Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
30,000 miles · Jul 28, 2015
Service Brakes
TL* THE CONTACT OWNS A 1996 FORD F-53. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOOR UPON DEPRESSING AND THE VEHICLE FAILED TO SLOW DOWN UNTIL THE EMERGENCY BRAKE WAS ENGAGED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE FRONT BRAKE CALI…
Read full complaint
TL* THE CONTACT OWNS A 1996 FORD F-53. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOOR UPON DEPRESSING AND THE VEHICLE FAILED TO SLOW DOWN UNTIL THE EMERGENCY BRAKE WAS ENGAGED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE FRONT BRAKE CALIPERS WERE REPLACED. THE CONTACT MENTIONED THAT TWO YEARS AFTER THE REPAIR WAS PERFORMED, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 09/17/15*LJ UPDATED 12/13/2017*CN
NHTSA ODI #10744397
Mileage unknown · Jul 8, 2002
Fuel System, Gasoline
WHIRRING NOISE FROM FUEL PUMP AS DESCRIBED IN FORD TECHNICAL BULLETIN AND LOSS OF SENDING UNIT SIGNAL TO FUEL GAUGE. PARTS DEPT AND SERVISOR FOR LOCAL FORD DEALER ADMIT SEVERAL UNITS REPLACED USING SPECIFIED FIELD REVISION PARTS SEPARATING FUEL PUMP AND SENDING UNIT USING NEW DESIGN JUMPER HARNESS. NOT COVERED BY ANY KNOWN RE…
Read full complaint
WHIRRING NOISE FROM FUEL PUMP AS DESCRIBED IN FORD TECHNICAL BULLETIN AND LOSS OF SENDING UNIT SIGNAL TO FUEL GAUGE. PARTS DEPT AND SERVISOR FOR LOCAL FORD DEALER ADMIT SEVERAL UNITS REPLACED USING SPECIFIED FIELD REVISION PARTS SEPARATING FUEL PUMP AND SENDING UNIT USING NEW DESIGN JUMPER HARNESS. NOT COVERED BY ANY KNOWN RECALL. COST TO UNFORTUNATE CONSUMER, $371.80 FOR PARTS PLUS $75.00 PER HOUR WITH NO TIME ESTIMATE. ANY MALFUNCTION IN THE FULE TANK AND DELIVERY SYSTEM ALONG WITH THE GAUGING SYSTEM POWERED BY ELECTRICITY IS A MAJOR SAFETY PROBLEM AS I SEE IT AS A FORMER OSHA ASSOCIATE (WITH MY FORMER EMPLOYER, BEFORE RETIREMENT).*AK
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 Ford F-53 Problems, Complaints & Recalls | Skip That Year
Illustration