME ON AND STAYED ON DURING NORMAL, STRAIGHT AND LEVEL HIGHWAY DRIVING AT 60 MPH, INDICATING AN ESC SYSTEM MALFUNCTION. THE LIGHT CAME ON AFTER ABOUT 20 MILES OF HIGHWAY DRIVING AND REMAINED ON FOR THE REMAINING 12 MILES OF MY JOURNEY. AFTER BEING PARKED OVERNIGHT THE ESC LIGHT OPERATED NORMALLY WHEN THE ENGINE WAS RESTARTED WHILE PARKED.
Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Consequence & remedy
Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.
Additional source detail variants (2)
Power Train:driveline:differential Unit
Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2020 Ford F-550 Problems, Complaints & Recalls | Skip That Year
Illustration