Fuel System, Diesel. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports1 fire reports0 injury reports

Power Train complaints

3 reports

Clear category filter

Mileage unknown · Oct 8, 2025

Electrical SystemEnginePower Train

Read full complaint

At ~93,000 miles, my 2020 Ford F-550 (7.3L “Godzilla” V8) suffered catastrophic engine failure due to a roller lifter bearing failure, causing internal valvetrain damage and requiring full engine replacement. Ford dealer stated they recommended 90% coverage of the repair under goodwill through corporate, but later reduced coverage to 40% without explanation. After repairs, Ford corporate recommended a 3-year/36,000-mile PremiumCare warranty, then rescinded it a week later and offered only free oil changes. The 7.3L engine in my truck shares the same design as the F-53/F-59 motorhome chassis, which have multiple Technical Service Bulletins (TSBs) for lifter bearing failure, overheating of cylinders #2–3, and low oil pressure at idle. My vehicle shows identical symptoms but was excluded from those VIN ranges, suggesting Ford is segmenting related defects to limit recall exposure. Inspection revealed a cracked and arcing spark-plug wire on cylinder #2, matching the motorhome TSB’s overheating issue. This arcing poses a fire risk and likely contributed to localized heat and mechanical failure. The truck was often driven in Eco Mode, which holds low RPMs under load. This can increase cylinder pressure, reduce oil flow, and exacerbate heat in cylinders #2–3—factors that align with the failure pattern. This combination of design-related overheating, lifter bearing failure, oil-pressure fluctuation, and spark-wire arcing presents a clear safety hazard. Engine stall or fire could occur under towing or heavy-load conditions. NHTSA investigation is warranted into Ford’s 7.3L Godzilla engine design and VIN-exclusion practices.

NHTSA ODI #11692097

100,000 miles · May 14, 2025

Power Train

Read full complaint

The contact owns a 2020 Ford F-550. The contact stated that while starting the vehicle, the vehicle unintentionally rolled away while the transmission was in park(P). No warning light was illuminated. Additionally, the vehicle jerked while driving uphill. The vehicle also jerked violently while downshifting from third to second gear. The vehicle was taken to the dealer, who determined that the transmission needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V256000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.

NHTSA ODI #11661025

80,000 miles · Jun 13, 2022

Power Train

Read full complaint

The contact owns a 2020 Ford F-550. The contact stated while driving 45 MPH, the transmission started slipping. The check engine warning light was illuminated. The contact pulled to the side of the roadway. The vehicle was towed to an independent mechanic. The vehicle was taken to an independent mechanic where it was diagnosed that the planetary ring gear needed to be replaced under NHTSA Campaign Number: 22V256000 (Power Train). The VIN was included in the recall. The vehicle was then towed to the local dealer who informed the contact that they could not accommodate the vehicle for the recall repair due to the size of the vehicle. The vehicle was towed to a second dealer, Northside Ford Truck Sales, Inc. (6221 NE Columbia Blvd, Portland, OR 97218) who informed the contact that the vehicle would be repaired at his own expense. The manufacturer was notified of the failure and advised the contact to follow up with the dealer. The vehicle was not repaired. The failure mileage was approximately 80,000.

NHTSA ODI #11469065

Official recalls

20V099000 · Power Train:driveline:differential Unit; Power Train:driveline:driveshaft

Feb 21, 2020

Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.

Consequence & remedy

Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.

Additional source detail variants (2)

Power Train:driveline:differential Unit

Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.

Power Train:driveline:driveshaft

19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly

Aug 28, 2019

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence & remedy

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Additional source detail variants (2)

Seats:mid/rear Assembly

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Seats:front Assembly:recliner

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24014 · Sogefi Secondary Diesel Fuel Filter Leak

Opened May 9, 2024 · No close date supplied

Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter

The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Fuel System, Diesel

Fuel System, Other:fuel Filter